Influence of water and weak acid on thermal hazard of cumene hydroperoxide

JIN Manping; SUN Feng; SHI Ning; XIE Chuanxin

doi:10.3969/j.issn.0438-1157.2012.12.051

您当前的位置：

首页 >

文章列表页 >

Influence of water and weak acid on thermal hazard of cumene hydroperoxide

更新时间：2025-12-10

- Influence of water and weak acid on thermal hazard of cumene hydroperoxide
- CIESC Journal Issue 12, Pages: 4096-4102(2012)
- 作者机构：
  
  中国石油化工股份有限公司青岛安全工程研究院, 化学品安全控制国家重点实验室,山东,青岛,266071
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2012.12.051
  CLC： 937
- Online First：26 June 2012，
  
  Published：26 June 2012
- 稿件说明：
移动端阅览
JIN Manping, SUN Feng, SHI Ning, et al. Influence of water and weak acid on thermal hazard of cumene hydroperoxide[J]. CIESC Journal, 2012, (12): 4096-4102.
DOI：

JIN Manping, SUN Feng, SHI Ning, et al. Influence of water and weak acid on thermal hazard of cumene hydroperoxide[J]. CIESC Journal, 2012, (12): 4096-4102. DOI： 10.3969/j.issn.0438-1157.2012.12.051.

摘要

为研究水和弱酸对过氧化氢异丙苯(CHP)热危险性的影响

利用C600微量热仪研究了CHP及CHP与不同含量水、不同含量弱酸、不同pH值弱酸的混合物在空气中受热分解的反应和放热特性

根据实验数据得出了相应的动力学和热力学参数

利用Semenov热爆炸模型计算出了自加速分解温度(SADT)。结果表明:少量的水和弱酸都能够使CHP的起始放热温度、最大放热温度、活化能降低;弱酸的pH值对CHP的热危险性也有影响

pH值越低

CHP的热危险性越大;计算得到CHP的SADT为84℃

通过对CHP及CHP与不同含量水、弱酸和不同pH值弱酸混合物SADT进行比较

发现少量的水和弱酸均能降低CHP的SADT

弱酸的pH值对SADT也有影响

pH值越低

CHP与弱酸混合物的SADT越小。

Abstract

In order to study the influence of water and weak acid on the thermal hazard of cumene hydroperoxide(CHP)

the thermal decomposition of CHP and CHP mixtures with different contents of water and weak acid and different pH of weak acid in the air was studied by C600 calorimeter.The corresponding kinetic and thermodynamic parameters based on experimental data were obtained

and the Semenov model was used to calculate the self accelerating decomposition temperature (SADT).The results show that small amounts of water and weak acid reduce the initial exothermic temperature

peak exothermic temperature and activation energy.The pH of weak acid also affects thermal hazard of CHP.As the pH of weak acid decreases

it is easier for the CHP decomposition reaction to occur.Calculated SADT of CHP is 84℃.The comparison on the calculated SADT results indicates that small amounts of water and weak acid reduce the SADT of CHP

and at lower pH of weak acid

the SADT also decreases.

关键词

Keywords

references

Views

285

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

The effect of ionic liquids on the vapor-liquid equilibrium of ammonia-water solution by the COSMO-SAC

Measurement and correlation of vapor-liquid equilibria for ethanol-water-potassium acetate system under atmospheric pressure

Influence of crystalloid NaNO2 on safety of emulsion explosive

Macromolecular post-chain extension study of TDI-based waterborne polyurethane dispersions with ethylene diamine

Comparison on stability of sulfated solid superacid with water pretreatment

Related Author

LI Mingyan

LI Jinlong

PENG Changjun

LIU Honglai

XU Jumei

SHI Yunhai

TAN Jinhui

CHEN Xiang

Related Institution

State Key Laboratory of Chemical Engineering, Department of Chemistry, East China University of Science and Technology

School of Petrochemical Engineering, Changzhou University

Research Centre of Chemical Engineering, East China University of Science and Technology

School of Chemical Engineering, Nanjing University of Science and Technology

Shanghai Entry-exit Inspection and Quarantine Bureau

⁰