Application conditions and kinetics simulation over SCR catalyst for flue gas denitrification under low temperature

LI Ping; LI Changming; DUAN Zhengkang; GAO Shiqiu; XU Guangwen; YU Jian

doi:10.11949/j.issn.0438-1157.20181438

您当前的位置：

首页 >

文章列表页 >

Application conditions and kinetics simulation over SCR catalyst for flue gas denitrification under low temperature

更新时间：2026-07-24

- Application conditions and kinetics simulation over SCR catalyst for flue gas denitrification under low temperature
- CIESC Journal Vol. 70, Issue 8, Pages: 2981-2990(2019)
- 作者机构：
  
  1.中国科学院过程工程研究所多相复杂系统国家重点实验室，北京 100190
  2.湘潭大学化工学院，湖南湘潭 411105
  3.沈阳化工大学，辽宁沈阳 110142
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20181438
  CLC： TQ 028.8
- Received：04 December 2018，
  
  Revised：2019-03-01，
  
  Online First：24 July 2026，
  
  Published：05 August 2019
- 稿件说明：
移动端阅览
李萍, 李长明, 段正康, 高士秋, 许光文, 余剑. 低温烟气脱硝催化剂适用条件与动力学[J]. 化工学报, 2019, 70(8): 2981-2990

LI Ping, LI Changming, DUAN Zhengkang, GAO Shiqiu, XU Guangwen, YU Jian. Application conditions and kinetics simulation over SCR catalyst for flue gas denitrification under low temperature[J]. CIESC Journal, 2019, 70(8): 2981-2990
李萍, 李长明, 段正康, 高士秋, 许光文, 余剑. 低温烟气脱硝催化剂适用条件与动力学[J]. 化工学报, 2019, 70(8): 2981-2990 DOI： 10.11949/j.issn.0438-1157.20181438.

LI Ping, LI Changming, DUAN Zhengkang, GAO Shiqiu, XU Guangwen, YU Jian. Application conditions and kinetics simulation over SCR catalyst for flue gas denitrification under low temperature[J]. CIESC Journal, 2019, 70(8): 2981-2990 DOI： 10.11949/j.issn.0438-1157.20181438.

摘要

随着国家对大气污染物排放要求的进一步提高，中低温脱硝催化剂也将迎来更大的市场和挑战。为进一步明确低温脱硝催化剂的应用特性，在不同温度、烟气流速、催化剂长度和水蒸气含量下对已产业化的蜂窝催化剂的脱硝活性进行了系统考察，获得该中低温脱硝催化剂的适用区间与动力学参数。实验表明，在温度高于160℃条件下，通过调变气速与催化剂长度可以实现理论氨氮比的脱硝率；且在考察水蒸气对脱硝活性的影响时，发现脱硝率随着水蒸气含量的增加而逐步降低，在低温条件下降低更加显著，最大降幅达30%；依据2 ~ 4 m/s气速下的脱硝率与停留时间的关系，拟合脱硝反应活化能为22.7 kJ/mol，属于典型的气体外表面扩散控制，可为低温脱硝催化剂选型提供重要参考；180000 m

/h烟气量的脱硝示范验证了该催化剂在180℃下脱硝率超过90%，显示了优良的工业应用和推广前景。

Abstract

With the more stringent requirements of atmospheric pollutant emission standards

medium and low temperature catalyst would have larger market and greater challenge. In order to further clarify the application characteristics of the low temperature denitration catalyst

the denitration activity of the industrialized honeycomb catalyst was systematically investigated under different temperatures

flue gas flow rate

catalyst length and water vapor content. The applicable temperature range and kinetic parameters of the catalyst under low temperature window were also determined. These results showed that theoretical denitrification rate of NH

/NO can be achieved above 160℃ by adjustments of gas velocity and length of honeycomb catalyst. Moreover

it was found that NO conversion gradually decreased with the increase of steam content

and the negative impact become more severely below 180℃ with less than 70% DeNO

efficiency at 160℃ and 35% steam content in flue gas. According to the relationship between denitrification rate and residence time (at 2－4 m/s gas velocity)

the reaction activation energy was calculated to be 22.7 kJ/mol

suggesting that the reaction is limited by the external diffusion. The industrial DeNO

demonstration of flue gas with 180000 m

/h over this catalyst exhibits more than 90% DeNO

efficiency at 180℃ and promising industrialization prospect.

关键词

Keywords

references

李穹 , 吴玉新 , 杨海瑞 , 等 . SNCR脱硝特性的模拟及优化 [J ] . 化工学报 , 2013 , 64 ( 5 ): 1789 - 1796 .

Li Q , Wu Y X , Yang H R , et al . Simulation and optimization of SNCR process [J ] . CIESC Journal , 2013 , 64 ( 5 ): 1789 - 1796 .

Lai J K , Wachs I E . A perspective on the sel ective catalytic reduction (SCR) of NO with NH 3 by supported V 2 O 5 -WO 3 /TiO 2 catalysts [J ] . ACS Catalysis , 2018 , 8 ( 3 ): 6537 - 6551 .

顾卫荣 , 周明吉 , 马薇 . 燃煤烟气脱硝技术的研究进展 [J ] . 化工进展 , 2012 , 31 ( 9 ): 2084 - 2092 .

Gu W R , Zhou M J , Ma W . Technology statue and analysis on coal-fired flue gas denitrification [J ] . Chemical Industry and Engineering Progress , 2012 , 31 ( 9 ): 2084 - 2092 .

苗强 . 脱硝技术的现状及展望 [J ] . 洁净煤技术 , 2017 , 23 ( 2 ): 12 - 19 .

Miao Q . Progress and prospects of denitration technology [J ] . Clean Coal Technology , 2017 , 23 ( 2 ): 12 - 19 .

顾庆华 , 胡秀丽 . SCR脱硝反应区域运行温度影响因素研究 [J ] . 洁净煤技术 , 2015 , 21 ( 2 ): 77 - 80 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Progress in microwave technology for denitration catalyst preparation and NH3-SCR application

Preparation and pilot-scale test of V2O5-MoO3/TiO2 catalytic filter bag

Non-thermal plasma enhanced hydrolysis of urea decomposition by-products over TiO2

Preparation and industrial application of MnOx particle catalyst for low temperature denitration

Study on low temperature selective catalytic reduction of NO by Ba and Co co-doped MnOx

Related Author

CHANG Chenchao

ZHANG Zhongliang

WANG Chengzhi

YU Jian

HAN Zhennan

SAN Xiaoguang

GAO Shiqiu

WANG Yue

Related Institution

College of Water Resources, North China University of Water Resources and Electric Power

Henan Province Key Laboratory of Environmentally Friendly Functional Materials

Institute of Chemistry, Henan Academy of Sciences

Zhejiang Baiyu Intelligent Technology Co., Ltd.

School of Ecology and Environment, Beijing Technology and Business University

⁰