Preparation of p-aminophenol from electrochemical reduction of nitrobenzene

NIU Dongfang; LANG Chao; ZHANG Xinsheng

doi:10.3969/j.issn.0438-1157.2013.02.033

您当前的位置：

首页 >

文章列表页 >

Preparation of p-aminophenol from electrochemical reduction of nitrobenzene

更新时间：2025-12-10

- Preparation of p-aminophenol from electrochemical reduction of nitrobenzene
- CIESC Journal Issue 2, Pages: 656-662(2013)
- 作者机构：
  
  华东理工大学化学工程联合国家重点实验室,上海,200237
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2013.02.033
  CLC： Q151.5
- Online First：05 February 2013，
  
  Published：05 February 2013
- 稿件说明：
移动端阅览
NIU Dongfang, LANG Chao, ZHANG Xinsheng. Preparation of p-aminophenol from electrochemical reduction of nitrobenzene[J]. CIESC Journal, 2013, (2): 656-662.
DOI：

NIU Dongfang, LANG Chao, ZHANG Xinsheng. Preparation of p-aminophenol from electrochemical reduction of nitrobenzene[J]. CIESC Journal, 2013, (2): 656-662. DOI： 10.3969/j.issn.0438-1157.2013.02.033.

摘要

采用固定床电解槽还原硝基苯制备对氨基苯酚

并对其工艺条件进行了优化。以铜网组成固定床电解槽阴极

镀铱钛网(DSA)作为阳极

在电流密度为1000 A·m-2

阴极电解槽内流速为4.28 cm·s-1

铜网厚度为10 mm

温度为85℃条件下

硝基苯还原的电流效率接近100%

对氨基苯酚的选择性可达到83%。电解液可循环套用5次

硫酸和氨水的消耗量降至原来的25%

硫酸铵和废水的排放量也减少了75%。采用扩散渗析法回收废弃电解液中的硫酸

以APS为阴离子交换膜

模拟液的流量为0.01 ml·min-1、温度为20℃时

酸回收率达到61%

且对氨基苯酚和苯胺的透过率分别仅为1.4%和1.6%。

Abstract

The packed bed cell was used in the preparation of p-aminophenol from the electrochemical reduction of nitrobenzene.The effects of current density

flow rate of catholyte

reactor thickness and temperature on electrolysis were studied.The results showed that under the conditions of 10 mm thickness of copper mesh as cathode

DSA as anode

current density 1000 A·m-2

flow rate of catholyte 4.28 cm·s-1 and temperature 85℃

current efficiency for nitrobenzene reduction was almost 100%

and selectivity of p-aminophenol could reach 83%.The catholyte could be reused five times for electrolysis

which resulted in that the lowered consumptions of sulfuric acid and ammonia approximately to 25% of the original value

and reduced discharge amounts of ammonia sulfate and effluent by 75%.Diffusion dialysis was used to recycle sulfuric acid from the spent catholyte.The results showed that under the conditions of APS as anion exchange membrane

flow rate of simulated solution 0.01 ml·min-1 and temperature 20℃

recovery of sulfuric acid was up to 61%

and transmissivities for p-aminophenol and aniline were only 1.4% and 1.6%

respectively.

关键词

Keywords

references

Views

511

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Amination of bromaminic acid catalyzed by Mn-containing basic copper carbonate electrocatalyst based on electrochemical reduction

Enhanced nitrobenzene removal by persulfate-assisted zerovalent iron

Degradation of nitrobenzene wastewater under Fe0/GAC-Fenton enhanced by ultrasound

Electrochemical reduction of nitrobenzene in binary ionic liquid of OMImBF4/HMImPF6

Zn3-MOF as highly efficient fluorescent sensor for nitrobenzene

Related Author

ZHANG Shufen

LYU Rongwen

WANG Tianwei

TANG Zhicheng

QIAO Junlian

FAN Peng

CHEN Jie

GUAN Xiaohong

Related Institution

State Key Laboratory of Fine Chemicals, Dalian University of Technology

College of Environment Science and Engineering, Tongji University

Shanxi Province Key Laboratory of Higee-Oriented Chemical Engineering, North University of China

State Key Laboratory Breeding Base of Green Chemistry-Synthesis Technology, College of Chemical Engineering, Zhejiang University of Technology

Yancheng Institute of Technology

⁰