Simultaneous reduction of NO<italic style="font-style: italic"><sub>x</sub></italic> and CO emissions in domestic decoupling coal-fired stoves

HAN Jian; LIU Xinhua; HE Jingdong; LI Honglin; ZHANG Nan

doi:10.11949/j.issn.0438-1157.20181327

您当前的位置：

首页 >

文章列表页 >

Simultaneous reduction of NO_x and CO emissions in domestic decoupling coal-fired stoves

Energy and environmental engineering | 更新时间：2026-07-24

- Simultaneous reduction of NO_x and CO emissions in domestic decoupling coal-fired stoves
- CIESC Journal Vol. 70, Issue 5, Pages: 1991-1998(2019)
- 作者机构：
  
  1.中国科学院过程工程研究所多相复杂系统国家重点实验室，北京 100190
  2.中国科学院大学化学工程学院，北京 100049
  3.中国科学院，北京 100864
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20181327
  CLC： TQ 534
- Received：14 November 2018，
  
  Revised：2019-02-14，
  
  Online First：24 July 2026，
  
  Published：05 May 2019
- 稿件说明：
移动端阅览
韩健, 刘新华, 何京东, 李虹嶙, 张楠. 民用解耦燃煤炉中的NO_x和CO同时减排[J]. 化工学报, 2019, 70(5): 1991-1998 DOI: 10.11949/j.issn.0438-1157.20181327.

HAN Jian, LIU Xinhua, HE Jingdong, LI Honglin, ZHANG Nan. Simultaneous reduction of NO_x and CO emissions in domestic decoupling coal-fired stoves[J]. CIESC Journal, 2019, 70(5): 1991-1998 DOI: 10.11949/j.issn.0438-1157.20181327.
韩健, 刘新华, 何京东, 李虹嶙, 张楠. 民用解耦燃煤炉中的NO_x和CO同时减排[J]. 化工学报, 2019, 70(5): 1991-1998 DOI: 10.11949/j.issn.0438-1157.20181327. DOI：

HAN Jian, LIU Xinhua, HE Jingdong, LI Honglin, ZHANG Nan. Simultaneous reduction of NO_x and CO emissions in domestic decoupling coal-fired stoves[J]. CIESC Journal, 2019, 70(5): 1991-1998 DOI: 10.11949/j.issn.0438-1157.20181327. DOI：

摘要

典型民用解耦燃煤炉具有底部连通的两个分别被称为热解室和燃烧室的并列炉膛，煤炭从热解室上部加入，空气通过热解室底部的倾斜炉排引入。结合煤炭燃烧过程中的氮转移路线与解耦炉中的气体循环流动特征，定性分析了民用解耦燃煤炉中的NO

和CO同时减排机理，并在此基础上对配风和煤种等因素对NO和CO排放的影响进行了定量实验研究。结果表明，民用解耦燃煤炉特有的结构特征和通风方式有利于NO

和CO的同时减排，解耦炉具与洁净型煤匹配可显著降低综合污染物排放。

Abstract

A typical civil decoupling coal-fired stove has two parallel furnaces

called a pyrolysis chamber and a combustion chamber

which are connected at the bottom

coal is introduced from the upp

er part of the pyrolysis chamber

and air is introduced through the inclined grate at the bottom of the pyrolysis chamber. Based on the profound understanding of both the nitrogen transformation route in coal combustion and the characteristics of gas flow circulation in decoupling stoves

the mechanisms of simultaneous reduction of NO

and CO emissions in domestic decoupling coal-fired stoves were qualitatively analyzed in this paper. The influences of draft type and coal property on NO and CO emissions were experimentally studied further. The results indicate that the simultaneous suppression of NO

and CO emissions in a domestic decoupling coal-fired stove can be mainly attributed to its unique geometry structure and draft type. Burning clean briquettes in decoupling stoves helps to reduce pollutant emissions significantly.

关键词

Keywords

references

霍沫霖 , 赵佳 , 徐朝 , 等 . 中国散烧煤消费地图及影响因素研究 [J ] . 中国电力 , 2017 , 50 ( 1 ): 1 - 8 .

Huo M L , Zhao J , Xu Z , et al . China scattered coal consumption map and influence factors [J ] . Electric Power , 2017 , 50 ( 1 ): 1 - 8 .

毛健雄 , 毛健全 , 赵树民 . 煤的清洁燃烧 [M ] . 北京 : 科学出版社 , 1998 .

Mao J X , Mao J Q , Zhao S M . Clean Combustion of Coal [M ] . Beijing : Science Press , 1998 .

Li Q , Jiang J K , Qi J , et al . Improving the energy efficiency of stoves to reduce pollutant emissions from household solid fuel combustion in China [J ] . Environ. Sci. Technol. Lett ., 2016 , ( 3 ): 369 - 374 .

郝江平 , 孙广藩 , 李静海 , 等 . 一种燃煤解耦燃烧装置及燃烧方法: 201310381626.7 [P ] . 2013-08-28 .

Hao J P , Sun G F , Li J H , et al . A coal-fired decoupling combustion appliance as well as decoupling combustion method: 201310381626.7 [P ] . 2013-08-28 .

郝江平 , 高士秋 , 孙广藩 , 等 . 燃煤工业锅炉的发展与解耦燃烧技术的开发 [J ] . 工业锅炉 , 2014 , ( 4 ): 7 - 11 .

Hao J P , Gao S Q , Sun G F , et al . Status of coal-fired industrial boilers and development of decoupling combustion technique [J ] . Industrial Boiler , 2014 , ( 4 ): 7 - 11 .

许光文 , 高士秋 , 余剑 , 等 . 解耦热化学转化基础与技术 [M ] . 北京 : 科学出版社 , 2016 .

Xu G W , Gao S Q , Yu J , et al . Decoupling Thermochemical Conversion Foundation and Technology [M ] . Beijing : Science Press , 2016 .

郝江平 , 刘新华 , 李静海 , 等 . 一种空气分级解耦燃烧机械炉排燃烧炉: 201720174699.2 [P ] . 2017-02-24 .

Hao J P , Liu X H , Li J H , et al . An air-staged decoupling combustion grate boiler: 201720174699.2 [P ] . 2017-02-24 .

刘新华 , 郝江平 , 张楠 , 等 . 一种解耦燃烧装置及燃烧方法: 201710512563.2 [P ] . 2017-06-29 .

Liu X H , Hao J P , Zhang N , et al . A decoupling combustion appliance as well as decoupling combustion method: 201710512563.2 [P ] . 2017-06-29 .

Wang J , Helen H L , Yang F L , et al . Numerical simulation of a decoupling and re-burning combinative low-NO x coal grate boiler [J ] . Journal of Cleaner Production , 2018 , ( 188 ): 977 - 988 .

李静海 , 许光文 , 杨励丹 , 等 . 一种抑制氮氧化物的无烟燃煤方法及燃煤炉: 95102081.1 [P ] . 1995-10-25 .

Li J H , Xu G W , Yang L D , et al . A NO x -suppressed smokeless coal-fired method as well as corresponding stove: 95102081.1 [P ] . 1995-10-25 .

徐有宁 . 抑制氮氧化物无烟燃煤技术及其应用 [D ] . 北京 : 中国科学院化工冶金研究所 , 2000 .

Xu Y N . NO x -suppressed and smokeless coal combustion technology and its application [D ] . Beijing : Institute of Chemical Metallurgy, Chinese Academy of Sciences , 2000 .

徐有宁 , 宋文立 , 白蕴如 , 等 . 抑制氮氧化物排放的无烟燃煤技术及其在窑炉中的应用 [J ] . 过程工程学报 , 2001 , 1 ( 1 ): 95 - 98 .

Xu Y N , Song W L , Bai Y R , et al . NO x -suppressed and smokeless coal combustion technique and application in coal-fired kilns [J ] . The Chinese Journal of Process Engineering , 2001 , 1 ( 1 ): 95 - 98 .

He J D , Song W L , Gao S Q , et al . Experimental study of the reduction mechanisms of NO emission in decoupling combustion [J ] . Fuel Processing Technology , 2006 , ( 87 ): 803 - 810 .

何京东 . 煤炭解耦燃烧NO抑制机理实验研究 [D ] . 北京 : 中国科学院过程工程研究所 , 2006 .

He J D . Experimental study of the reduction mechanisms on NO emission in decoupling combustion of coal [D ] . Beijing : Institute of Process Engineering, Chinese Academy of Sciences , 2006 .

Dong L , Gao S Q , Song W L , et al . Experimental study of NO reduction over biomass char [J ] . Fuel Processing Technology , 2007 , ( 88 ): 707 - 715 .

Dong L , Gao S Q , Song W L , et al . NO reduction in decoupling combustion of biomass and biomass-coal blend [J ] . Energy & Fuels , 2009 , ( 23 ): 224 - 228 .

尚校 , 高士秋 , 汪印 , 等 . 不同煤燃烧方式降低NO x 排放比较及解耦燃烧应用 [J ] . 燃料化学学报 , 2012 , 40 ( 6 ): 672 - 679 .

Shang X , Gao S Q , Wang Y , et al . Comparison of NO x reduction among different coal combustion methods and the application of decoupling combustion [J ] . Journal of Fuel Chemistry and Technology , 2012 , 40 ( 6 ): 672 - 679 .

Cai L G , Shang X , Gao S Q , et al . Low-NO x coal combustion via combining decoupling combustion and gas reburning [J ] . Fuel , 2013 , ( 112 ): 695 - 703 .

Li H L , Han J , Zhang N , et al . Effects of high-temperature char layer and pyrolysis gas on NO x reduction in a typical decoupling combustion coal-fired stove [J ] . Journal of Thermal Sciences , 2018 , 28 ( 1 ): 40 - 50 .

Burchill P , Welch L S . Variation of nitrogen content and functionality with rank for some UK bituminous coals [J ] . Fuel , 1989 , 68 ( 1 ): 100 - 104 .

Tomita A . Suppression of nitrogen oxides emission by carbonaceous reductants [J ] . Fuel Processing Technology , 2001 , ( 71 ): 53 - 70 .

Garijo E G , Jensen A D , Glarborg P . Reactivity of coal char in reducing NO [J ] . Combustion and Flame , 2004 , 136 ( 3 ): 249 - 252 .

Xie J J , Yang X M , Zhang L , et al . Emissions of SO 2 , NO and N 2 O in a circulating fluidized bed combustor during co-firing coal and biomass [J ] . Journal of Environmental Sciences , 2007 , 19 ( 1 ): 109 - 116 .

Fan W D , Lin Z C , Kuang J G , et al . Impact of air staging along furnace height on NO x emissions from pulverized coal combustion [J ] . Fuel Processing Technology , 2010 , ( 91 ): 625 - 634 .

车得福 . 煤氮热变迁与氮氧化物生成 [M ] . 西安 : 西安交通大学出版社 , 2013 .

Che D F . Thermal Coal-N Transformation and Nitrogen Oxide Generation [M ] . Xi an : Xi an Jiaotong University Press , 2013 .

方晓晴 , 范垂钢 , 都林 , 等 . 煤焦直接还原脱除烟道气氮氧化物 [J ] . 化工学报 , 2014 , 65 ( 6 ): 2249 - 2255 .

Fang X Q , Fan C G , Du L , et al . Reduction of nitric oxide in flue gas by coal char [J ] . CIESC Journal , 2014 , 65 ( 6 ): 2249 - 2255 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Selenium transformation in ultra-low-emission coal-fired power units and its enrichment characteristics in fly ash

Migration and distribution characteristics of trace elements in 220 MW cogeneration boiler

polycyclic aromatic hydrocarbons from household coal combustionsEmissions of particulate matter and

Prediction model for COD in petrochemical wastewater influent based on temporal-spatial dual-stream convolutional neural network

Study on impact of impurities in coal chemical waste salt on solvation of NaCl and Na2SO4

Related Author

LIU Xuan

SU Yinjiao

TENG Yang

ZHANG Kai

WANG Pengcheng

LI Lifeng

LI Zhen

WANG Chao

Related Institution

Beijing Key Laboratory of Emission Surveillance and Control for Thermal Power Generation, North China Electric Power University

Shanxi Hepo Power Generation Company Limited

State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology

The Research Center for Clean Coal Technology & Engineering, Yankuang Group Co.

Yankuang Technology Co., Ltd.

⁰

Simultaneous reduction of NOx and CO emissions in domestic decoupling coal-fired stoves

DOI：10.11949/j.issn.0438-1157.20181327

摘要

Abstract

关键词

Keywords

references

Simultaneous reduction of NO_x and CO emissions in domestic decoupling coal-fired stoves