Process of BOG treating in LNG receiving station with normal temperature compressor

XIONG Xiaojun; HE Ting; LIN Wensheng

doi:10.11949/j.issn.0438-1157.20181153

您当前的位置：

首页 >

文章列表页 >

Process of BOG treating in LNG receiving station with normal temperature compressor

更新时间：2025-12-10

- Process of BOG treating in LNG receiving station with normal temperature compressor
- CIESC Journal Issue S2, Pages: 425-430(2018)
- 作者机构：
  
  上海交通大学制冷与低温工程研究所,上海,200240
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20181153
  CLC： Q519
- Online First：31 December 2018，
  
  Published：31 December 2018
- 稿件说明：
移动端阅览
XIONG Xiaojun, HE Ting, LIN Wensheng. Process of BOG treating in LNG receiving station with normal temperature compressor[J]. CIESC Journal, 2018, (S2): 425-430.
DOI：

XIONG Xiaojun, HE Ting, LIN Wensheng. Process of BOG treating in LNG receiving station with normal temperature compressor[J]. CIESC Journal, 2018, (S2): 425-430. DOI： 10.11949/j.issn.0438-1157.20181153.

摘要

液化天然气（LNG）接收站运行过程中会产生一定量的蒸发气（BOG），目前常用火炬、压缩、再冷凝三种工艺来处理BOG。由于BOG温度较低，压缩工艺中普遍采用的是低温压缩机。然而低温压缩机造价十分昂贵，极大地降低了LNG接收站的经济效益。为此，提出了一种利用常温压缩机处理BOG的工艺。该工艺利用压缩机出口的高温BOG来加热压缩机进口处的低温BOG，一方面提高了压缩机进口温度，使得常温压缩机代替低温压缩机成为可能；另一方面，降低了压缩机出口BOG的温度，减少了BOG再冷凝所需冷量。借助HYSYS软件对低温压缩和常温压缩工艺进行了模拟分析，结果表明对于小型LNG接收站，常温压缩机工艺更有优势。

Abstract

A certain amount of boil-off gas (BOG) will be produced during the operation of LNG receiving station. At present

three processes of torch

compression and re-condensation are commonly used to process BOG. Due to the low temperature of BOG

the cryogenic compressor is widely used in the compression process. However

the cost of cryogenic compressor reduces the economic benefits of LNG receiving station. Therefore

this paper proposes a process for BOG treating using a normal temperature compressor. The process utilizes the high temperature BOG of the compressor outlet to heat the low temperature BOG at the inlet of the compressor. On the one hand

the inlet temperature of the compressor is increased

which makes it possible for the normal temperature compressor to replace the cryogenic compressor; on the other hand

the BOG temperature at the outlet of the compressor and the cooling capacity required for the BOG re-condensation is reduced. Both cryogenic temperature compression and normal temperature compression process are simulated by HYSYS software. The results show that the normal temperature compressor process is more advantageous for small LNG receiving stations.

关键词

Keywords

references

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Zn-doped PdO/ZrO2 with rich oxygen vacancies for the synthesis of diphenyl carbonate from CO2 and phenol

Research progress of ionic liquids in separation of aromatics/alkanes and olefins/alkanes

Research on the characterization of the molecular weight and its distribution of perfluoropolyether

Oxygen mass transfer performance of hollow fiber non-bubble aeration membrane based on gas/liquid-phase measurement method

Performance study of gas-liquid vortex separators under low cross-sectional gas velocity

Related Author

No data

Related Institution

No data

⁰