TG-FTIR analysis on pyrolysis characteristics of refuse-derived fuel

BAI Jisong; YU Chunjiang; WU Peng; FANG Mengxiang; LUO Zhongyang

doi:10.3969/j.issn.0438-1157.2013.03.036

您当前的位置：

首页 >

文章列表页 >

TG-FTIR analysis on pyrolysis characteristics of refuse-derived fuel

更新时间：2025-12-10

- TG-FTIR analysis on pyrolysis characteristics of refuse-derived fuel
- CIESC Journal Issue 3, Pages: 1042-1048(2013)
- 作者机构：
  
  能源清洁利用国家重点实验室(浙江大学),浙江,杭州,310027
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2013.03.036
  CLC： 705
- Online First：05 March 2013，
  
  Published：05 March 2013
- 稿件说明：
移动端阅览
BAI Jisong, YU Chunjiang, WU Peng, et al. TG-FTIR analysis on pyrolysis characteristics of refuse-derived fuel[J]. CIESC Journal, 2013, (3): 1042-1048.
DOI：

BAI Jisong, YU Chunjiang, WU Peng, et al. TG-FTIR analysis on pyrolysis characteristics of refuse-derived fuel[J]. CIESC Journal, 2013, (3): 1042-1048. DOI： 10.3969/j.issn.0438-1157.2013.03.036.

摘要

利用热重红外分析仪(TG-FTIR)研究了两种不同垃圾衍生燃料(RDF)的热解特性。研究发现

尽管两种RDF的来源不同

但却具有相似的热解特性

其热解过程主要分为3个阶段:生物质组分(220～430℃)、塑料类物质(430～520℃)以及无机碳酸盐(>650℃)的分解。利用Coats-Redfern法

求得了RDF热解前两个阶段的表观动力学参数

计算结果表明高温段的反应活化能要高于低温段。通过FTIR对RDF热解析出的气体进行了在线分析

发现两种RDF热解过程中的气相产物析出规律基本一致

析出的气体主要包括H2O、CO2、CO以及CH4等烃类。HCl在低温阶段(230～400℃)即析出完毕。相比之下

NH3开始析出的温度较高(260℃)

并且整个析出温度范围较广

高温下仍有少量析出。SO2在热解条件下仍有相当量的生成

其析出主要集中在300～600℃的温度范围内。

Abstract

The pyrolysis characteristics of two different kinds of refuse-derived fuels(RDF) were investigated using thermogravimetric analysis-Fourier transform infrared spectrometer(TG-FTIR).It was found that the pyrolysis characteristics of two RDFs were similar.The pyrolysis process could be divided into three main stages

corresponding to the decomposition of biomass components(220—430℃)

plastic substances(430—520℃) and carbonates(>650℃).The Coats-Redfern method was used to analyze the apparent kinetic parameters of the first two stages

and the results showed that the activation energy was higher for the middle-temperature stage than for the low-temperature stage.By FTIR analysis

it was found that the major volatile gases released from the two RDFs were similar

mainly including H2O

CO2

CH4 and other hydrocarbons.The release of gaseous pollutants was paid special attention.The emission of HCl is completed at the low temperature stage(230—400℃).In contrast

the release of NH3 begins at 260℃ and goes through a much wider temperature range

and there is still a small amount of NH3 release at much higher temperature.In pyrolysis condition investigated

it was surprised to detect large amount of SO2

mainly released in the temperature range of 300—600℃.

关键词

Keywords

references

Views

409

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Thermo-oxidative degradation characteristics of TPT backsheet from end-of-life photovoltaic modules

Preparation of biobased polyurethane adhesives for flexible packaging and their water-resistance and thermal stability assessment

Revealing mechanisms of tar formation and char structural evolution during lignin pyrolysis from microscopic perspective

Progress of molten salt-assisted thermochemical high-value conversion of biomass

Characterisation of nitrogenous pollutants in solid wastes associated with waste incineration process using polymer non-catalytic reduction denitrification

Related Author

WANG Shangming

LI Xiaofeng

FANG Qiuyu

WANG Qiang

ZHANG Guoping

CHEN Yunan

CHEN Bin

ZHANG Haisheng

Related Institution

State Key Laboratory of Multiphase Flow in Power Engineering, Xi’an Jiaotong University

School of Chemical Engineering and Light Industry, Guangdong University of Technology

Zhongshan Kingho Chemical Co., Ltd.

State Key Laboratory of Mesoscience and Engineering, Institute of Process Engineering, Chinese Academy of Sciences

Innovation Academy for Green Manufacture, Chinese Academy of Sciences

⁰