Phase behavior of K-Mg mixed salt during transformation-flotation from Yiliping magnesium sulfate-type salt lake

SHI Lijie; WANG Min

doi:10.11949/j.issn.0438-1157.20181286

您当前的位置：

首页 >

文章列表页 >

Phase behavior of K-Mg mixed salt during transformation-flotation from Yiliping magnesium sulfate-type salt lake

Separation engineering | 更新时间：2026-07-24

- Phase behavior of K-Mg mixed salt during transformation-flotation from Yiliping magnesium sulfate-type salt lake
- CIESC Journal Vol. 70, Issue 5, Pages: 1832-1841(2019)
- 作者机构：
  
  1.中国科学院青海盐湖研究所，中国科学院盐湖资源综合高效利用重点实验室，青海西宁 810008
  2.青海省盐湖资源化学重点实验室，青海西宁 810008
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20181286
  CLC： TQ 443；O 643.12
- Received：31 October 2018，
  
  Revised：2019-02-18，
  
  Online First：24 July 2026，
  
  Published：05 May 2019
- 稿件说明：
移动端阅览
时历杰, 王敏. 一里坪硫酸镁亚型盐湖钾镁混盐转化-浮选中物相行为[J]. 化工学报, 2019, 70(5): 1832-1841

SHI Lijie, WANG Min. Phase behavior of K-Mg mixed salt during transformation-flotation from Yiliping magnesium sulfate-type salt lake[J]. CIESC Journal, 2019, 70(5): 1832-1841
时历杰, 王敏. 一里坪硫酸镁亚型盐湖钾镁混盐转化-浮选中物相行为[J]. 化工学报, 2019, 70(5): 1832-1841 DOI： 10.11949/j.issn.0438-1157.20181286.

SHI Lijie, WANG Min. Phase behavior of K-Mg mixed salt during transformation-flotation from Yiliping magnesium sulfate-type salt lake[J]. CIESC Journal, 2019, 70(5): 1832-1841 DOI： 10.11949/j.issn.0438-1157.20181286.

摘要

加水比例及物相行为研究对硫酸镁亚型盐湖钾镁混盐转化制备软钾镁矾工艺具有重要意义。以柴达木盆地一里坪盐湖钾镁混盐为对象，采用“转化-浮选”法制备钾盐镁矾，研究了钾镁混盐初始及转化产生的物相行为。结果表明，初始物相光卤石、水氯镁石溶解速率最快，分解得到新物相氯化钾。初始物相钾盐镁矾及其转化得到的新物相软钾镁矾，溶解转化速率次之，加水比例高于0.40时，速率趋于平缓。初始物相氯化钠溶解速率始终最低。转化过程中，氯化钾只发生溶解行为，并未与软钾镁矾反应生成新物相硫酸钾。转化实验结果与理论计算结果吻合度高，相对误差低于4%，利用介稳相图理论计算能够指导钾镁混盐转化。同时，正浮选捕收剂对含钾物相的捕收吸附能力强于反浮选，钾的总收率达到66%。

Abstract

Study on water-salt mass ratio and phase behavior during the K-Mg mixed salt transformation from magnesium sulfate-type salt lake is important for preparing Pic (Picromerite). Pic was prepared from the K-Mg mixed salt of Yiliping salt lake in Qaidam Basin by means of transformation-flotation. Phase behavior was researched which was the initial and new produced by transformation. The results showed that the dissolution rate of the initial phase Car (Carnallite) and Bis (Bischofite) was the fastest

and the new phase KCl (Sylvite) was obtained by decomposition. The dissolution and transformation rate of the initial phase Kai (Kainite) and the new phase Pic transformed from Kai was second

and while the water-salt mass ratio was higher than 0.40

the rate tended to be flat. The dissolution rate of the initial phase NaCl (Halite) was always the lowest. During the transformation

KCl only dissolved

didn’t react with Pic to form a new phase SOP (potassium sulfate). Experimental results of the K-Mg mixed salt transformation were in good agreement with theoretical calculation results

the relative error was less than 4% between them

the theoretical calculations of the metastable phase diagram could be used to guide the K-Mg mixed salt transformation better. Finally

the obverse flotation collector had stronger capacity for collecting and adsorbing the K-containing phase than the reverse

the total yield of K had been reached 66%.

关键词

Keywords

references

郭如新 . 硫酸钾镁肥的过去、现状和未来前景 [J ] . 磷肥与复肥 , 2009 , 24 ( 3 ): 59 - 61 .

Guo R X . Past, current status and future prospect of langbeinite fertilizer [J ] . Phosphate & Compound Fertilizer , 2009 , 24 ( 3 ): 59 - 61 .

赵永宝 . 近几年钾肥生产技术发展现状 [J ] . 盐业与化工 , 2016 , 45 ( 4 ): 9 - 13 .

Zhao Y B . Production technological development status of potash in recent years [J ] . Journal of Salt and Chemical Industry , 2016 , 45 ( 4 ): 9 - 13 .

宋彭生 , 李武 , 孙柏 , 等 . 盐湖资源开发利用进展 [J ] . 无机化学学报 , 2011 , 27 ( 5 ): 801 - 815 .

Song P S , Li W , Sun B , et al . Recent development on comprehensive utilization of salt lake resources [J ] . Chinese Journal of Inorganic Chemistry , 2011 , 27 ( 5 ): 801 - 815 .

王长青 , 宋彭生 . 硫酸盐型盐湖卤水天然制取软钾镁矾 [J ] . 应用化学 , 1991 , 8 ( 1 ): 28 - 32 .

Wang C Q , Song P S . Preparation of schoenite from brine by natural evaporation [J ] . Chinese Journal of Applied Chemistry , 1991 , 8 ( 1 ): 28 - 32 .

金作美 , 肖显志 , 梁式梅 . (Na + 、K + 、Mg 2+ ), (Cl - 、SO 4 2- ), H 2 O五元系统介稳平衡的研究 [J ] . 化学学报 , 1980 , 38 ( 4 ): 313 - 321 .

Jin Z M , Xiao X Z , Liang S M . Study of the metastable equilibrium for pentanary system of (Na + ,K + ,Mg 2+ ), (Cl - ,SO 4 2- ), H 2 O [J ] . Acta Chimica Sinica , 1980 , 38 ( 4 ): 313 - 321 .

李刚 , 吴景泉 . 利用盐田钾镁混盐矿制取软钾镁矾的研究 [J ] . 盐湖研究 , 1998 , 6 ( 2 / 3 ): 49 - 52 .

Li G , Wu J Q . Study on the separation of picromerite from the mixture of potassium and magnesium produced from salar ponds [J ] . Journal of Salt Lake Science , 1998 , 6 ( 2 / 3 ): 49 - 52 .

谈霞 , 李宏灿 . 热溶结晶法制取硫酸钾镁肥的实验研究 [J ] . 无机盐工业 , 2013 , 45 ( 5 ): 35 - 37 .

Tan X , Li H C . Study on preparation of potassium-magnesium sulfate fertilizer with thermally dissolved cold crystallization method [J ] . Inorganic Chemicals Industry , 2013 , 45 ( 5 ): 35 - 37 .

程怀德 , 马海州 . 利用硫酸盐型盐湖资源制取软钾镁矾的研究 [J ] . 盐业与化工 , 2008 , 37 ( 3 ): 24 - 26 .

Cheng H D , Ma H Z . Study of preparing schoenite from sulfate-type saline resources [J ] . Journal of Salt and Chemical Industry , 2008 , 37 ( 3 ): 24 - 26 .

李陇岗 , 曾英 , 杨建元 , 等 . 钾镁混盐“反浮选-转化法”制取软钾镁矾的研究 [J ] . 盐业与化工 , 2012 , 41 ( 11 ): 11 - 14 .

Li L G , Zeng Y , Yang J Y , et al . Study on the preparation of schoenite from K-Mg mixing salt with reverse flotation and convention method [J ] . Journal of Salt and Chemical Industry , 2012 , 41 ( 11 ): 11 - 14 .

甘顺鹏 , 季荣 , 李昱昀 . 新型捕收剂CB-805浮选制取硫酸钾镁肥工艺研究 [J ] . 化工矿物与加工 , 2013 , ( 11 ): 7 - 9 .

Gan S P , Ji R , Li Y Y . Research on process of potash magnesium sulphate fertilizer production by flotation with new collector CB-805 [J ] . Industrial Minerals & Processing , 2013 , ( 11 ): 7 - 9 .

黄尚泉 . 钾混盐矿制取硫酸钾工艺研究 [J ] . 化工矿物与加工 , 2013 , ( 8 ): 6 - 7 .

Huang S Q . Study of process for production of potassium sulfate from potassium mixed salt [J ] . Industrial Minerals & Processing , 2013 , ( 8 ): 6 - 7 .

谈霞 , 杨蓉飞 . 硫酸镁亚型盐湖钾肥生产中尾矿回收钾镁肥的研究 [J ] . 无机盐工业 , 2014 , 46 ( 10 ): 50 - 52 .

Tan X , Yang R F . Research on recycling of potassium magnesium fertilizer from tailings in potash production of subtype magnesium sulfate salt lake [J ] . Inorganic Chemicals Industry , 2014 , 46 ( 10 ): 50 - 52 .

张明强 , 胡勇 . 新疆某钾镁盐矿浮选回收软钾镁矾试验 [J ] . 现代矿业 , 2017 , ( 4 ): 136 - 138 .

Zhang M Q , Hu Y . Research on recycling of schoenite from K-Mg mixed salt of Xinjiang by flotation [J ] . Modern Mining , 2017 , ( 4 ): 136 - 138 .

时历杰 , 王敏 . 柴达木盆地一里坪盐湖卤水水化学及夏季蒸发中钾、锂、硼行为 [J ] . 湖泊科学 , 2019 , 31 ( 2 ): 590 - 608 .

Shi L J , Wang M . Hydrochemistry and behavior of K, Li and B in summer evaporation of Yiliping salt lake brine in Qaidam basin [J ] . Journal of Lake Sciences , 2019 , 31 ( 2 ): 590 - 608 .

金作美 , 周惠南 , 王励生 . Na + , K + , Mg 2+ //Cl - , SO 4 2- -H 2 O五元体系15℃介稳相图研究 [J ] . 高等学校化学学报 , 2002 , 23 ( 4 ): 690 - 694 .

Jin Z M , Zhou H N , Wang L S . Studies on the metastable phase equilibrium of Na + , K + , Mg 2+ //Cl - , SO 4 2- -H 2 O quinary system at 15℃ [J ] . Chemical Journal of Chinese Universities , 2002 , 23 ( 4 ): 690 - 694 .

中国科学院青海盐湖研究所分析室 . 卤水和盐的分析方法 [M ] . 2 版. 北京 : 科学出版社 , 1988 .

Qinghai Institute of Salt Lakes , Chinese Academy of Sciences . Analysis Methods for Brines and Salts [M ] . 2nd ed. Beijing : Science Press , 1988 .

Neitzel U E G . Method for the production of high-grade kainite: US3589871 [P ] . 1971-06-29 .

Choudhari B P . Deposition of primary kainite from marine bitterns in solar evaporation [J ] . J. Appl. Chem. Biotechnol ., 1971 , 21 ( 9 ): 266 - 267 .

毕思峰 . 一里坪盐湖卤水的自然及冷冻蒸发实验 [D ] . 西宁 : 青海大学 , 2016 .

Bi S F . Study on natural and freezing evaporation of Yiliping brine [D ] . Xining : Qinghai University , 2016 .

Bi S F , Cui X M . Comparison between simulated evaporation and natural evaporation of inter-crystal brine in Yiliping salt lake [J ] . Carbonates and Evaporites , 2018 , 33 ( 2 ): 235 - 241 .

安东 , 张志宏 , 付振海 , 等 . 硫酸盐型卤水蒸发过程钾盐镁矾结晶区域研究 [J ] . 无机盐工业 , 2015 , 47 ( 8 ): 49 - 52 .

An D , Zhang Z H , Fu Z H , et al . Crystallizing region of kainite in sulfate-type brine evaporation process [J ] . Inorganic Chemicals Industry , 2015 , 47 ( 8 ): 49 - 52 .

Garrett D E . Potash—Deposits, Processing, Properties and Uses [M ] . London : Chapman & Hall , 1996 .

沈菊 , 张彩岳 , 许显花 , 等 . 1980—2015年柴达木盆地地表温度变化特征 [J ] . 中国农学通报 , 2016 , 32 ( 35 ): 58 - 64 .

Shen J , Zhang C Y , Xu X H , et al . Variation characteristics of surface temperature in Qaidam basin 1980—2015 [J ] . Chinese Agricultural Science Bulletin , 2016 , 32 ( 35 ): 58 - 64 .

金作美 , 周惠南 , 王励生 . Na + , K + , Mg 2+ //Cl - , SO 4 2- -H 2 O五元体系35℃介稳相图研究 [J ] . 高等学校化学学报 , 2001 , 22 ( 4 ): 634 - 638 .

Jin Z M , Zhou H N , Wang L S . Studies on the metastable phase equilibrium of Na + , K + , Mg 2+ //Cl - , SO 4 2- -H 2 O quinary system at 35℃ [J ] . Chemical Journal of Chinese Universities , 2001 , 22 ( 4 ): 634 - 638 .

梁保民 . 水盐体系相图原理及运用 [M ] . 北京 : 轻工业出版社 , 1986 .

Liang B M . Salt-water System Phase Diagrams: Principles and Applications [M ] . Beijing : China Light Industry Press , 1986 .

Hadzeriga P . Dynamic equilibria in the solar evaporation of the Great Salt Lake brine [J ] . AIME Transactions , 1967 , 238 : 413 - 419 .

Neitzel U . 100 Jahre Langbeinit [J ] . Kali und Steinsalz , 1992 , 11 ( 1 / 2 ): 7 - 13 .

Neitzel U . 无水钾镁矾的100年 [J ] . 王连第 , 译 . 化工矿产地质 , 1995 , 17 ( 4 ): 281 - 285 .

Neitzel U . 100 Jahre Langbeinit [J ] . Wang L D, trans. Geology of Chemical Minerals , 1995 , 17 ( 4 ): 281 - 285 .

Hancer M , Miller J D . The flotation chemistry of potassium double salts: schoenite, kainite, and carnallite [J ] . Mine. Eng ., 2000 , 13 ( 14 / 15 ): 1483 - 1493 .

权朝明 . 十二烷基吗啉与氯化钠、氯化钾及光卤石表面作用机理 [D ] . 北京 : 中国科学院大学 , 2017 .

Quan C M . Surface interaction mechanism of dodecylmorpholine with sodium chloride, potassium chloride and carnallite [D ] . Beijing : University of Chinese Academy of Sciences , 2017 .

张婉萍 , 宋兴福 , 李晓松 , 等 . 十二烷基吗啉选择性浮选氯化钠颗粒的作用原理 [J ] . 化工学报 , 2006 , 57 ( 5 ): 1171 - 1176 .

Zhang W P , Song X F , Li X S , et al . Selective flotation mechanism sodium chloride particle with dodecylmorpholine [J ] . Journal of Chemical Industry and Engineering(China) , 2006 , 57 ( 5 ): 1171 - 1176 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Preparation of DMAPS-modified PVDF membranes via pre-radiation-induced graft polymerization for effective oil/water emulsion separation

Progress in preparation and application of porous fiber materials

Performance and application of specialized dry water material spraying agents

Recent progress in the preparation, structure, and application of thermal insulation materials

Preparation and heat resistance of cyanide-derived benzoxazine resins

Related Author

YU Zhuangzhuang

TONG Tong

ZHA Shangwen

ZHANG Shenxiang

XU Jie

LIU Xiangdong

YANG Yaoyong

WANG Quan

Related Institution

College of Chemistry, Chemical Engineering and Materials Science, Soochow University

Shanghai Eco Polymer Sci & Tech Co., Ltd.

School of Materials Science and Engineering, Zhejiang Sci-Tech University

School of Civil Engineering and Architecture, Anhui University of Science and Technology

School of Chemical and Blasting Engineering, Anhui University of Science and Technology

⁰