Energy consumption analysis and minimum reboil ratio in batch stripping distillation at constant reboil ratio

王为国1; 吴元欣3

doi:10.3969/j.issn.0438-1157.2012.07.016

您当前的位置：

首页 >

文章列表页 >

Energy consumption analysis and minimum reboil ratio in batch stripping distillation at constant reboil ratio

更新时间：2025-12-10

- Energy consumption analysis and minimum reboil ratio in batch stripping distillation at constant reboil ratio
- CIESC Journal Issue 7, Pages: 2106-2112(2012)
- 作者机构：
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2012.07.016
  CLC： Q015
- Online First：05 July 2012，
  
  Published：05 July 2012
- 稿件说明：
移动端阅览
王为国1, 吴元欣3. Energy consumption analysis and minimum reboil ratio in batch stripping distillation at constant reboil ratio[J]. CIESC Journal, 2012, (7): 2106-2112.
DOI：

王为国1, 吴元欣3. Energy consumption analysis and minimum reboil ratio in batch stripping distillation at constant reboil ratio[J]. CIESC Journal, 2012, (7): 2106-2112. DOI： 10.3969/j.issn.0438-1157.2012.07.016.

摘要

通过构造一函数，推导出二元恒再沸比提馏式间歇精馏，在理想操作条件下，理论板数趋向无穷多时，瞬时恒浓区变化方式可由此函数值(>0或<0)来判断，完善了二元恒再沸比提馏式间歇精馏最小再沸比计算方法。推导出二元恒残液组成提馏式间歇精馏，在理想操作条件下的最小汽化总量的计算公式。通过对理论板数趋向无穷多时的能耗分析得到，二元提馏式间歇精馏，要求残液中重组分的收率和平均浓度均高时，相对于恒残液组成操作，采用恒再沸比操作能耗较高，其主要原因是低效总能耗（理论板数趋向无穷多时，直接表现为无效总能耗）在总能耗中占比例较大。

Abstract

For a batch binary stripping distillation under ideal operating condition

with constant reboil ratio and infinite number of theoretical plates

a function was derived in this study

and the variation of instantaneous constant composition region may be evaluated by the value of this function.Thus the calculation method for the minimum reboil ratio of the batch binary stripping distillation was improved.A formula was deduced for computing the minimum total vapor capacity of the distillation under constant residual fraction composition and ideal operating condition.The results show that to achieve high yield and high average concentration of heavy component in the residual fraction

the energy consumption of the batch stripping distillation at constant reboil ratio is higher than that at constant residual fraction composition because the low efficient consumption of total energy (which is the inefficient total energy consumption with infinite number of theoretical plates)accounts for a large portion of the total energy consumption.

关键词

Keywords

references

Views

351

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Process simulation and energy consumption analysis of CO2/N2 pilot-scale separation using ZIF-8 slurry

Study on synergistic modification of nitrogen-doped carbon coating and Ti⁴⁺ co-doping for lithium vanadium phosphate cathode materials

Performance study of gas-liquid vortex separators under low cross-sectional gas velocity

Progress of solar photo-thermo-catalysis for ammonia synthesis and decomposition under mild conditions

Exothermic characteristics of energy carrier for calcium looping thermo-chemical energy storage

Related Author

HUANG Zixuan

CHEN Huan

LI Hai

WANG Minglong

CHEN Guangjin

LIU Bei

Related Institution

State Key Laboratory of Heavy Oil Processing, China University of Petroleum

Key Laboratory of Green Process and Engineering, Institute of Process Engineering, Chinese Academy of Sciences

⁰