Start-up behavior of gravity heat pipe with small diameter

WANG Xinyu; XIN Gongming; TIAN Fuzhong; CHENG Lin

doi:10.3969/j.issn.0438-1157.2012.z1.018

您当前的位置：

首页 >

文章列表页 >

Start-up behavior of gravity heat pipe with small diameter

更新时间：2025-12-10

- Start-up behavior of gravity heat pipe with small diameter
- CIESC Journal Issue S1, Pages: 94-98(2012)
- 作者机构：
  
  山东大学热科学与工程研究中心,山东,济南,250061
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2012.z1.018
  CLC：
- Online First：28 May 2012，
  
  Published：28 May 2012
- 稿件说明：
移动端阅览
WANG Xinyu, XIN Gongming, TIAN Fuzhong, et al. Start-up behavior of gravity heat pipe with small diameter[J]. CIESC Journal, 2012, (S1): 94-98.
DOI：

WANG Xinyu, XIN Gongming, TIAN Fuzhong, et al. Start-up behavior of gravity heat pipe with small diameter[J]. CIESC Journal, 2012, (S1): 94-98. DOI： 10.3969/j.issn.0438-1157.2012.z1.018.

摘要

实验研究了小管径重力热管启动过程特性，分析了加热功率、倾角、冷却水流量对热管启动特性的影响。实验用热管为铜水重力热管，外径8 mm，壁厚1 mm，总长1500 mm。结果表明，随加热功率增大，热管启动时间缩短，当量热导率到达稳定的时间缩短。在倾角为60°时热管启动特性要优于在30°和90°时的情况，90°时启动温差最大、启动时间最长。冷却水流量在10 L·h-1时，热管启动温差最大，启动时间最长，当量热导率稳定得最慢，而在其他流量下时，热管的启动温差和启动时间大小关系均为10 L·h-1＞40 L·h-1＞20 L·h-1＞30 L·h-1。

Abstract

The gravity heat pipe with small diameter in the startup process was investigated experimentally by analyzing the influences of heat input，inclination angle，cooling water flow rate on the startup properties.The tested gravity heat pipe was fabricated with copper tube and charged with distilled water.The heat pipe has the outer diameter of 8 mm with the thickness of 1mm，and total length of 1500 mm.The results show that with increasing heat inputs，the startup time decreases and the time to reach a steady effective thermal conductivity is shortened.The startup properties at inclination angle of 60° are superior to those at 30° and 90°.The startup temperature difference and startup time at 90° obtain the maximum values.When the cooling water flow rate is 10L·h-1，the startup temperature difference and startup time both present the maximum value，and the effective thermal conductivity demonstrates the shortest time to reach the steady state.The relations of the startup temperature difference and startup time at other cooling water flow rates are all satisfied with the sequence of 10L·h-1 ＞ 40L·h-1＞ 20L·h-1＞ 30L·h-1.

关键词

Keywords

references

Views

897

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

A preliminary experimental study on start-up behavior in nitrated gravity heat pipe

Numerical study and economic analysis of gravity heat pipe hot dry rock geothermal system

Experimental study on heat transfer performance of super long gravity heat pipe

Thermal conduction mechanism of multi-walled carbon nanotubes-deionized water nanofluids and experimental research in gravity heat pipe

Influence of changing evaporator/condenser section on operation characteristics of gravity heat pipe

Related Author

LI Deying

MA Chongfang

LIU Shanwei

CUI Wujun

XIONG Yaxuan

WU Yuting

MENG Qiang

HUANG Wenbo

Related Institution

Key Laboratory of Enhanced Heat Transfer and Energy Conservation of Ministry of Education, Key Laboratory of Heat Transfer and Energy Conversion of Beijing Municipality, Beijing University of Technology

Key Lab of HVAC, Beijing University of Civil Engineering and Architecture

Laboratory of Advanced Energy Systems, Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences

Key Laboratory of Renewable Energy, Chinese Academy of Sciences

The Guangdong Provincial Key Laboratory of New and Renewable Energy

⁰