Visual measurement and data analysis of pool boiling on silicon surfaces

CHEN Hongxia; SUN Yuan; GONG Yifei; HUANG Linbin

doi:10.11949/j.issn.0438-1157.20181298

您当前的位置：

首页 >

文章列表页 >

Visual measurement and data analysis of pool boiling on silicon surfaces

Fluid dynamics and transport phenomena | 更新时间：2026-07-24

- Visual measurement and data analysis of pool boiling on silicon surfaces
- CIESC Journal Vol. 70, Issue 4, Pages: 1309-1317(2019)
- 作者机构：
  
  华北电力大学能源动力与机械工程学院，北京 102206
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20181298
  CLC： TK 121
- Received：05 November 2018，
  
  Revised：2019-01-19，
  
  Online First：15 June 2020，
  
  Published：12 April 2019
- 稿件说明：
移动端阅览
陈宏霞, 孙源, 宫逸飞, 黄林滨. 单晶硅表面池沸腾可视化测量及数据分析[J]. 化工学报, 2019, 70(4): 1309-1317

CHEN Hongxia, SUN Yuan, GONG Yifei, HUANG Linbin. Visual measurement and data analysis of pool boiling on silicon surfaces[J]. CIESC Journal, 2019, 70(4): 1309-1317
陈宏霞, 孙源, 宫逸飞, 黄林滨. 单晶硅表面池沸腾可视化测量及数据分析[J]. 化工学报, 2019, 70(4): 1309-1317 DOI： 10.11949/j.issn.0438-1157.20181298.

CHEN Hongxia, SUN Yuan, GONG Yifei, HUANG Linbin. Visual measurement and data analysis of pool boiling on silicon surfaces[J]. CIESC Journal, 2019, 70(4): 1309-1317 DOI： 10.11949/j.issn.0438-1157.20181298.

摘要

针对核态沸腾过程，利用高速摄像机和红外热成像设备对光滑、微坑、均匀微柱和槽型微柱四种不同单晶硅表面的沸腾现象进行了在线可视观测，获得了各表面气泡动力学演变过程及局部温度演变规律，揭露了基于动力学过程的沸腾强化机理。由沸腾曲线可知，光滑硅表面，沸腾起始过热度为6℃，而三种微结构表面，起沸过热度为3～4℃；同时，微坑、槽型微柱和均匀微柱表面核态沸腾的CHF较光滑表面分别提高了109%、129%和140%。动力学演变过程则证明了微坑的存在为核化沸腾提供了核化点，有效降低了核化能垒、缩短了壁面蓄能阶段的时长。微柱的存在大幅度增加了气泡核化密度，减小了脱离直径，缩短了脱离时间，促进了沸腾表面温度的均匀化。

Abstract

The high-speed video and high-speed infrared were used to visual measure the boiling phenomenon on four kinds of monocrystalline silicon surfaces including smooth

cavity

pitch and groove-pitch surfaces. The dynamic evolution process and the local temperature evolution law reveal the boiling enhancement mechanism based on the dynamic process. For the smooth silicon surface

the superheat is 6℃ when the boiling starts under low heat transfer

and this superheat is around 3－4℃ for the three micro-structured surfaces. In addition

compared with the smooth surface

the CHF for cavity

groove-pitch and pitch surfaces are increased by 109%

129% and 140%

respectively. According to the dynamic evolution of bubble

cavities provide the nucleation sites

decrease the nucleation barrier energy and shrink the energy accumulation stage. Pitches significant increase nucleation sites

decrease departure diameter and departure time of bubbles

which uniform the boiling surface temperature.

关键词

Keywords

references

纪献兵 , 徐进良 . 流体在超轻多孔金属泡沫中的流动和换热特性 [J ] . 化工学报 , 2009 , 60 ( 1 ): 21 - 27 .

Ji X B , Xu J L . Fluid flow and heat transfer characteristics in ultra light porous metal foam [J ] . CIESC Journal , 2009 , 60 ( 1 ): 21 - 27 .

朱禹 , 胡海涛 , 丁国良 , 等 . 制冷剂/油在泡沫金属加热表面池沸腾换热特性 [J ] . 化工学报 , 2011 , 62 ( 2 ): 329 - 335 .

Zhu Y , Hu H T , Ding G L , et al . Nucleate pool boiling heat transfer characteristics of regrigerant/oil mixture on metal foam covers [J ] . CIESC Journal , 2011 , 62 ( 2 ): 329 - 335 .

逯国强 , 韩吉田 , 孔令健 , 等 . 卧式螺旋管内流动换热壁温分布特性 [J ] . 化工学报 , 2014 , 65 ( S1 ): 152 - 156 .

Lu G Q , Han J T , Kong L J , et al . Wall temperature distribution characteristics of flow and heat transfer inside horizontal helically-coiled tube [J ] . CIESC Journal , 2014 , 65 ( S1 ): 152 - 156 .

Xu J , Ji X , Yang W , et al . Modulated porous wick evaporator for loop heat pipes: experiment [J ] . International Journal of Heat and Mass Transfer , 2014 , 72 : 163 - 176 .

Das S , Saha B , Bhaumik S . Experimental study of nucleate pool boiling heat transfer of water by surface functionalization with SiO 2 nanostructure [J ] . Experimental Thermal and Fluid Science , 2017 , 81 : 454 - 465 .

Gheitaghy A M , Saffari H , Ghasimi D , et al . Effect of electrolyte temperature on porous electrodeposited copper for pool boiling enhancement [J ] . Applied Thermal Engineering , 2017 , 113 : 1097 - 1106 .

Wang Y Q , Mo D C , Lyu S S . Enhanced pool boiling heat transfer on mono and multi-layer micro-nano bi-porous copper surfaces [C ] // ASME 2016 5th International Conference on Micro/Nanoscale Heat and Mass Transfer . Biopolis, Singapore , 2016 : V 001T04A005 .

Byon C , Choi S , Kim S J . Critical heat flux of bi-porous sintered copper coatings in FC-72 [J ] . International Journal of Heat and Mass Transfer , 2013 , 65 : 655 - 661 .

郭兆阳 , 徐鹏 , 王元华 , 等 . 烧结型多孔表面管外池沸腾传热特性 [J ] . 化工学报 , 2012 , 63 ( 12 ) : 3798 - 3804 .

Guo Z Y , Xu P , Wang Y H , et al . Pool boiling heat transfer on sintered porous coating tubes [J ] . CIESC Journal , 2012 , 63 ( 12 ): 3798 - 3804 .

Zupančič M , Steinbücher M , Gregorčič P , et al . Enhanced pool-boiling heat transfer on laser-made hydrophobic/superhydrophilic polydimethylsiloxane-silica patterned surfaces [J ] . Applied Thermal Engineering , 2015 , 91 : 288 - 297 .

Lu M C , Huang C H , Huang C T , et al . A modified hydrodynamic model for pool boiling CHF considering the effects of heater size and nucleation site density [J ] . International Journal of Thermal Sciences , 2015 , 91 : 133 - 41 .

Rainey K N , You S M . Pool boiling heat transfer from plain and microporous, square pin-finned surfaces in saturated FC-72 [J ] . Journal of Heat Transfer , 2000 , 122 ( 3 ): 509 - 516 .

Clark H B , Strenge P S , Westwater J W . Active sites for nucleate boiling [J ] . Chemical Engineering Progress Symposium , 1959 , 56 ( 29 ): 103 - 110 .

Shoji M , Takagi Y . Bubbling features from a single artificial cavity [J ] . International Journal of Heat and Mass Transfer , 2001 , 44 ( 14 ): 2763 - 2776 .

Hsu Y Y . On the size range of active nucleation cavities on a heating surface [J ] . Journal of Heat Transfer , 1962 , 84 ( 3 ): 207 - 213 .

Kim S H , Lee G C , Kang J Y , et al . Boiling heat transfer and critical heat flux evaluation of the pool boiling on micro structured surface [J ] . International Journal of Heat and Mass Transfer , 2015 , 91 : 1140 - 1147 .

Dong L , Quan X , Cheng P . An experimental investigation of enhanced pool boiling heat transfer from surfaces with micro/nano-structures [J ] . International Journal of Heat and Mass Transfer , 2014 , 71 : 189 - 196 .

Honda H , Takamastu H , Wei J J . Enhanced boiling of FC-72 on silicon chips with micro-pin-fins and submicron-scale roughness [J ] . Journal of Heat Transfer , 2002 , 124 ( 2 ): 383 .

Hutter C , Kenning D B R , Sefiane K , et al . Experimental pool boiling investigations of FC-72 on silicon with artificial cavities and integrated temperature microsensors [J ] . Experimental Thermal and Fluid Science , 2010 , 34 ( 4 ): 422 - 433 .

Lie Y M , Ke J H , Chang W R , et al . Saturated flow boiling heat transfer and associated bubble characteristics of FC-72 on a heated micro-pin-finned silicon chip [J ] . International Journal of Heat and Mass Transfer , 2007 , 50 ( 19/20 ): 3862 - 3876 .

Yu C K , Lu D C , Cheng T C . Pool boiling heat transfer on artificial micro-cavity surfaces in dielectric fluid FC-72 [J ] . Journal of Micromechanics and Microengineering , 2006 , 16 ( 10 ): 2092 - 2099 .

Zhao Y H , Masuoka T , Tsuruta T . Unified theoretical prediction of fully developed nucleate boiling and critical heat flux based on a dynamic microlayer model [J ] . International Journal of Heat and Mass Transfer , 2002 , 45 ( 15 ): 3189 - 3197 .

刁彦华 , 赵耀华 . R-141b池沸腾气泡行为的可视化及传热研究 [C ] // 2004年传热传质学学术会议 . 吉林 , 2004 : 043288 .

Diao Y H , Zhao Y H . Visual study on bubble dynamics and heat transfer mechanism of pool boiling of R-141 b[C ] // Heat Mass Transfer Conference of China . Jilin , 2004 : 043288 .

刁彦华 , 赵耀华 , 王秋良 . R-113池沸腾气泡行为的可视化及传热机理 [J ] . 化工学报 , 2005 , 56 ( 2 ): 227 - 234 .

Diao Y H , Zhao Y H , Wang Q L . Bubble dynamics and heat transfer mechanism of pool boiling of R-113 [J ] . Journal of Chemical Industry and Engineering(China) , 2005 , 56 ( 2 ): 227 - 234 .

Gerardi C , Buongiorno J , Hu L W , et al . Study of bubble growth in water pool boiling through synchronized, infrared thermometry and high-speed video [J ] . International Journal of Heat and Mass Transfer , 2010 , 53 ( 19/20 ): 4185 - 4192 .

Gerardi C B J , Hu L W , Mckrell T . Infrared thermometry study of nanofluid pool boiling phenomena [J ] . Nano Scale Research Letters , 2011 , 6 ( 1 ): 232 .

Jung J , Kim S J , Kim J . Observations of the critical heat flux process during pool boiling of FC-72 [J ] . Journal of Heat Transfer , 2014 , 136 ( 4 ): 041501 .

Dhillon N S , Buongiorno J , Varanasi K K . Critical heat flux maxima during boiling crisis on textured surfaces [J ] . Nature Communications , 2015 , 6 : 8247 .

Golobic I , Zupancic M . Wall-temperature distributions of nucleate pool boiling surfaces vs. boiling curves: a new approach [J ] . International Journal of Heat and Mass Transfer , 2016 , 99 : 541 - 547 .

Chen H X , Sun Y , Huang L B , et al . Nucleation and sliding growth of boiling bubbles on locally heated silicon surfaces [J ] . Applied Thermal Engineering , 2018 , 143 : 1068 - 1078 .

Zuber N . Hydrodynamic Aspects of Boiling Heat Transfer [M ] . United States : AEC Report , 1959 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Study on enhanced pool boiling heat transfer based on self-driven jet device

Investigation of enhanced boiling heat transfer on porous structural surfaces by high voltage electric field

Numerical simulation and performance optimization of a new loop gravity heat pipe

Experimental study on boiling dynamics modulation by porous foam deaeration board

Study on pool boiling heat transfer performance of trapezoidal microchannel surface

Related Author

DONG Wuhan

ZUO Qirong

GAO Ming

SU Zeshi

WANG Junfeng

ZUO Lei

XU Haojie

WANG Chen

Related Institution

School of Energy and Power Engineering, University of Shanghai for Science and Technology

School of Energy and Power Engineering, Jiangsu University

School of Electric Power, South China University of Technology

Guangdong Province Key Laboratory of Efficient and Clean Energy Utilization, South China University of Technology

State Key Laboratory of Subtropical Building Science, South China University of Technology

⁰