Effect of evaporator heat transfer process on selection of mixture and operating condition in ORC system

CHEN Yuting; XU Yanyan; WANG Lei; YE Shuang; HUANG Weiguang

doi:10.11949/j.issn.0438-1157.20181238

您当前的位置：

首页 >

文章列表页 >

Effect of evaporator heat transfer process on selection of mixture and operating condition in ORC system

Fluid dynamics and transport phenomena | 更新时间：2026-07-24

- Effect of evaporator heat transfer process on selection of mixture and operating condition in ORC system
- CIESC Journal Vol. 70, Issue 5, Pages: 1723-1733(2019)
- 作者机构：
  
  1.中国科学院上海高等研究院，上海 201210
  2.中国科学院大学，北京 100049
  3.上海科技大学，上海 201210
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20181238
  CLC： TK 114
- Received：22 October 2018，
  
  Revised：2019-01-31，
  
  Online First：24 July 2026，
  
  Published：05 May 2019
- 稿件说明：
移动端阅览
陈玉婷, 徐燕燕, 王磊, 叶爽, 黄伟光. 蒸发器换热过程对ORC系统混合工质选择和运行工况的影响[J]. 化工学报, 2019, 70(5): 1723-1733

CHEN Yuting, XU Yanyan, WANG Lei, YE Shuang, HUANG Weiguang. Effect of evaporator heat transfer process on selection of mixture and operating condition in ORC system[J]. CIESC Journal, 2019, 70(5): 1723-1733
陈玉婷, 徐燕燕, 王磊, 叶爽, 黄伟光. 蒸发器换热过程对ORC系统混合工质选择和运行工况的影响[J]. 化工学报, 2019, 70(5): 1723-1733 DOI： 10.11949/j.issn.0438-1157.20181238.

CHEN Yuting, XU Yanyan, WANG Lei, YE Shuang, HUANG Weiguang. Effect of evaporator heat transfer process on selection of mixture and operating condition in ORC system[J]. CIESC Journal, 2019, 70(5): 1723-1733 DOI： 10.11949/j.issn.0438-1157.20181238.

摘要

在有机朗肯循环（ORC）系统其他部件的效率均相同的条件下，蒸发器的换热量越大，不可逆损失越小，系统的做功潜力就越大。由于混合工质的相变温度滑移与热源的温度变化具有较好的“匹配性”，采用混合工质为循环工质，并使用

https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=113947439&type=

https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=113947407&type=

https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=113947406&type=

2.75166678

2.92100000

流耗散率来描述混合工质与热源流体换热过程中的不可逆损失。结合

T-Q

图来分析蒸发器中混合工质与热源流体换热过程，发现混合工质与热源流体换热曲线围成的面积为

https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=113947439&type=

https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=113947430&type=

https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=113947441&type=

2.75166678

2.92100000

流耗散率，并且分别得出了蒸发器换热量最大与不可逆损失最小的条件，以此指导系统最佳混合工质和运行条件的选择。针对确定的热源条件，在蒸发器换热量达到最大的条件下，以不可逆损失最小为目标，建立了基于蒸发器性能的系统最佳混合工质和运行条件的选择方法。采用参考文献中热源条件，筛选出最佳混合工质为R600a/R134a(0.2/0.8)，在最佳蒸发器出口温度为365.75 K的运行条件下，换热量是文献中最佳混合工质的3.3倍，在系统其他部件的参数选择均相同的条件下，系统的净输出功率是文献中最佳混合工质的2.4倍。

Abstract

Under the condition of the same efficiency of other parts of organic Rankine cycle (ORC) system

the greater the heat exchange capacity of the evaporator

the smaller the irreversible loss

and the greater the potential of the system. Because of the phase transition temperature glide of mixture has good “matching” with the temperature change of heat source

this paper uses mixture as working fluid

and uses entransy flow dissipation rate to represent the irreversible loss of heat transfer process between mixture and heat source fluid. Combining

T-Q

diagram

the heat transfer process of mixture and heat source fluid in evaporator is analyzed. It is found that the area enclosed by the heat transfer curves of mixture and heat source fluid is the entransy flow dissipation rate

and the conditions of maximum heat transfer quantity and minimum irreversible loss of evaporator are obtained respectively

to guide the selecting of the optimal mixture and operation condition. According to the determined heat source

under the condition of max

imum heat transfer quantity

a method for selecting the optimal mixture and optimal operating condition of the system based on the performance of evaporator is established. Adopting the heat source listed in reference paper

the optimum mixture and optimum outlet temperature are R600a/R134a(0.2/0.8) and 365.75 K

respectively. The heat transfer quantity of the evaporator is 3.3 times

under the condition that the parameters of other parts of the system are the same

the net output power of the system is 2.4 times than the optimum mixture in the literature.

关键词

Keywords

references

Quoilin S , Declaye S , Tchanche B F , et al . Thermo-economic optimization of waste heat recoveryorganic Rankine cycles [J ] . Applied Thermal Engineering , 2011 , 31 ( 14 / 15 ): 2885 - 2893 .

Carcasci C , Winchler L . Thermodynamic analysis of an organic Rankine cycle for waste heat recovery from an aeroderivative intercooled gas turbine [J ] . Energy Procedia , 2016 , 101 : 862 - 869 .

Li G . Organic Rankine cycle performance evaluation and thermoeconomic assessment with various applications (Ⅱ): Economic assessment aspect [J ] . Renewable & Sustainable Energy Reviews , 2016 , 64 : 490 - 505 .

Freeman J , Hellgardt K , Markides C N . An assessment of solar-powered organic Rankine cycle systems for combined heating and power in UK domestic applications [J ] . Applied Energy , 2015 , 138 : 605 - 620 .

Proctor M J , Yu W , Kirkpatrick R D , et al . Dynamic modelling and validation of a commercial scale geothermal organic Rankine cycle power plant [J ] . Geothermics , 2016 , 61 : 63 - 74 .

Chys M , Broek M V D , Vanslambrouck B , et al . Potential of zeotropic mixtures as working fluids in organic Rankine cycles [J ] . Energy , 2012 , 44 ( 1 ): 623 - 632 .

Andreasen J , Kærn M , Pierobon L , et al . Multi-objective optimization of organic Rankine cycle power plants using pure and mixed working fluids [J ] . Energies , 2016 , 9 ( 5 ): 322 .

Dong B , Xu G , Luo X , et al . Potential of low temperature organic Rankine cycle with zeotropic mixtures as working fluid [J ] . Energy Procedia , 2017 , 105 : 1489 - 1494 .

Liu Q , Duan Y , Yang Z . Effect of condensation temperature glide on the performance of organic Rankine cycles with zeotropic mixture working fluids [J ] . Applied Energy , 2014 , 115 : 394 - 404 .

Pang K C , Chen S C , Hung T C , et al . Experimental study on organic Rankine cycle utilizing R245fa, R123 and their mixtures to investigate the maximum power generation from low-grade heat [J ] . Energy , 2017 ， 133 ： 636 - 651 .

Modi A , Haglind F . A review of recent research on the use of zeotropic mixtures in power generation systems [J ] . Energy Conversion & Management , 2017 , 138 : 603 - 626 .

Collings P , Yu Z , Wang E . A dynamic organic Rankine cycle using a zeotropic mixture as the working fluid with composition tuning to match changing ambient conditions [J ] . Applied Energy , 2016 , 171 : 581 - 591 .

倪渊 , 赵良举 , 刘朝 , 等 . 非共沸混合工质ORC低温烟气余热利用分析与优化 [J ] . 化工学报 , 2013 , 64 ( 11 ): 3985 - 3992 .

Ni Y , Zhao L J , Liu C , et al . Recovery of waste heat of low-temperature flue gas by parametric optimization on organic Rankine cycle with non-azeotropic mixtures [J ] . CIESC Journal , 2013 , 64 ( 11 ): 3985 - 3992 .

Yue C , Han D , Pu W , et al . Thermal matching performance of a geothermal ORC system using zeotropic working fluids [J ] . Renewable Energy , 2015 , 80 : 746 - 754 .

周颖艳 , 杜小泽 , 杨立军 , 等 . 吸收烟气余热的非共沸混合工质蒸发换热特性 [J ] . 中国电机工程学报 , 2013 , 33 ( 8 ): 9 - 15 .

Zhou Y Y , Duo X Z , Yang L J , et al . Heat transfer characteristics of zeotropic mixtures in an ORC evaporator heated by exhaust gas [J ] . Proceeding of the CSEE , 2013 , 33 ( 8 ): 9 - 15 .

Andreasen J G , Larsen U , Knudsen T , et al . Selection and optimization of pure and mixed working fluids for low grade heat utilization using organic Rankine cycles [J ] . Energy , 2014 , 73 ( 9 ): 204 - 213 .

张军辉 , 刘娟芳 , 陈清华 . 有机朗肯循环系统最佳蒸发温度和㶲分析 [J ] . 化工学报 , 2013 , 64 ( 3 ): 820 - 826 .

Zhang J H , Liu J F , Chen Q H . Optimal evaporating temperature and exergy analysis for organic Rankine cycle [J ] . CIESC Journal , 2013 , 64 ( 3 ): 820 - 826 .

Bao J , Zhao L . A review of working fluid and expander selections for organic Rankine cycle [J ] . Renewable & Sustainable Energy Reviews , 2013 , 24 ( 10 ): 325 - 342 .

Li T , Zhang Z , Lu J , et al . Two-stage evaporation strategy to improve system performance for organic Rankine cycle [J ] . Applied Energy , 2015 , 150 : 323 - 334 .

于超 , 徐进良 , 王华荣 . 工质比热匹配对有机朗肯循环不可逆损失的影响 [J ] . 华北电力大学学报(自然科学版) , 2016 , 43 ( 3 ): 69 - 75 .

Yu C , Xu J L , Wang H R . Influence of heat capacity match between heat transfer fluids on irreversibility of organic Rankine cycle [J ] . Journal of North China Electric Power University , 2016 , 43 ( 3 ): 69 - 75 .

张红光 , 贝晨 , 杨富斌 , 等 . ORC系统蒸发器性能分析及其对柴油机性能影响 [J ] . 太阳能学报 , 2016 , 2 : 462 - 468 .

Zhang H G , Bei C , Yang F B , et al . Performance analysis of ORC evaporator and its effect on diesel engine performance [J ] . Acta Energiae Solaris Sinica , 2016 , 2 : 462 - 468 .

Bei C , Zhang H , Yang F , et al . Performance analysis of an evaporator for a diesel engine–organic Rankine cycle(ORC) combined system and influence of pressure drop on the diesel engine operating characteristics [J ] . Energies , 2015 , 8 ( 6 ): 5488 - 5515 .

Yu H S , Feng X , Wang Y F . A new pinch based method for simultaneous selection of working fluid and operating conditions in an ORC (organic Rankine cycle) recovering waste heat [J ] . Energy , 2015 , ( 90 ): 36 - 46 .

王辉涛 , 王华 , 葛众 , 等 . 变温热源驱动非共沸混合工质ORC换热器温度匹配性能评价方法 [J ] . 昆明理工大学学报(自然科学版) , 2014 , 39 ( 1 ): 58 - 62 .

Wang H T , Wang H , Ge Z , et al . A method to evaluate temperature matching performance of heat exchanger in variable-temperature heat source driving ORC with zeotropic refrigerant mixtures [J ] . Journal of Kunming University of Science & Technology , 2014 , 39 ( 1 ): 58 - 62 .

严晋跃，路岭，马一太 , 等 . 循环工质与变温热源匹配的热力学分析 [J ] . 工程热物理学报 , 1987 , 8 ( 4 ): 314 - 1296 .

Yan J Y , Lu L , Ma Y T , et al . The thermodynamic analysis of the matching between working fluids and variable temperature heat sources in a cycle [J ] . Journal of Engineering Thermophysics , 1987 , 8 ( 4 ): 314 - 316 .

过增元 , 梁新刚 , 朱宏晔 . ( https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=113947700&type= https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=113947677&type= https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=113947676&type= 2.75166678 2.66699982 )——描述物体传递热量能力的物理量 [J ] . 自然科学进展 , 2006 , 16 ( 10 ): 1288 - 1296 .

Guo Z Y , Liang X G , Zhu H Y . Entransy—a physical quantity to describe the ability to transmit heat [J ] . Progress in Natural Science , 2006 , 16 ( 10 ): 1288 - 1296 .

Chen Q , Liang X G , Guo Z Y . Entransy theory for the optimization of heat transfer – a review and update [J ] . International Journal of Heat & Mass Transfer , 2013 , 63 ( 15 ): 65 - 81 .

Bejan A . Second law analysis in heat transfer [J ] . Energy , 1980 , 5 ( 8 ): 720 - 732 .

柳雄斌 , 过增元 . 换热器性能分析新方法 [J ] . 物理学报 , 2009 , 58 ( 7 ): 4766 - 4771 .

Liu X B , Guo Z Y . A new method for performance analysis of heat exchangers . [J ] . Acta Physica Sinica , 2009 , 58 ( 7 ): 4766 - 4771 .

Liu Q , Shen A , Duan Y . Parametric optimization and performance analyses of geothermal organic Rankine cycles using R600a/R601a mixtures as working fluids [J ] . Applied Energy , 2015 , 148 : 410 - 420 .

徐燕燕 , 叶爽 , 黄伟光 . 基于当量热阻的ORC工质选择方法研究 [J ] . 工程热物理学报 , 2018 , ( 1 ): 23 - 30 .

Xu Y Y , Ye S , Huang W G . A method of selecting working fluid and operating conditions at once in an ORC (organic Rankine cycle) [J ] . Journal of Engineering Thermophysics , 2018 , ( 1 ): 23 - 30 .

王羽平 , 丁小益 , 翁一武 . 用于ORC发电系统的混合工质R601a/R600的实验研究 [J ] . 中国电机工程学报 , 2016 , 36 ( 12 ): 3184 - 3191 .

Wang Y P , Ding X Y , Weng Y W . Experimental study of mixture R601a/R600a used in ORC power generation system [J ] . Proceeding of the CSEE , 2016 , 36 ( 12 ): 3184 - 3191 .

中华人民共和国国家质量监督检验检疫总局 , 中国国家标准化管理委员会 . 制冷剂编号方法和安全性分类：GB/T 7778-2008 [S ] . 北京 : 中国标准出版社 , 2008 .

General Administration of Quality Supervision , Inspection and Quarantine of the People’s Republic of China , Standardization Administration of the People’s Republic of China . Number designation and safety classification of refrigerants: GB/T 778-2008 [S ] . Beijing : Standards Press of China , 2008 .

Bell I H , Wronski J , Quoilin S , et al . Pure and pseudo-pure fluid thermophysical property evaluation and the open-source thermophysical property library CoolProp [J ] . Industrial & Engineering Chemistry Research , 2014 , 53 ( 6 ): 2498 - 2508 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

A multiscale approach for the thermo-mechanical coupling analysis of parallel-flow PCHE core

Simulation research on the boiling heat transfer characteristics of liquid sodium under microgravity

Improvement and numerical validation of quasi-steady-state frosting model based on thermal and mass transfer effect

Characteristics of non-uniform wind velocity distribution in window air conditioner axial fans and their impact on optimizing condenser circuit optimization

Numerical simulation for flow condensation of methanol in horizontal tube

Related Author

WANG Hao

CAI Lujun

BAI Fan

ZHANG Feng

ZENG Yufeng

HE Yurong

WANG Tianyu

WU Linkai

Related Institution

School of Science, Wuhan University of Science and Technology

Hubei Province Key Laboratory of Systems Science in Metallurgical Process

Hubei Key Laboratory for Engineering Structural Analysis and Safety Assessment

School of Mechanical Engineering, Wuhan University of Science and Technology

School of Energy Science and Engineering, Harbin Institute of Technology

⁰