Influence of calcination temperature on CuMgAl catalytic performance for hydrogenation of furfuralcohol to pentanediol

WEI Caiyun; TAN Jingjing; XIA Xiaoli; ZHAO Yongxiang

doi:10.11949/j.issn.0438-1157.20181466

您当前的位置：

首页 >

文章列表页 >

Influence of calcination temperature on CuMgAl catalytic performance for hydrogenation of furfuralcohol to pentanediol

Catalysis\, kinetics and reactors | 更新时间：2026-07-24

- Influence of calcination temperature on CuMgAl catalytic performance for hydrogenation of furfuralcohol to pentanediol
- CIESC Journal Vol. 70, Issue 4, Pages: 1409-1419(2019)
- 作者机构：
  
  山西大学化学化工学院，精细化学品教育部工程研究中心，山西太原 030006
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20181466
  CLC： O 643.36
- Received：10 December 2018，
  
  Revised：2019-01-07，
  
  Online First：15 June 2020，
  
  Published：12 April 2019
- 稿件说明：
移动端阅览
卫彩云, 谭静静, 夏晓丽, 赵永祥. 焙烧温度对CuMgAl催化剂催化糠醇加氢制戊二醇的影响[J]. 化工学报, 2019, 70(4): 1409-1419

WEI Caiyun, TAN Jingjing, XIA Xiaoli, ZHAO Yongxiang. Influence of calcination temperature on CuMgAl catalytic performance for hydrogenation of furfuralcohol to pentanediol[J]. CIESC Journal, 2019, 70(4): 1409-1419
卫彩云, 谭静静, 夏晓丽, 赵永祥. 焙烧温度对CuMgAl催化剂催化糠醇加氢制戊二醇的影响[J]. 化工学报, 2019, 70(4): 1409-1419 DOI： 10.11949/j.issn.0438-1157.20181466.

WEI Caiyun, TAN Jingjing, XIA Xiaoli, ZHAO Yongxiang. Influence of calcination temperature on CuMgAl catalytic performance for hydrogenation of furfuralcohol to pentanediol[J]. CIESC Journal, 2019, 70(4): 1409-1419 DOI： 10.11949/j.issn.0438-1157.20181466.

摘要

采用共沉淀法制得物质的量比为

(Cu

)∶

(Mg

)∶

(Al

)=10∶65∶25的CuMgAl类水滑石前体（CMA-HT），经过不同温度焙烧制得CuMgAl水滑石催化剂。通过傅里叶变换红外光谱（FTIR）、热重分析（TG）、X射线粉末衍射（XRD）、扫描电子显微镜（SEM）、透射电子显微镜（TEM）、N

-物理吸附、程序升温还原（H

-TPR）、H

-程序升温脱附（H

-TPD）、CO

-程序升温脱附（CO

-TPD）和NH

-程序升温脱附（NH

-TPD）等对催化剂的结构进行表征，在高压反应釜中考察了CuMgAl水滑石催化剂催化糠醇（FFA）加氢制1

2-戊二醇（1

2-PeD）和1

5-戊二醇（1

5-PeD）的催化性能。研究结果表明，焙烧温度对催化剂的结构及其催化性能具有显著的影响，金属活性中心和碱性位随焙烧温度的升高先增加后减少。经600℃焙烧的CMA催化剂表面存在适宜的金属中心和碱性位，在金属位和碱性中心的协同催化下，表现出了优异的催化性能。在140℃，H

压力为4 MPa的条件下，反应8 h，糠醇的转化率和戊二醇的收率分别达74.13%和58.36%。

Abstract

The CuMgAl hydrotalcite-type (CMA-HT) precursors was prepared by co-precipitation process

in which the molar ratio of

(Cu

)∶

(Mg

)∶

(Al

) was 10∶65∶25. The CuMgAl hydrotalcite catalysts were obtained by calcining at various temperatures. The catalysts were characterized by Fourier transform infrared spectroscopy (FTIR)

thermogravimetric analysis (TG)

X-ray powder diffraction (XRD)

scanning electron microscope (SEM)

transmission electron microscope (TEM)

-adsorption

-temperature programmed reduction (H

-TPR)

-temperature programmed desorption (H

-TPD)

-temperature programmed desorption (CO

-TPD) and NH

-temperature programmed desorption (NH

-TPD). The catalytic performance of CMA catalysts for the hydrogenation of furfuryl alcohol to 1

2-pentanediol and 1

5-pentanediol were investigated in the autoclave. The results indicated that the calcination temperatures had significantly influence on the structure and catalytic activity of the catalyst. The metal sites and basic sites increased firstly and then decreased with rising the calcined temperatures. The sample calcined at 600℃ possesses the suitable metal and basic sites. It exhibited the superior activity for the hydrogenolysis of furfuryl alcohol as the synergistic effect between the surface metal sites and the basic sites. Under the condition of 140℃ and H

pressure of 4 MPa

the conversion of sterol and the yield of pentanediol reached 74.13% and 58.36%

respectively

after 8 h of reaction.

关键词

Keywords

references

Iborra S , Huber G W , Corma A . Synthesis of transportation fuels from biomass: chemistry, catalysts, and engineering [J ] . Chemical Reviews , 2006 , 106 ( 9 ): 4044 - 4089 .

Velty A , Iborra S , Corma A . Chemical routes for the transformation of biomass into chemicals [J ] . Chemical Reviews , 2007 , 107 ( 6 ): 2411 - 2502 .

Tilman D , Socolow R , Foley J A , et al . Beneficial biofuels—the food, energy, and environment trilemma [J ] . Science , 2009 , 325 ( 5938 ): 270 - 271 .

Zhou B W , Song J L , Zhang Z R , et al . Highly selective photocatalytic oxidation of biomass-derived chemicals to carboxyl compounds over Au/TiO 2 [J ] . Green Chemistry , 2017 , 19 : 1075 - 1081 .

Cui J , Tan J , Zhu Y , et al . Aqueous hydrogenation of levulinic acid to 1,4-pentanediol over Mo-modified Ru/activated carbon catalyst [J ] . ChemSusChem , 2018 , 11 ( 8 ): 1316 - 1320 .

Adkins H , Connor R . The catalytic hydrogenation of organic compounds over copper chromite [J ] . Journal of the American Chemical Society , 1931 , 53 ( 3 ): 1091 - 1095 .

Connor R , Adkins H . Hydrogenolysis of oxygenated organic compounds [J ] . Journal of the American Chemical Society , 1932 , 54 ( 12 ): 4678 - 4690 .

Connor R , Folkers K , Adldns H . The preparation of copper-chromium oxide catalysts for hydrogenation [J ] . Journal of the American Chemical Society , 1932 , 54 ( 3 ): 1138 - 1145 .

Li X , Jia P , Wang T . Furfural: a promising platform compound for sustainable production of C 4 and C 5 chemicals [J ] . ACS Catalysis , 2016 , 6 : 7621 - 7640 .

Sun D , Sato S , Ueda W , et al . Production of C 4 and C 5 alcohols from biomass-derived materials [J ] . ChemInform , 2016 , 47 ( 26 ): 2579 - 2597 .

Mizugaki T , Yamakawa T , Nagatsu Y , et al . Direct transformation of furfural to 1,2-pentanediol using a hydrotalcite-supported platinum nanoparticle catalyst [J ] . ACS Sustainable Chemistry & Engineering , 2014 , 2 ( 10 ): 2243 - 2247 .

Liu H , Huang Z , Kang H , et al . Selective hydrogenolysis of biomass-derived furfuryl alcohol into 1, 2- and 1, 5-pentanediol over highly dispersed Cu-Al 2 O 3 catalysts [J ] . Chinese Journal of Catalysis , 2016 , 37 ( 5 ): 700 - 710 .

Schlaf M . Selective deoxygenation of sugar polyols to α , ω -diols and other oxygen content reduced materials—a new challenge to homogeneous ionic hydrogenation and hydrogenolysis catalysis [J ] . Dalton Transactions , 2006 , 29 ( 39 ): 4645 - 4653 .

Sato M , Otabe N , Tuji T , et al . Highly-selective and high-speed Claisen rearrangement induced with subcritical water microreaction in the absence of catalyst [J ] . Green Chemistry , 2009 , 11 ( 6 ): 763 - 766 .

Chatterjee M , Kawanami H , Ishizaka T , et al . An attempt to achieve the direct hydrogenolysis of tetrahydrofurfuryl alcohol in supercritical carbon dioxide [J ] . Catalysis Science & Technology , 2011 , 1 ( 8 ): 1466 - 1471 .

Xu W J , Wang H F , Wang Y P , et al . Direct catalytic conversion of furfural to 1, 5-pentanediol by hydrogenolysis of the furan ring under mild conditions over Pt/Co 2 AlO 4 catalyst [J ] . Chemical Communication , 2011 , 47 ( 3 ): 3924 - 3926 .

Zhang B , Zhu Y , Ding G , et al . Selective conversion of furfuryl alcohol to 1, 2-pentanediol over a Ru/MnO x catalyst in aqueous phase [J ] . Green Chemistry , 2012 , 14 ( 12 ): 3402 - 3409 .

Cui J , Tan J , Cui X , et al . Conversion of xylose to furfuryl alcohol and 2-methylfuran in a continuous fixed-bed reactor [J ] . ChemSusChem , 2016 , 9 ( 11 ): 1259 - 1262 .

Xia S X , Nie R F , Lu X Y , et al . Hydrogenolysis of glycerol over Cu 0.4 /Zn 5.6- x Mg x Al 2 O 8.6 catalysts: the role of basicity and hydrogen spillover [J ] . Journal of Catalysis , 2012 , 296 ( 7 ): 1 - 11 .

Pinnavaia T J . Intercalated clay catalysts [J ] . Science , 1983 , 220 ( 4595 ): 365 - 371 .

Węgrzyn A , Rafalska-Łasocha A , Majda D , et al . The influence of mixed anionic composition of Mg-Al hydrotalcites on the thermal decomposition mechanism based on in situ study [J ] . Journal of Thermal Analysis & Calorimetry , 2010 , 99 ( 2 ): 443 - 457 .

Forgionny A , Fierro G , Mondragon F , et al . Effect of Mg/Al ratio on catalytic behavior of Fischer-Tropsch cobalt-based catalysts obtained from hydrotalcites precursors [J ] . Topic Catalysis , 2016 , 59 ( 2/4 ): 230 - 240 .

Zhou M , Zeng Z , Zhu H , et al . Aqueous-phase catalytic hydrogenation of furfural to cyclopentanol over Cu-Mg-Al hydrotalcites derived catalysts: model reaction for upgrading of bio-oil [J ] . Journal of Energy Chemistry , 2014 , 23 ( 1 ): 91 - 96 .

Debecker D P , Gaigneaux E M , Bysca G . Exploring, tuning, and exploiting the basicity of hydrotalcites for applications in heterogeneous catalysis [J ] . Chemistry , 2009 , 15 ( 16 ): 3920 - 3935 .

Jiang Z , Hao Z P , Yu J J , et al . Catalytic combustion of methane on novel catalysts derived from Cu-Mg/Al-hydrotalcites [J ] . Catalysis Letters , 2005 , 9 ( 3/4 ): 157 - 163 .

Zeng Y , Zhang T , Xu Y , et al . Cu/Mg/Al hydrotalcite-like hydroxide catalysts for o -phenylphenol synthesis [J ] . Applied Clay Science , 2016 , 126 : 207 - 214 .

Parker L M , Milestone N B , Newman R H . The use of hydrotalcite as an anion absorbent [J ] . Industrial & Engineering Chemistry Research , 1995 , 34 ( 4 ): 1196 - 1202 .

Melián-Cabrera I , López Granados M , Fierro J L G . Thermal decomposition of a hydrotalcite-containing Cu-Zn-Al precursor: thermal methods combined with an in situ DRIFT study [J ] . Physical Chemistry Chemical Physics , 2002 , 4 ( 13 ): 3122 - 3127 .

Kannan S , Rives V , Knozinger H . High-temperature transformations of Cu-rich hydrotalcites [J ] . Journal of Solid State Chemistry , 2004 , 177 ( 1 ): 319 - 331 .

Bonura G , Cordaro M , Cannilla C , et al . The changing nature of the active site of Cu-Zn-Zr catalysts for the CO 2 hydrogenation reaction to methanol [J ] . Applied Catalysis B: Environmental , 2014 , 152/153 : 152 - 161 .

Pérez-Ramı́Rez J , Mul G , Moulijn J A . In situ Fourier transform infrared and laser Raman spectroscopic study of the thermal decomposition of Co-Al and Ni-Al hydrotalcites [J ] . Vibrational Spectroscopy , 2001 , 27 ( 1 ): 75 - 88 .

Rousselot I , Tavioto-Gueh C , Besse J P , Synthesis and characterization of mixed Ga/Al-containing layered double hydroxides : study of their basic properties through the Knoevenagel condensation of benzaldehyde and ethyl cyanoacetate, and comparison to other LDHs [J ] . International Journal of Inorganic Materials , 1999 , 1 : 165 - 174 .

BasąG S , Piwowarska Z , Kowalczyk A , et al . Cu-Mg-Al hydrotalcite-like materials as precursors of effective catalysts for selective oxidation of ammonia to dinitrogen—the influence of Mg/Al ratio and calcination temperature [J ] . Applied Clay Science , 2016 , 129 : 122 - 130 .

Corma A , Fornes V , Martin-Aranda R M , et al . ChemInform abstract: determination of base properties of hydrotalcites: condensation of benzaldehyde with ethyl acetoacetate [J ] . Journal of Catalysis , 1992 , 134 ( 1 ): 58 - 65 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

High-performance electrocatalytic semi-hydrogenation of acetylene to ethylene via MOF derived Cu/N-C catalyst

Effect of ammonia evaporation time on the reaction performance of hydrogenation of dimethyl oxalate to ethylene glycol over Cu/SiO2

Integrated production of 2-methyltetrahydrofuran through hydrogenation and dehydration of ethyl levulinate

Mechanistic insights into the hydrogenation of dimethyl oxalate to methyl glycolate over Ni-Ag/SiO2 catalyst

Ga2O3 modified CuCeO catalysts for CO2 hydrogenation to methanol

Related Author

DU Zifu

XIE Xiaomi

ZHANG Mimi

LI Zuosi

WU Deyin

ZHOU Jianzhang

LI Rui

JIAN Xuan

Related Institution

Shaanxi Key Laboratory of Chemical Reaction Engineering, School of Chemistry and Chemical Engineering, Yan’an University, Yan’an

National Key Laboratory of Surface-Interface Chemistry, School of Chemistry and Chemical Engineering, Xiamen University

Key Laboratory of Atmospheric Complex Pollution Control and Synergistic Carbon Reduction of Shanxi Province, School of Environmental Science and Engineering, Taiyuan University of Technology

School of Chemistry and Chemical Engineering, Guangxi University

Guangxi Huayi Energy Chemical Co., Ltd.

⁰