Effect of particle gradation on flow field of feeding pipe in classifier

DIAO Xiong; LI Shuangyue; HUANG Peng; REN Xihao

doi:10.3969/j.issn.0438-1157.2012.10.014

您当前的位置：

首页 >

文章列表页 >

Effect of particle gradation on flow field of feeding pipe in classifier

更新时间：2025-12-10

- Effect of particle gradation on flow field of feeding pipe in classifier
- CIESC Journal Issue 10, Pages: 3101-3111(2012)
- 作者机构：
  
  1. 西南科技大学制造科学与工程学院,四川,绵阳,621010
  2. 上海海事大学物流工程学院,上海,200135
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2012.10.014
  CLC： D454
- Online First：05 October 2012，
  
  Published：05 October 2012
- 稿件说明：
移动端阅览
DIAO Xiong, LI Shuangyue, HUANG Peng, et al. Effect of particle gradation on flow field of feeding pipe in classifier[J]. CIESC Journal, 2012, (10): 3101-3111.
DOI：

DIAO Xiong, LI Shuangyue, HUANG Peng, et al. Effect of particle gradation on flow field of feeding pipe in classifier[J]. CIESC Journal, 2012, (10): 3101-3111. DOI： 10.3969/j.issn.0438-1157.2012.10.014.

摘要

为了分析颗粒级配对超细分级机进料管内流动特性的影响

利用计算流体力学(CFD)方法

对进料管内气固两相流动进行研究。在对计算模型进行验证的基础上

揭示了不同颗粒级配下进出口压差、颗粒浓度分布及颗粒分散等特性。研究表明:进料管进出口压差随着级配中大粒径颗粒含量的增加而增加。当级配中小粒径含量较大时

颗粒浓度分布均匀

颗粒分散性较好

入口风速、喂料浓度、颗粒密度的改变对颗粒量纲1浓度分布及分散性影响较小。对于大粒径含量较大的级配

随着入口风速的增加

量纲1浓度减小

浓度分布不均匀度减小

分散性提高;随着喂料浓度的增加

量纲1浓度分布变化较小

但浓度分布不均匀度增大

颗粒分散性下降;随着物料密度的增加

浓度分布不均匀度减小

颗粒分散性提高。竖直段轴向截面上颗粒量纲1平均浓度的高低分界线为一定值(Z=0.5 m)

且与颗粒级配及操作参数的变化无关。

Abstract

In order to investigate the effect of particle gradation on the flow field of the feeding pipe in a classifier

the computational fluid dynamics method was applied in the study of gas-solids two-phase flow field in the feeding pipe.After the model was verified

the effects of gas velocity

feeding concentration

particle gradation and density on the pressure difference of inlet and outlet

particle concentration distribution and dispersion were analyzed.The results showed that the pressure difference of inlet and outlet increased with increasing large size particle content of gradation.When gradation was with a high content of small size particle

concentration distribution was uniform and particle dispersion was good.The change of gas velocity

feeding concentration and particle density had less influence on particle dimensionless concentration distribution and dispersion.The operation parameters had significant effects on gradation with a high content of large size particle.With the increase of gas velocity

particle dimensionless concentration decreased

concentration non-uniformity decreased

and particle dispersion became better. With the increase of feeding concentration

concentration non-uniformity increased

and particle dispersion became worse.With the increase of particle density

concentration non-uniformity decreased

and particle dispersion became better.The dividing line between high and low dimensionless average concentration in the vertical section of the axial feeding pipe was Z=0.5 m

and it basically unchanged with the change of particle gradation and operation parameters.

关键词

Keywords

references

Views

378

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Two-phase flow and reaction in radial moving beds for propane dehydrogenation

Three-dimensional numerical simulation of biomass-coal mixed combustion in fluidized beds

Sedimentation characteristics of the bottom surface of the inlet pipe box of a waste heat boiler

Particle velocity and concentration distribution in double-exit staged entrained-flow gasifier

Construction of two parameter mesoscale heat transfer model for gas-solid flow based on resetting temperature method

Related Author

HOU Kaijun

WANG Zhifeng

XU Chunming

LU Chunxi

JIANG Guiyuan

LIU Mengxi

LIU Qi

SUN Zhaolun

Related Institution

Lanzhou Petrochemical Research Center, Petrochemical Research Institute, PetroChina

State Key Laboratory of Heavy Oil Processing, China University of Petroleum

Beijing Institute of Low-Carbon Clean Energy

National Key Laboratory of Energy Efficiency and Clean Utilization, Zhejiang University

School of Energy and Power Engineering, Xi’an Jiaotong University

⁰