Filtration mechanism of membranes in combination of catalytic wet air oxidation and membrane filtration

LI Xiaoyi; WU Sijun; SUN Dezhi

doi:10.3969/j.issn.0438-1157.2013.05.020

您当前的位置：

首页 >

文章列表页 >

Filtration mechanism of membranes in combination of catalytic wet air oxidation and membrane filtration

更新时间：2025-12-10

- Filtration mechanism of membranes in combination of catalytic wet air oxidation and membrane filtration
- CIESC Journal Issue 5, Pages: 1642-1650(2013)
- 作者机构：
  
  北京林业大学水体污染源控制技术北京市重点实验室,北京,100083
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2013.05.020
  CLC： 505
- Online First：05 May 2013，
  
  Published：05 May 2013
- 稿件说明：
移动端阅览
LI Xiaoyi, WU Sijun, SUN Dezhi. Filtration mechanism of membranes in combination of catalytic wet air oxidation and membrane filtration[J]. CIESC Journal, 2013, (5): 1642-1650.
DOI：

LI Xiaoyi, WU Sijun, SUN Dezhi. Filtration mechanism of membranes in combination of catalytic wet air oxidation and membrane filtration[J]. CIESC Journal, 2013, (5): 1642-1650. DOI： 10.3969/j.issn.0438-1157.2013.05.020.

摘要

采用湿式催化氧化/膜过滤组合工艺

以Mo-Zn-Al-O粉末作为催化剂降解阳离子红GTL模拟染料废水

探讨在膜过滤过程中平均孔径为0.1 μm的微滤和0.022 μm的超滤聚偏氟乙烯(PVDF)中空纤维膜的过滤机理。实验结果表明

两种膜过滤组合工艺对染料的降解效果均优于单独湿式催化氧化

0.01 MPa恒压条件下运行120 min后微滤和超滤的膜通量分别衰减了26.63%和16.48%

其原因是粉末催化剂可在微滤膜孔内部沉积形成中间阻塞过滤

后在表面形成滤饼层;而在超滤膜表面仅形成滤饼层。通过实验结果对膜阻力进行计算

可知在相同反应过程后微滤膜产生的不可逆阻力大于超滤膜。在不同反应条件下

催化剂的沉积量与膜阻力呈现线性相关。

Abstract

The treatment of simulated cationic red GTL dye wastewater was conducted by coupling technology of catalytic wet air oxidation(CWAO)with membrane filtration

using Mo-Zn-Al-O as catalyst.The filtration mechanism of polyvinylidene fluoride hollow fiber microfiltration(MF)membranes with average pore size 0.1 μm and ultrafiltration(UF)membranes with average pore size 0.022 μm was investigated.It was found that the degradation efficiency of hybrid system was superior to CWAO with single process.Under 0.01 MPa pressure for 120 min the fluxes of MF and UF declined 26.63% and 16.48%

respectively.The reason for flux decline of microfiltration membrane was considered to be the blocking of pores and the formation of cake layer on the membrane surface by deposited catalyst powder

while that of ultrafiltration was dominated by cake layer formation.The experimental results showed that the irreversible resistance in microfiltration was larger than that in ultrafiltration after the same process.Under different operation conditions

a linear relationship could be obtained between the filtration resistance and specific deposit.

关键词

Keywords

references

Views

380

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Oxidation-ultrafiltration coupling process: advances and challenges in mitigating membrane fouling and degrading emerging pollutants

In situ monitoring of membrane fouling by electrical impedance tomography based on bilateral array electrodes

Preparation and performance of high-flux polysulfone ultrafiltration membrane by in-situ synthesis

Ultrafiltration membrane cleaning technology and mechanism based on seawater desalination pilot equipment

Progress research on development of membrane technology and materials for health industry

Related Author

ZHANG Bing

TANG Heli

GONG Yuyang

QIN Yu

YIN Yanmei

WANG Jie

WANG Qi

GAO Fei

Related Institution

National Research Base of Intelligent Manufacturing Service, Chongqing Technology and Business University

School of Environmental and Ecology, Chongqing University

School of River and Ocean Engineering, Chongqing Jiaotong University

School of Electronics and Information Engineering, Tiangong University

Shihan (Tianjin) Energy Conservation and Environmental Protection Technology Co., Ltd.

⁰