Performances of waste paper cellulose/SiO<sub>2</sub> composite aerogel

Yuhan ZHOU; Xiaoyu CHEN; Cheng ZUO; Qingjie GUO; Jun ZHAO

doi:10.11949/j.issn.0438-1157.20180916

您当前的位置：

首页 >

文章列表页 >

Performances of waste paper cellulose/SiO₂ composite aerogel

Energy and environmental engineering | 更新时间：2026-07-24

- Performances of waste paper cellulose/SiO₂ composite aerogel
- CIESC Journal Vol. 70, Issue 3, Pages: 1120-1126(2019)
- 作者机构：
  
  1.青岛科技大学化工学院清洁化工过程山东省高校重点实验室，山东青岛 266042
  2.宁夏大学省部共建煤炭高效利用与绿色化工国家重点实验室，宁夏银川 750021
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20180916
  CLC： TQ 35
- Received：13 August 2018，
  
  Revised：2018-11-30，
  
  Online First：24 July 2026，
  
  Published：05 March 2019
- 稿件说明：
移动端阅览
周钰寒, 陈晓玉, 左成, 郭庆杰, 赵军. 废纸纤维素/SiO₂复合气凝胶的性能[J]. 化工学报, 2019, 70(3): 1120-1126 DOI: 10.11949/j.issn.0438-1157.20180916.

ZHOU Yuhan, CHEN Xiaoyu, ZUO Cheng, GUO Qingjie, ZHAO Jun. Performances of waste paper cellulose/SiO₂ composite aerogel[J]. CIESC Journal, 2019, 70(3): 1120-1126 DOI: 10.11949/j.issn.0438-1157.20180916.
周钰寒, 陈晓玉, 左成, 郭庆杰, 赵军. 废纸纤维素/SiO₂复合气凝胶的性能[J]. 化工学报, 2019, 70(3): 1120-1126 DOI: 10.11949/j.issn.0438-1157.20180916. DOI：

ZHOU Yuhan, CHEN Xiaoyu, ZUO Cheng, GUO Qingjie, ZHAO Jun. Performances of waste paper cellulose/SiO₂ composite aerogel[J]. CIESC Journal, 2019, 70(3): 1120-1126 DOI: 10.11949/j.issn.0438-1157.20180916. DOI：

摘要

对废纸纤维素进行处理，以甲基三甲氧基硅烷（MTMS）作为硅源，制备纤维素/SiO

复合水凝胶，经过冷冻干燥得到性能良好的纤维素/SiO

复合气凝胶。利用扫描电镜（SEM）、接触角测量仪及热重分析（TGA）等对制得的气凝胶进行了表征测试。结果显示材料由大孔、介孔、微孔组成，最低密度为0.107 g/cm

，具有较好的疏水性能，静态疏水接触角可达148.5°，力学性能良好，可实现50%范围内压缩后100%恢复，材料具备良好的吸附性能，吸附油污可达到本身质量的12.7倍，热稳定性提高。在处理有机废水，尤其是水体油污方面有着广阔的应用前景。

Abstract

The waste paper cellulose was treated

and the cellulose/SiO

composite hydrogel was prepared by using methyltrimethoxysilane (MTMS) as a silicon source

and freeze-dried to obtain a cellulose/SiO

composite aerogel having good performance. The prepared aerogels were characterized by scanning electron microscopy (SEM)

contact angle measuring instrument and thermogravimetric analysis (TGA). The

results show that the material consists of macropores

mesopores

and micropores with a minimum density of 0.107 g/cm

which has good hydrophobic properties

static hydrophobic contact angle of up to 148.5°

good mechanical properties

and 100% recovery after compression in 50% range. The material has good adsorption performance

and the adsorbed oil can reach 12.7 times of its own quality

and the thermal stability is improved. It has broad application prospects in the treatment of organic wastewater

especially water pollution.

关键词

Keywords

references

Dalton T , Jin D . Extent and frequency of vessel oil spills in US marine protected areas [J ] . Marine Pollution Bulletin , 2010 , 60 ( 11 ): 1939 .

Bi H C , Xie X , Yin K B , et al . Spongy graphene as a highly efficient and recyclable sorbent for oils and organic solvents [J ] . Advanced Function Material , 2012 , 22 ( 21 ): 4421 - 4425 .

Annunciado T R , Sydenstricker T H , Amico S C . Experimental investigation of various vegetable fibers as sorbent materials for oil spills [J ] . Marine Pollution Bulletin , 2005 , 50 ( 11 ): 1340 - 1346 .

Bayat A , Aghamiri S F , Moheb A , et al . Oil spill cleanup from sea water by sorbent materials [J ] . Chemical Engineering Technology , 2005 , 28 ( 12 ): 1525 - 1528 .

Zhu Q , Pan Q , Liu F . Facile removal and collection of oils from water surfaces through superhydrophobic and superoleophilic sponges [J ] . Journal of Physical Chemistry C , 2011 , 115 ( 35 ): 17464-17470 .

Lermontov S A . Methyltrimethoxysilane-based elastic aerogels: effects of the supercritical medium on structure-sensitive properties [J ] . Russian Journal of Inorganic Chemistry , 2015 , 60 ( 4 ): 488 - 492 .

Fidalgo A , Farinha J P S , Martinho J M G , et al . Flexible hybrid aerogels prepared under subcritical conditions [J ] . Journal of Material Chemistry A , 2013 , 1 ( 39 ): 12044-12052 .

Yu Y , Wu X , Guo D , et al . Preparation of flexible, hydrophobic, and oleophilic silica aerogels based on a methyltriethoxysilane precursor [J ] . Journal of Material Science , 2014 , 49 ( 22 ): 7715 - 7722 .

Kettunen M , Silvennoinen R J , Houbenov N , et al . Photoswitchable superabsorbency based on nanocellulose aerogels [J ] . Advanced Functional Materials , 2011 , 21 ( 3 ): 510 - 517 .

Sai H Z , Xing L , Xiang J H , et al . Flexible aerogels with interpenetrating network structure of bacterial cellulose–silica composite from sodium silicate precursor via freeze drying process [J ] . Journal of Materials Chemistry A , 2013 , 1 ( 27 ): 7963 - 7970 .

马书荣 , 米勤勇 , 余坚 , 等 . 基于纤维素的气凝胶材料 [J ] . 化学进展 , 2014 , 26 ( 5 ): 796 - 809 .

Ma S R , Mi Q Y , Yu J , et al . Aerogel materials based on cellulose [J ] . Progress in Chemistry , 2014 , 26 ( 5 ): 796 - 809 .

Fei H , Sui C , Yang G , et al . Fabrication of hydrophobic silica-cellulose aerogels by using dimethyl sulfoxide(DMSO) as solvent [J ] . Materials Letters , 2014 , 137 ( 137 ): 167 - 169 .

刘昕昕 , 刘志明 . 疏水纤维素/SiO 2 复合气凝胶的制备和表征 [J ] . 生物质化学工程 , 2016 , 50 ( 2 ): 39 - 44 .

Liu X X , Liu Z M . Preparation and characterization of hydrophobic cellulose/SiO 2 composite aerogel [J ] . Biomass Chemical Engineering , 2016 , 50 ( 2 ): 39 - 44 .

Shi J J , Lu L B , Guo W T , et al . Heatinsulation performance, mechanics and hydrophobic modification of cellulose-SiO 2 composite aerogels [J ] . Carbohydrate Polymers , 2013 , 98 ( 1 ): 2118 - 2121 .

He M , Duan B , Xu D F , et al . Moisyure and solvent responsive cellulose/SiO 2 nanocomposite materials [J ] . Cellulose , 2015 , 22 ( 1 ): 553 - 563 .

Egal M , Budtova T , Navard P . The dissolution of microcrystalline cellulose in sodium hydroxide-urea aqueous solutions [J ] . Cellulose , 2008 , 15 ( 3 ): 361 .

Kobayashi Y , Saito T , Isogai A . Aerogels with 3D ordered nanofiber skeletons of liquid-crystalline nanocellulose derivatives as tough and transparent insulators [J ] . Angewandte Chemie International Edition , 2015 , 53 ( 39 ): 10253-10253 .

李慧媛 , 吴清林 , 周定国 . 纳米二氧化硅/纳米纤维素复合材料制备及性能分析 [J ] . 农业工程学报 , 2015 , 31 ( 7 ): 299 - 303 .

Li H Y , Wu Q L , Zhou D G . Preparation and performance analysis of nanosilica/cellulose composites [J ] . Transactions of the Chinese Society of Agricultural Engineering , 2015 , 31 ( 7 ): 299 - 303 .

莫尊理 , 赵仲丽 , 陈红 , 等 . 纳米SiO 2 /纤维素复合材料的非均相制备及其性能 [J ] . 复合材料学报 , 2008 , 25 ( 4 ): 24 - 28 .

Mo Z L , Zhao Z L , Chen H , et al . Heterogeneous preparation and properties of nano-SiO 2 /cellulose composites [J ] . Acta Materiae Compositae Sinica , 2008 , 25 ( 4 ): 24 - 28 .

柏正武 , 徐小琴 , 金芬芬 , 等 . 纤维素-二氧化硅复合颗粒的制备与表征 [J ] . 武汉工程大学学报 , 2013 , 35 ( 2 ): 11 - 15 .

Bo Z W , Xu X Q , Jin F F , et al . Preparation and characterization of cellulose-SiO 2 composite beads [J ] . Journal of Wuhan Institute of Technology , 2013 , 35 ( 2 ): 11 - 15 .

卿彦 , 吴义强 , 秦志永 , 等 . SiO 2 /杨木复合材料制备与性能评价 [J ] . 复合材料学报 , 2011 , 28 ( 6 ): 125 - 131 .

Qing Y , Wu Y Q , Qin Z Y , et al . Preparation and performance evaluation of SiO 2 /poplar wood composites [J ] . Acta Materiae Compositae Sinica , 2011 , 28 ( 6 ): 125 - 131 .

Nguyen B N , Meador M A , Tousley M E , et al . Tailoring elastic properties of siliea aerogels cross-linked with polystyrene [J ] . ACS Applied Materials and Interfaces , 2009 , 1 ( 3 ): 621 - 630 .

Pour G , Beauger C , Rigacci A , et al . Xerocellulose: lightweight, porous and hydrophobic cellulose prepared via ambient drying [J ] . Journal of Materials Science , 2015 , 50 ( 13 ): 4526 - 4535 .

林冲 , 张锡东 , 何边阳 . 疏水性纤维素气凝胶的制备及性能研究 [J ] . 海南大学学报(自然科学版) , 2015 , 33 ( 4 ): 353 - 358 .

Lin C , Zhang X D , He B Y . Synthesis and characterization of hydrophobic cellulose aerogel [J ] . Natural Sciences Journal of Hainan University , 2015 , 33 ( 4 ): 353 - 358 .

李飞 , 邢丽 , 向军辉 , 等 . 疏水性纤维素-SiO 2 复合气凝胶的非超临界制备 [J ] . 稀有金属材料与工程 , 2015 , 44 (S 1 ): 647 - 650 .

Li F , Xing L , Xiang J H , et al . Hydrophobic cellulose-SiO 2 composite aerogel prepared by a non-supercritical drying process [J ] . Rare Metal Materials and Engineering , 2015 , 44 (S 1 ): 647 - 650 .

He J , Zhao H Y , Li X L , et al . Superelastic and superhydrophobic bacterial cellulose/silica aerogels with hierarchical cellular structure for oil absorption and recovery [J ] . Journal of Hazardous Materials , 2018 , 346 : 199 - 207 .

Yuan J , Liu X , Akbulut O , et al . Superwetting nanowire membranes for selective absorption [J ] . Nature Nanotechnology , 2008 , 3 ( 6 ): 332 - 336 .

Hayase G , Kanamori K , Fukuchi M , et al . Facile synthesis of marshmallow-like macroporous gels usable under harsh conditions for the separation of oil and water [J ] . Angewandte Chemie , 2013 , 52 ( 7 ): 1986 - 1989 .

张颖 . 高比表面积稻壳基活性炭制备及其在废水处理中应用研究 [D ] . 长沙 : 中南大学 , 2012 .

Zhang Y . Preparation of high specific surface area rice hull based activated carbon and its application in wastewater treatment [D ] . Changsha : Central South University , 2012 .

黄辉 . 活性炭吸附法去除水中硒的研究 [D ] . 昆明 : 昆明理工大学 , 2005 .

Huang H . Studying on removal of selenium from water by activated carbon process [D ] . Kunming : Kunming University of Science and Technology , 2005 .

齐菊锐 , 李陟 , 许宏鼎 , 等 . 多孔炭的物理化学性能对其吸附性能的影响 [J ] . 吉林大学学报(理学版) , 2005 , 43 ( 1 ): 95 - 100 .

Qi J R , Li Z , Xu H D , et al . Effect of physicochemical characteristic of porous carbon on its performance of adsorption [J ] . Journal of Jilin University (Science Edition) , 2005 , 43 ( 1 ): 95 - 100 .

刘大中 , 王锦 . 物理吸附与化学吸附 [J ] . 山东轻工业学院学报(自然科学版) , 1999 , ( 2 ): 22 - 25 .

Liu D Z , Wang J . Physisorption and chemisorption [J ] . Journal of Shandong Polytechnic University , 1999 , ( 2 ): 22 - 25 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Preparation of ZTIF based hydrophobic micro-mesoporous carbon and their adsorption and separation performance of 5-hydroxymethylfurfural

Study on adsorption and catalytic oxidation characteristics of toluene on Co3O4 modified USY molecular sieve

Saturated adsorption capacities of graphene aerogels on organics

Preparation and adsorption properties of spherical poly(tannin)-cellulose resin

Optimization of heat storage and release cycle performance of Ca(OH)2/CaO indirect reactor

Related Author

LYU Tiantian

YUAN Min

WANG Jiang

GAO Meizhen

YANG Jiahui

XU Hong

DONG Jinxiang

SHI Qi

Related Institution

College of Chemical Engineering and Technology, Shanxi Key Laboratory of Chemical Product Engineering, Taiyuan University of Technology

National Engineering Laboratory for Reducing Emissions from Coal Combustion, Engineering Research Center of Environmental Thermal Technology of Ministry of Education, Shandong Key Laboratory of Energy Carbon Reduction and Resource Utilization, School of Energy and Power Engineering, Shandong University

State Key Laboratory of Heavy Oil Processing, China University of Petroleum

College of Chemistry and Chemical Engineering, Jishou University, Jishou

Key Laboratory of Advanced Control for Light Industry Process of the Ministry of Education , Jiangnan University

⁰

Performances of waste paper cellulose/SiO2 composite aerogel

DOI：10.11949/j.issn.0438-1157.20180916

摘要

Abstract

关键词

Keywords

references

Performances of waste paper cellulose/SiO₂ composite aerogel