Experimental and theoretical study of Fe<sub>2</sub>O<sub>3</sub>/coal ash oxygen carrier in CLC system

SHI Simo; DONG Changqing; QIN Wu; WANG Lei; LI Wenyan; YANG Yongping

doi:10.3969/j.issn.0438-1157.2012.12.039

您当前的位置：

首页 >

文章列表页 >

Experimental and theoretical study of Fe₂O₃/coal ash oxygen carrier in CLC system

更新时间：2025-12-10

- Experimental and theoretical study of Fe₂O₃/coal ash oxygen carrier in CLC system
- CIESC Journal Issue 12, Pages: 4010-4018(2012)
- 作者机构：
  
  华北电力大学生物质发电成套设备国家工程实验室,北京,102206
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2012.12.039
  CLC： Q546
- Online First：13 August 2012，
  
  Published：13 August 2012
- 稿件说明：
移动端阅览
SHI Simo, DONG Changqing, QIN Wu, et al. Experimental and theoretical study of Fe₂O₃/coal ash oxygen carrier in CLC system[J]. CIESC Journal, 2012, (12): 4010-4018. DOI: 10.3969/j.issn.0438-1157.2012.12.039.
DOI：

SHI Simo, DONG Changqing, QIN Wu, et al. Experimental and theoretical study of Fe₂O₃/coal ash oxygen carrier in CLC system[J]. CIESC Journal, 2012, (12): 4010-4018. DOI: 10.3969/j.issn.0438-1157.2012.12.039. DOI：

摘要

提出了一种以粉煤灰为载体制备的新型铁基载氧体。采用同步热重分析仪、小型流化床以及DFT分别研究了新型载氧体的活性与热稳定性

发泡剂含量与反应温度以及粉煤灰主要组分之间的协同作用对新型载氧体性能的影响。研究结果表明

新型载氧体在以CO为燃料的化学链系统中具有较高的活性;新型载氧体较大的孔隙率以及粉煤灰多组分间的协同作用促使850℃下发泡剂含量为10.0%(质量)的新型铁基载氧体的最大转化率(84.9%)比Fe2O3/Al2O3的最大转化率(54.3%)高30%

且新型铁基载氧体在30个循环测试中表现出良好的热稳定性。载体制备采用的发泡剂含量以及反应温度对新型铁基载氧体性能影响很大

适当的发泡剂含量(约10%(质量))可提高新型载氧体性能。此外

高温下会造成载氧体的烧结现象。最后

采用密度泛函理论(DFT)研究了粉煤灰与载氧体之间的界面作用以及协同氧化CO的电子特性。计算结果表明

粉煤灰和Fe2O3之间的界面电荷转移使Fe2O3为电正性

促使CO在表面的相互作用

载体和活性组分之间的协同作用降低了载氧体与CO前线轨道能量差

进而促进了CO与Fe2O3的反应。

Abstract

A novel Fe-based oxygen carrier/coal ash was proposed for CO oxidation in CLC system in this paper.Its activity and thermal stability as well as the synergistic effect between oxygen carrier and coal ash were studied by TGA and combustion experiments in a small fluidized bed and density functional theory calculations also performed.It is found that the novel oxygen carrier is more active for CO oxidation in CLC system

because of greater porosity and synergistic effect between them.At 850℃ and with 10.0%(mass) foamer

the maximum conversion is much higher for the novel Fe-based ash oxygen carrier(84.9%)than for Fe2O3/Al2O3(54.3%)

and the former is of preferable thermal stability in 30 cycles test.The activity of novel oxygen carrier is influenced significantly by the content of foamer and reaction conditions.Suitable foamer content(about 10%(mass))is favorable

whereas high reaction temperature causes its sintering. Furthermore

the effect of interfacial interaction and electronic properties related to the synergistic effect between them on CO oxidation were studied by density functional theory(DFT).The calculation results indicate that total charge population in the Fe2O3 particles is positive due to interfacial charge transfer between coal ash and Fe2O3

which could be favorable for reaction of CO and oxygen carrier.Synergistic effect between coal ash and Fe2O3 could cause a decrease of their frontier orbital energy difference

hence promote reactions between CO and Fe2O3.

关键词

Keywords

references

Views

477

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Distribution of sulfur in chemical looping combustion of anthracite based on Fe-based oxygen carrier

Reaction characteristics of chemical-looping gasification for waste coffee grounds

Chaotic mixing process of fly ash in acid leaching tank intensified by rigid-flexible impeller

Prediction of biomass pyrolysis product yield based on machine learning algorithms

Controlled synthesis of Bi2MoO6/MoO3 composite fibers via in-situ hydrothermal method and their high-efficiency photocatalytic hydrogen production performance

Related Author

YU Guangsuo

WANG Fuchen

LI Jilin

ZHU Longchu

WANG Yifei

ZHANG Zhifeng

LIU Yongzhuo

GUO Qingjie

Related Institution

Key Laboratory of Coal Gasification and Energy Chemical Engineering of Ministry of Education, Shanghai Engineering Research Center of Coal Gasification, East China University of Science and Technology

Key Laboratory of Clean Chemical Processing of Shandong Province, College of Chemical Engineering, Qingdao University of Science & Technology

School of Chemistry and Chemical Engineering, Chongqing University

Department of Chemical Engineering, Tsinghua University

⁰

Experimental and theoretical study of Fe2O3/coal ash oxygen carrier in CLC system

DOI：10.3969/j.issn.0438-1157.2012.12.039

摘要

Abstract

关键词

Keywords

references

Experimental and theoretical study of Fe₂O₃/coal ash oxygen carrier in CLC system