Distribution characteristics of mercury speciation in coals with three different ranks

SU Yinjiao; LIU Xuan; LI Lifeng; LI Xiaohang; JIANG Ping; TENG Yang; ZHANG Kai

doi:10.11949/j.issn.0438-1157.20181311

您当前的位置：

首页 >

文章列表页 >

Distribution characteristics of mercury speciation in coals with three different ranks

Energy and environmental engineering | 更新时间：2026-07-24

- Distribution characteristics of mercury speciation in coals with three different ranks
- CIESC Journal Vol. 70, Issue 4, Pages: 1559-1566(2019)
- 作者机构：
  
  1.华北电力大学热电生产过程污染物监测与控制北京市重点实验室，北京 102206
  2.山西河坡发电有限责任公司，山西阳泉 045011
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20181311
  CLC： TQ 53
- Received：12 November 2018，
  
  Revised：2019-01-11，
  
  Online First：15 June 2020，
  
  Published：12 April 2019
- 稿件说明：
移动端阅览
苏银皎, 刘轩, 李丽锋, 李晓航, 姜平, 滕阳, 张锴. 三类煤阶煤中汞的赋存形态分布特征[J]. 化工学报, 2019, 70(4): 1559-1566

SU Yinjiao, LIU Xuan, LI Lifeng, LI Xiaohang, JIANG Ping, TENG Yang, ZHANG Kai. Distribution characteristics of mercury speciation in coals with three different ranks[J]. CIESC Journal, 2019, 70(4): 1559-1566
苏银皎, 刘轩, 李丽锋, 李晓航, 姜平, 滕阳, 张锴. 三类煤阶煤中汞的赋存形态分布特征[J]. 化工学报, 2019, 70(4): 1559-1566 DOI： 10.11949/j.issn.0438-1157.20181311.

SU Yinjiao, LIU Xuan, LI Lifeng, LI Xiaohang, JIANG Ping, TENG Yang, ZHANG Kai. Distribution characteristics of mercury speciation in coals with three different ranks[J]. CIESC Journal, 2019, 70(4): 1559-1566 DOI： 10.11949/j.issn.0438-1157.20181311.

摘要

采用逐级化学提取方法与程序升温热解方法研究了两个煤田三类煤阶六个样品中汞的赋存形态及其热稳定性。煤中汞分为可交换态（F1）、碳酸盐+硫酸盐+氧化物结合态（F2）、硅酸盐+硅铝酸盐结合态（F3）、硫化物结合态（F4）和残渣态（F5），其中F2、F4和F5约占煤中汞总量的90%以上，且F4是煤中汞最主要的赋存形态，占比达45.2%~82.1%。煤中汞的赋存形态与煤阶密切相关，随样品煤化程度加深F4的比例显著提高，但F2和F5逐渐降低，其原因可能是汞在煤变质过程中由碳酸盐、硫酸盐或有机物中逐渐迁移至硫化物中。煤中汞的热稳定性依赖于其赋存形态，其中F1热稳定性最差，在150℃以下全部释放；F3热稳定性最强，析出温度在600℃以上；其余三种结合态汞的释放温度界于以上两者之间，依次为F1 < F5 < F2 < F4 < F3；尽可能多地使汞转化为硫化物结合态中较为稳定的形态是煤燃烧及其相关过程液、固副产物中汞稳定化处理的有效方法之一。

Abstract

The occurrence and thermal stability of mercury in six samples of three coal ranks in two coal fields were studied by stepwise chemical extraction method and temperature programmed pyrolysis method. The results show that mercury in coal can be divided into five fractions: exchangeable mercury (F1)

carbonate+sulfate+oxide bound mercury (F2)

silicate+aluminosilicate bound mercury (F3)

sulfide bound mercury (F4) and residual mercury (F5). Among them

F4 and F5 account for over 90%

especially F4 ranges from 45.2% to 82.1%. Mercury speciation is heavily related to coal rank in this study. The proportion of F4 is significantly increased with increasing the degree of coalification

whilst both F2 and F5 are gradually decreased

which can be inferred that mercury combined with carbonate

sulfate and organic matter transfer to the sulfide during the metamorphic process of coal. The thermal release characteristics of mercury in coal depend on its speciation. F1 has the weakest thermal stability which completely releases when the temperature is lower than 150℃

but F3 is the strongest with the release temperature above 600℃. The release temperature of the other mercury species is between F1 and F3. As a result

the order of release temperature is F1 < F5 < F2 < F4 < F3. Based on the above findings

it should be an effective method to transform mercury into much more sulfide with stable state for stabilizing mercury speciation in liquid and solid by-products of coal combustion and other related processes.

关键词

Keywords

references

中华人民共和国国家统计局 . 中国统计年鉴 [M ] . 北京 : 中国统计出版社 , 2017 .

National Bureau of Statistics of the People s Republic of China . China Statistical Yearbook [M ] . Beijing : China Statistics Press , 2017 .

刘慧敏 , 王春波 , 张月 , 等 . 温度和赋存形态对燃煤过程中砷迁移和释放的影响 [J ] . 化工学报 , 2015 , 66 ( 11 ): 4643 - 4651 .

Liu H M , Wang C B , Zhang Y , et al . Effect of temperature and occurrence form of arsenic on its migration and volatilization during coal combustion [J ] . CIESC Journal , 2015 , 66 ( 11 ): 4643 - 4651 .

周劲松 , 齐攀 , 侯文慧 , 等 . 纳米氧化锌在模拟煤气下吸附单质汞的实验研究 [J ] . 燃料化学学报 , 2013 , 41 ( 11 ): 1371 - 1377 .

Zhou J S , Qi P , Hou W H , et al . Elemental mercury removal from syngas by nano-ZnO sorbent [J ] . Journal of Fuel Chemistry and Technology , 2013 , 41 ( 11 ): 1371 - 1377 .

郭瑞霞 , 杨建丽 , 刘东艳 , 等 . 热处理条件对大同煤中微量有害元素变迁规律的影响 [J ] . 化工学报 , 2003 , 54 ( 11 ): 1603 - 1607 .

Guo R X , Yang J L , Liu D Y , et al . Influence of thermal of treatment conditions on transformation of trace elements in Datong coal [J ] . Journal of Chemical Industry and Engineering (China) , 2003 , 54 ( 11 ): 1603 - 1607 .

魏绍青 , 滕阳 , 李晓航 , 等 . 300 MW等级燃煤机组煤粉炉与循环流化床锅炉汞排放特性比较 [J ] . 燃料化学学报 , 2017 , 45 ( 8 ): 1009 - 1016 .

Wei S Q , Teng Y , Li X H , et al . Comparison of mercury emission from around 300 MW coal-fired power generation units between pulverized boiler and circulating fluidized-bed boiler [J ] . Journal of Fuel Chemistry and Technology , 2017 , 45 ( 8 ): 1009 - 1016 .

Zhao H T , Yang G , Gao X , et al . Hg 0 -temperature-programmed surface reaction and its application on the investigation of metal oxides for Hg 0 capture [J ] . Fuel , 2016 , 181 : 1089 - 1094 .

Zhu Y C , Han X J , Huang Z G , et al . Superior activity of CeO 2 modified V 2 O 5 /AC catalyst for mercury removal at low temperature [J ] . Chemical Engineering Journal , 2018 , 337 : 741 - 749 .

李洋 , 陈敏东 , 薛志钢 , 等 . 燃煤电厂协同脱汞研究进展及强化措施 [J ] . 化工进展 , 2014 , 33 ( 8 ): 2187 - 2191 .

Li Y , Chen M D , Xue Z G , et al . Research on synergistic mercury removal of coal-fired power plants [J ] . Chemical Industry and Engineering Progress , 2014 , 33 ( 8 ): 2187 - 2191 .

Cheng C M , Cao Y , Zhang K , et al . Co-effects of sulfur dioxide load and oxidation air on mercury re-emission in forced-oxidation limestone flue gas desulfurization wet scrubber [J ] . Fuel , 2013 , 106 : 505 - 511 .

Gerald H L , Jaisen N K , Roe H Y . An evaluation of coal preparation technologies for controlling trace element emissions [J ] . Fuel Processing Technology , 2000 , 60 ( 3 ): 407 - 422 .

Lopez A A M , Diaz S M , Garcia A B , et al . Evaluation of mercury associations in two coals of different rank using physical separation procedures [J ] . Fuel , 2006 , 85 ( 10 ): 1389 - 1395 .

Diehl S F , Goldhaber M B , Hatch J R . Modes of occurrence of mercury and other trace elements in coals from the warrior field, Black Warrior Basin, Northwestern Alabama [J ] . Journal of Coal Geology , 2004 , 59 ( 3 ): 193 - 208 .

Michael E B , Ronald H A , James D C , et al . Geologic setting and characterization of coals and the modes of occurrence of selected elements from the Franklin coal zone, Puget Group, John Henry No.1 mine, King County, Washington, USA [J ] . International Journal of Coal Geology , 2005 , 63 ( 3/4 ): 247 - 275 .

罗小雨 , 苏胜 , 向军 , 等 . 汞在MnO x -CeO 2 /γ-Al 2 O 3 催化剂表面的赋存形态分析 [J ] . 化工学报 , 2015 , 66 ( 6 ): 2082 - 2088 .

Luo X Y , Su S , Xiang J , et al . Speciation of mercury formed on MnO x -CeO 2 /γ-Al 2 O 3 catalyst surface [J ] . CIESC Journal , 2015 , 66 ( 6 ): 2082 - 2088 .

Rumayor M , Gsllego J R , Rodriguez V E , et al . An assessment of the environmental fate of mercury species in highly polluted brownfields by means of thermal desorption [J ] . Journal of Hazardous Materials , 2017 , 325 : 1 - 7 .

Feng X B , Lu J Y , Gregoire D C , et al . Analysis of inorganic mercury species associated with airborne particulate matter/aerosols: method development [J ] . Analytical and Bioanalytical Chemistry , 2004 , 380 ( 4 ): 683 - 689 .

Harald B , Stefano C , Stefano C . Mercury speciation in sediments affected by dumped mining residues in the drainage area of the Idrija mercury mine [J ] . Environment Science Technology , 2000 , 34 ( 6 ): 2330 - 2336 .

Strezov V , Evans T J , Ziolkowski A , et al . Mode of occurrence and thermal stability of mercury in coal [J ] . Energy and Fuels , 2010 , 24 ( 1 ): 53 - 57 .

Uruski L , Gorecki J , Macherzynski M , et al . The ability of Polish coals to release mercury in the process of thermal treatment [J ] . Fuel Processing Technology , 2015 , 140 : 12 - 20 .

Zheng L G , Liu G J , Qi C C , et al . The use of sequential extraction to determine the distribution and modes of occurrence of mercury in Permian Huaibei coal, Anhui Province, China [J ] . International Journal of Coal Geology , 2008 , 73 ( 2 ): 139 - 155 .

Method 29 — Determination of Metals Emissions from Stationary Sources [S ] . United States : United States Environmental Protection Agency , 2009 .

Tessier P , Bisson M . Sequential extraction procedure for the speciation of particulate trace metals [J ] . Analytical Chemistry , 1979 , 51 ( 7 ): 844 - 851 .

Palmer C A , Mroczkowski S J , Finkelman R B , et al . The use of sequential leaching to quantify the modes of occurrence of elements in coal [C ] // Pittsburgh Coal Conference . Pittsburgh, PA, United States , 1998 .

Panyametheekul S . An operationally defined method to determine the speciation of mercury [J ] . Environmental Geochemistry and Health , 2004 , 26 ( 1 ): 51 - 57 .

Lopez A A M , Yuan Y , Perry R , et al . Analysis of mercury species present during coal combustion by thermal desorption [J ] . Fuel , 2010 , 89 ( 3 ): 629 - 634 .

Luo G Q , Yao H , Xu M H , et al . Identifying modes of occurrence of mercury in coal by temperature programmed pyrolysis [J ] . Proceedings of the Combustion Institute , 2011 , 33 ( 2 ): 2763 - 2769 .

郭少青 , 杨建丽 , 刘振宇 . 晋城煤中汞的热稳定性与赋存形态的研究 [J ] . 燃料化学学报 , 2009 , 37 ( 1 ): 115 - 118 .

Guo S Q , Yang J L , Liu Z Y . Thermal stability and occurrence of forms of mercury in Jincheng coal [J ] . Journal of Fuel Chemistry and Technology , 2009 , 37 ( 1 ): 115 - 118 .

赵峰华 . 煤中有害微量元素分布赋存机制及燃煤产物淋滤实验研究 [D ] . 北京 : 中国矿业大学 , 1997 .

Zhao F H . Study on the mechanism of distributions and occurrences of hazardous minor and trace elements in coal and leaching experiments of coal combustion residues [D ] . Beijing : China University of Mining & Technology , 1997 .

吴辉 . 燃煤汞释放及转化的实验与机理研究 [D ] . 武汉 : 华中科技大学 , 2011 .

Wu H . Experimental and mechanism study on mercury emission and transformation during coal combustion [D ] . Wuhan : Huazhong University of Science & Technology , 2011 .

Cláudia C W , Rolf D W , Wilson D F . Mercury speciation in contaminated soils by thermal release analysis [J ] . Water , Air and Soil Pollution , 1996 , 89 : 399 - 416 .

Finkelman R B . Modes of occurrence of potentially hazardous elements in coal: levels of confidence [J ] . Fuel Processing Technology , 1994 , 39 ( 1/2/3 ): 21 - 34 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Recent advances on the speciation distribution of heavy metals in sludge pyrolysis residue

Silicon distribution in straw black liquor recovery process of pyrolysis and combustion

Thermo-oxidative degradation characteristics of TPT backsheet from end-of-life photovoltaic modules

Preparation of Zn-CuOx/MgO-SiO2 aerogel catalyst with strong electron transfer ability and its catalytic ozonation mechanism and toxicity evaluation on sulfamethoxazole

Deformation and fragmentation characteristics of liquid marbles under the action of non-uniform electric field

Related Author

QUAN Cui

ZHANG Guangtao

XU Yu

GAO Ningbo

YUAN Hongyou

WU Shubin

YIN Xiuli

HUANG Yanqin

Related Institution

School of Energy and Power Engineering, Xi’an Jiaotong University

State Key Laboratory of Petroleum Pollutant Control

State Key Laboratory of Pulp and Paper Engineering, South China University of Technology

Key Laboratory of Renewable Energy, Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences

State Key Laboratory of Multiphase Flow in Power Engineering, Xi’an Jiaotong University

⁰