Characteristics of two-stage segregation auto-cascade refrigeration system

RUI Shengjun; ZHANG Hua; ZHANG Qinggang; HUANG Lihao

doi:10.3969/j.issn.0438-1157.2013.06.018

您当前的位置：

首页 >

文章列表页 >

Characteristics of two-stage segregation auto-cascade refrigeration system

更新时间：2025-12-10

- Characteristics of two-stage segregation auto-cascade refrigeration system
- CIESC Journal Issue 6, Pages: 2029-2035(2013)
- 作者机构：
  
  1. 上海理工大学制冷技术研究所,上海,200093
  2. 河南科技大学车辆与动力工程学院,河南,洛阳,471023
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2013.06.018
  CLC： B657.3
- Online First：05 June 2013，
  
  Published：05 June 2013
- 稿件说明：
移动端阅览
RUI Shengjun, ZHANG Hua, ZHANG Qinggang, et al. Characteristics of two-stage segregation auto-cascade refrigeration system[J]. CIESC Journal, 2013, (6): 2029-2035.
DOI：

RUI Shengjun, ZHANG Hua, ZHANG Qinggang, et al. Characteristics of two-stage segregation auto-cascade refrigeration system[J]. CIESC Journal, 2013, (6): 2029-2035. DOI： 10.3969/j.issn.0438-1157.2013.06.018.

摘要

以两级分凝自复叠制冷系统为研究对象

分析了三元混合工质空间和平面汽液平衡特性

对三元混合工质的组分变化规律及运行特性进行了理论研究。应用混合工质物性分析软件Refprop 8.0根据冷凝蒸发器冷量平衡特性讨论了混合工质组分比例

得到比较合理的配比组成65/20/15。通过5个平面压焓图的空间变化关系分析了自复叠制冷系统工质分离、混合和运行特性。根据实验研究

循环系统高低压旁通和相分离器出口气体旁通可有效改善压缩机启动初期系统压力和温度过高的问题。对系统各级节流降温过程进行了分析

并对压缩机的吸排气温度和蒸发温度进行了研究。

Abstract

A two-stage segregation auto-cascade refrigeration system was studied.The vapor-liquid equilibrium characteristics of a ternary mixed-refrigerant

composition change rules and operating characteristics of the ternary system were investigated.Refprop 8.0

general software for mixed-refrigerant property analysis with abroad applications

was used.The composition proportion of mixed-refrigerant was discussed according to the cooling capacity balance characteristics of evaporative condense and a reasonable proportion was obtained.The separation

mixing and operating characteristics of auto-cascade refrigeration system mixed-refrigerant were analyzed on the basis of spatial changes of five plane pressure-enthalpy diagrams.According to the experimental research

high-low pressure bypass and phase separator outlet vapor bypass of circulatory system could effectively improve the high discharge pressure and discharge temperature in the starting process.The throttle cooling process of each stage was analyzed

and the suction and discharge temperatures and evaporative temperature of compressor were studied.

关键词

Keywords

references

Views

473

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Investigation on effect of fractionation on performance of two-stage separation-based auto-cascade refrigeration cycle

Perfromance assessment of auto-cascade cycle integrating fractionation and flash separation

Experimental study on startup dynamic characteristics of R1150/R600a auto-cascade refrigeration cycle

Performance of R23/R134a auto-cascade refrigeration cycle with one-step dephlegmation and two-step dephlegmation

Overall heat transfer coefficient of plate-fin heat exchanger during a mixed refrigerant cryogenic process in low quality

Related Author

LIU Xiaoqing

TAN Yingying

LI Xiuzhen

ZANG Ziqing

LI Yinlong

LIU Guoqiang

YAN Gang

LIU Xiaoqing

Related Institution

Institute of Building Energy and Thermal Science and Technology, Henan University of Science and Technology

School of Energy and Power Engineering, Xi’an Jiaotong University

Institute of Building Energy and Thermal Science, Henan University of Science and Technology

Institute of Heat Pump, Air-Conditioning and Refrigeration, Henan University of Science and Technology

School of Civil Engineering, Hunan University

⁰