Evaporative cooling experiment of microchannel heat exchanger in loop heat pipe

LIU Haichao; SHAO Shuangquan; ZHANG Hainan; TIAN Changqing

doi:10.11949/j.issn.0438-1157.20181065

您当前的位置：

首页 >

文章列表页 >

Evaporative cooling experiment of microchannel heat exchanger in loop heat pipe

更新时间：2025-12-10

- Evaporative cooling experiment of microchannel heat exchanger in loop heat pipe
- CIESC Journal Issue S2, Pages: 161-166(2018)
- 作者机构：
  
  1. 中国科学院低温工程学重点实验室(理化技术研究所),北京,100190
  2. 热力过程节能技术北京市重点实验室(中国科学院理化技术研究所),北京,100190
  3. 中国科学院大学,北京,100049
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20181065
  CLC： Q051.5TU831.5
- Online First：31 December 2018，
  
  Published：31 December 2018
- 稿件说明：
移动端阅览
LIU Haichao, SHAO Shuangquan, ZHANG Hainan, et al. Evaporative cooling experiment of microchannel heat exchanger in loop heat pipe[J]. CIESC Journal, 2018, (S2): 161-166.
DOI：

LIU Haichao, SHAO Shuangquan, ZHANG Hainan, et al. Evaporative cooling experiment of microchannel heat exchanger in loop heat pipe[J]. CIESC Journal, 2018, (S2): 161-166. DOI： 10.11949/j.issn.0438-1157.20181065.

摘要

采用微通道换热器作为数据中心回路热管冷却换热器，在微通道冷凝器侧进行了蒸发冷却实验。实验利用焓差平台测量了不同因素对采用蒸发冷却技术的微通道冷凝器换热影响，并分析了室内外不同温差、室外不同湿度条件下采用蒸发冷却的微通道冷凝器及蒸发器的进出口空气温差。实验结果表明：采用蒸发冷却可使冷凝器入口空气温度实现大幅温降，并增加冷凝器及蒸发器的进出口空气温度差值，喷淋后可使流经热管空气降温0.3～1.9℃，增大2%～20%的系统换热量，冷凝器换热效率得以提升，并可扩大回路热管换热器使用地区，延长回路热管年利用时间。

Abstract

The microchannel heat exchanger is applied as the heat exchanger of the loop heat pipes in data center

and the evaporative cooling experiment is carried out on the side of the microchannel condenser. The influence of evaporative cooling on the microchannel condenser is measured by using the enthalpy difference chamber in the experiment

and the temperature difference between the inlet and outlet air of the microchannel condenser and evaporator with different indoor and outdoor temperature and humidity was analyzed. The experimental results show that evaporative cooling can make the condenser inlet air temperature achieve a large temperature drop and increase the temperature drop of the inlet and outlet air

while the spraying can cool the air through the heat pipe about 0.3-1.9℃ and increase about 0.1-0.6 kW heat transfer of the system. Moreover

the evaporative cooling capacity of microchannel condenser and evaporator increases with the increase of indoor and outdoor temperature difference

and decreases with the increase of outdoor relative humidity. Compared with single heat pipe air conditioning

loop heat pipe with evaporative cooling in data center can make better use of natural cooling energy

prolong the utilization time of air conditioning system in a year

and expand the application area of the system.

关键词

Keywords

references

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Thermodynamic performance of tower-type solar-assisted supercritical compression CO2 energy storage system

Thermo-gas-elastic coupling performance analysis of high-speed and high-temperature foil face seals

Study on flash evaporation characteristics as well as thermodynamic variation performance in liquid hydrogen tank during on-orbit venting

Research on the characterization of the molecular weight and its distribution of perfluoropolyether

New universal corresponding state equation for correlation and extrapolation of saturated vapor-liquid density

Related Author

No data

Related Institution

No data

⁰