Evaporation process of brine droplet at reducing pressure

LUO Qian; BI Qincheng; HAN Yanning; ZHANG Qiaoling

doi:10.3969/j.issn.0438-1157.2013.06.014

您当前的位置：

首页 >

文章列表页 >

Evaporation process of brine droplet at reducing pressure

更新时间：2025-12-10

- Evaporation process of brine droplet at reducing pressure
- CIESC Journal Issue 6, Pages: 2001-2006(2013)
- 作者机构：
  
  西安交通大学能源与动力工程学院,陕西,西安,710049
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2013.06.014
  CLC： K121
- Online First：05 June 2013，
  
  Published：05 June 2013
- 稿件说明：
移动端阅览
LUO Qian, BI Qincheng, HAN Yanning, et al. Evaporation process of brine droplet at reducing pressure[J]. CIESC Journal, 2013, (6): 2001-2006.
DOI：

LUO Qian, BI Qincheng, HAN Yanning, et al. Evaporation process of brine droplet at reducing pressure[J]. CIESC Journal, 2013, (6): 2001-2006. DOI： 10.3969/j.issn.0438-1157.2013.06.014.

摘要

盐水溶液在降压环境下的蒸发过程的研究

主要集中在海水淡化领域的降膜蒸发过程应用方面和工业制盐方面的平坦表面的蒸发过程的研究。而本文主要集中研究各种实验因素对于液滴温度变化的影响。对于多组分液滴降压环境下相变过程的研究

实验采用浓度为15%和6%的盐水溶液作为一组比较工质

在初始环境压力为94.5～97 kPa

最终环境压力范围为50～3000 Pa

液滴的初始温度范围为7～30℃

初始直径范围为1～3 mm的条件下进行实验。通过实验数据分析可知:盐水液滴在降压蒸发过程中的中心温度变化有析盐和不析盐两种现象

随着水分不断地蒸发

当液滴浓度达到22.4%而且温度足够低时就会析出盐分

否则

不会出现析盐现象;同时分析不同浓度、不同最终环境压力、不同初始温度和不同初始直径对液滴相变过程和温度变化的影响

并且观察环境压力降低和液滴温度变化之间的关系。

Abstract

The study on evaporation processes of brine solution at reducing pressure mainly concentrates on falling film evaporation in the sea-water desalination and flat surface evaporation in industrial processes.In this study

the phase change of droplets was investigated.Various factors influencing the temperature of multicomponent droplet were examined experimentally

with brine solutions of 15% and 6% as working medium

initial environmental pressure of 94.5—97 kPa and final pressure of 50—3000 Pa

initial droplet temperature of 7—30℃

and initial diameter of 1—3 mm.The experimental data show that with the change of central temperature of salt water droplets at reducing pressure

the process can be divided to that with salting and without salting.As the water evaporates

reaching droplet density of 22.4% and temperatures low enough

the salt precipitated

otherwise the salting would not appear.At different concentrations

final pressures

initial temperatures and sizes

the relationship between the temperature change in the phase change of droplet and the environmental pressure was obtained.

关键词

Keywords

references

Views

489

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Research on solidification characteristics of particles formed by dropping molten polyethylene glycol into oil pool

Investigation on the dynamics and vaporization characteristics of droplet impact on the heated wall surface

Heat transfer characteristics of oblique droplet impact on liquid film

Modeling and experimental study on the evaporation characteristics of liquid droplets subject to thermal convection

Preparation of aqueous two-phase droplets in improved T-shaped microchannel

Related Author

ZHENG Zhangjing

YANG Qingyun

YAN Shixing

SHI Yuchen

XU Yang

WANG Tai

SUN Yitie

LI Shengrui

Related Institution

School of Low-carbon Energy and Power Engineering, China University of Mining and Technology

Energy Storage and Novel Technology of Electrical Engineering Department, China Electric Power Research Institute Limited Company

College of Energy Power and Mechanical Engineering, North China Electric Power University

School of Energy and Power Engineering, Dalian University of Technology

Key Laboratory of Marine Intelligent Equipment and System, Ministry of Education, Shanghai Jiao Tong University

⁰