Minimum pressure drop velocity and stability analysis in pneumatic conveying of pulverized coal in commercial-scale horizontal pipe

XIE Kai; GUO Xiaolei; CONG Xingliang; LIU Kai; TAO Shunlong; LU Haifeng; GONG Xin

doi:10.3969/j.issn.0438-1157.2013.06.010

您当前的位置：

首页 >

文章列表页 >

Minimum pressure drop velocity and stability analysis in pneumatic conveying of pulverized coal in commercial-scale horizontal pipe

更新时间：2025-12-10

- Minimum pressure drop velocity and stability analysis in pneumatic conveying of pulverized coal in commercial-scale horizontal pipe
- CIESC Journal Issue 6, Pages: 1969-1975(2013)
- 作者机构：
  
  华东理工大学煤气化及能源化工教育部重点实验室,上海,200237
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2013.06.010
  CLC： Q536
- Online First：05 June 2013，
  
  Published：05 June 2013
- 稿件说明：
移动端阅览
XIE Kai, GUO Xiaolei, CONG Xingliang, et al. Minimum pressure drop velocity and stability analysis in pneumatic conveying of pulverized coal in commercial-scale horizontal pipe[J]. CIESC Journal, 2013, (6): 1969-1975.
DOI：

XIE Kai, GUO Xiaolei, CONG Xingliang, et al. Minimum pressure drop velocity and stability analysis in pneumatic conveying of pulverized coal in commercial-scale horizontal pipe[J]. CIESC Journal, 2013, (6): 1969-1975. DOI： 10.3969/j.issn.0438-1157.2013.06.010.

摘要

采用压缩空气作为输送介质

在工业级水平管(内径50 mm)上开展了粉煤密相气力输送实验研究。在实验获得最小压降速度基础上

通过电容层析成像系统观察到

随着表观气速降低而存在分层流、沙丘流、移动床流以及栓塞流4种流型。不同流型压力信号的概率密度分布和功率谱密度分析表明

压力信号的波动特征与流型紧密联系;由于流动形态的变化

存在由稳定输送过渡到不稳定输送的临界气速

且该速度小于最小压降速度。

Abstract

Dense-phase pneumatic conveying of pulverized coal was investigated in an commercial-scale horizontal pipe (50 mm I.D.) by using compressed air as carrier gas.Minimum pressure drop velocity was obtained from the Zenz-type phase diagram

which was influenced by solids mass flux significantly.Based on electrical capacitance tomography (ECT) system

the flow in the experimental range was classified into four regimes:stratified flow

dune flow

moving bed flow and slug flow.Using probability density function (PDF) and power spectral density (PSD) function to analyze the pressure signals of typical cases

pressure fluctuations were well correlated with flow patterns.The relative stability characteristics of different operating conditions showed that the critical velocity between stable and unstable conveying was smaller than minimum pressure drop velocity due to the transitions of flow patterns.

关键词

Keywords

references

Views

420

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Preparation of Zn-CuOx/MgO-SiO2 aerogel catalyst with strong electron transfer ability and its catalytic ozonation mechanism and toxicity evaluation on sulfamethoxazole

Deformation and fragmentation characteristics of liquid marbles under the action of non-uniform electric field

CN-doped CoRuO electrocatalysts for efficient acidic oxygen evolution reaction

Mn/Al modified calcium-based energy storage materials with high stability

Study on continuous alcoholysis of fructose to methyl lactate over TS-1 and In-TS-1

Related Author

ZHANG Lanhe

SHI Bing

LIU Hui

WU Jiaming

ZHANG Mingshuang

CAO Xue

ZUO Ziwen

WANG Junfeng

Related Institution

School of Chemical Engineering, Northeast Electric Power University

School of Hydraulic Engineering, Guangxi Vocational College of Water Resources and Electric Power

School of Energy and Power Engineering, Jiangsu University

Shanxi Key Laboratory of Gas Energy Efficient and Clean Utilization, College of Chemistry and Chemical Engineering, Taiyuan University of Technology

School of Chemical Engineering and Technology, Xi’an Jiaotong University

⁰