Experimental study of a novel solution regeneration system for heat-source tower under unsteady state

Xiantai WEN; Jiao YU; Xianqi CAO; Pengfei YU; Ning CAI; Yifan MAO

doi:10.11949/j.issn.0438-1157.20180419

您当前的位置：

首页 >

文章列表页 >

Experimental study of a novel solution regeneration system for heat-source tower under unsteady state

Fluid dynamics and transport phenomena | 更新时间：2020-06-24

- Experimental study of a novel solution regeneration system for heat-source tower under unsteady state
- CIESC Journal Vol. 70, Issue 1, Pages: 83-90(2019)
- 作者机构：
  
  1.南京工程学院能源与动力工程学院，江苏南京 211167
  2.东南大学能源与环境学院，江苏南京 210096
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20180419
  CLC： TK 123
- Received：23 April 2018，
  
  Revised：2018-10-18，
  
  Published：05 January 2019
- 稿件说明：
移动端阅览
文先太, 于娇, 曹先齐, 余鹏飞, 蔡宁, 茅逸凡. 新型热源塔溶液再生系统非稳态特性分析与实验研究[J]. 化工学报, 2019, 70(1): 83-90

WEN Xiantai, YU Jiao, CAO Xianqi, YU Pengfei, CAI Ning, MAO Yifan. Experimental study of a novel solution regeneration system for heat-source tower under unsteady state[J]. CIESC Journal, 2019, 70(1): 83-90
文先太, 于娇, 曹先齐, 余鹏飞, 蔡宁, 茅逸凡. 新型热源塔溶液再生系统非稳态特性分析与实验研究[J]. 化工学报, 2019, 70(1): 83-90 DOI： 10.11949/j.issn.0438-1157.20180419.

WEN Xiantai, YU Jiao, CAO Xianqi, YU Pengfei, CAI Ning, MAO Yifan. Experimental study of a novel solution regeneration system for heat-source tower under unsteady state[J]. CIESC Journal, 2019, 70(1): 83-90 DOI： 10.11949/j.issn.0438-1157.20180419.

摘要

针对热源塔冬季运行时存在的吸湿问题，构建了一种新型热源塔溶液再生系统并对其进行实验测试。考虑到系统在初始运行时需要建立平衡的温度场且系统运行时存在溶液不断变浓的现象，对该溶液再生系统启动时的非稳态特性进行了研究，获取了各运行参数随初始运行次数的变化规律，同时对不同浓度下各运行参数变化规律进行了实验分析。实验结果表明：初始开机运行后，随着运行次数的增多，在总运行水量保持不变的情况下，单次运行所需电量呈下降趋势，冷凝水量呈上升趋势，最终系统趋于稳定。随着溶液浓度的变化，系统再生效率存在先增加后降低的趋势，当溶液浓度达到18.5%时出现最佳值，此时再生效率为4.28 kg/(kW·h)，再生速率为749 kg/d，再生百分比为14%。该装置将溶液的真空沸腾过程和冷凝过程融合在一起，系统能耗大大降低，具有较好的节能效果。

Abstract

Based on the problem of moisture absorption in winter for heat source tower

a novel solution regeneration system is proposed in this paper. The corresponding test bench is constructed to carry out the relevant experimental tests. Considering with the balanced temperature field in the initial operation and the phenomenon of solution thicken with the water seperation from solutionin

the unsteady characteristics of the solution regeneration system during start-up are studied

and the variation of the operation parameters with the initial running times is obtained. Simultaneously the regularity of operation parameters with different concentration is studied. The results show that: with the increase of initial operation times

under the condition that the total running water quantity remains unchanged

the energy consumption for a single operation decreases

the condensate water rate increases

and finally the system tends to be stable. With the increase of solution concentration

the regeneration efficiency increases first and then reduces. When the solution concentration is 18.5%

the regeneration efficiency reaches the maximum. Simultaneously the regeneration efficiency is 4.28 kg/(kW·h)

and the regeneration rate is 749 kg/d. The regeneration percentage is 14%. In the system

low pressure boiling process of the solution is combined with the condensation process

and the energy efficiency is great.

关键词

Keywords

references

Huang S F , Lv Z Y , Liang C H , et al . Experimental study of heat and mass transfer characteristics in a cross-flow heating tower [J]. International Journal of Refrigeration , 2017 , 77 : 116 - 127 .

Huang S F , Lv Z Y , Liang C H , et al . Experimental investigation on heat and mass transfer in heating tower solution regeneration using packing tower [J]. Energy and Buildings , 2018 , 164 : 77 – 86 .

梁彩华 , 文先太 , 张小松 . 基于热源塔的热泵系统构建与实验 [J]. 化工学报 , 2010 , 61 ( S2 ): 142 - 146 .

Liang C H , Wen X T , Zhang X S . Construction and experimental research on heat pump system based on heat-source tower [J]. CIESC Journal , 2010 , 61 ( S2 ): 142 - 146 .

李念平 , 张鼎 , 成剑林 , 等 . 热源塔热泵空调系统经济性分析 [J]. 深圳大学学报(理工版) , 2015 , 32 ( 4 ): 404 - 410 .

Li N P , Zhang D , Cheng J L , et al . Economic analysis of heat pump air conditioning system of heat-source tower [J]. Journal of Shenzhen University (Science and Engineering) , 2015 , 32 ( 4 ): 404 - 410 .

Wu J S , Zhang G Q , Zhang Q , et al . Artificial neural network analysis of the performance characteristics of a reversibly used cooling tower under cross flow conditions for heat pump heating system in winter [J]. Energy and Building , 2011 , 43 : 1685 - 1693 .

Lu J , Li W Y , Zeng L Y , et al . Numerical study on heat and mass transfer characteristics of the counter-flow heat-source tower (CFHST) [J]. Energy and Buildings , 2017 , 145 : 318 - 330 .

Liang C H , Wen X T , Liu C X . Performance analysis and experimental study of heat-source tower solution regeneration [J]. Energy Conversion and Management , 2014 , 85 : 596 - 602 .

文先太 , 梁彩华 , 刘成兴 , 等 . 基于空气能量回收的热源塔溶液再生系统节能性分析 [J]. 化工学报 , 2011 , 62 ( 11 ): 3242 - 3247 .

Wen X T , Liang C H , Liu C X , et al . Energy-saving analysis of solution regeneration in heat-source tower based on recovery of air energy [J]. CIESC Journal , 2011 , 62 ( 11 ): 3242 - 3247 .

Wen X T , Liang C H , Zhang X S . Experimental study on heat transfer coefficient between air and liquid in the cross-flow heat-source tower [J]. Building and Environment , 2012 , 57 : 205 - 213 .

文先太 , 梁彩华 , 张小松 , 等 . 热源塔传质特性的分析与实验研究 [J]. 化工学报 , 2011 , 62 ( 4 ): 901 - 907 .

Wen X T , Liang C H , Zhang X S , et al . Mass transfer characteristics in heat-source tower [J]. CIESC Journal , 2011 , 62 ( 4 ): 901 - 907 .

文先太 , 梁彩华 , 刘成兴 , 等 . 叉流热源塔传热传质模型的建立及实验验证 [J]. 化工学报 , 2012 , 63 ( 8 ): 2398 - 2404 .

Wen X T , Liang C H , Liu C X , et al . Verification of model for heat and mass transfer process in cross flow heat-source tower [J]. CIESC Journal , 2012 , 63 ( 8 ): 2398 - 2404 .

Qi R H , Lu L , Huang Y . Energy performance of solar-assisted liquid desiccant air-conditioning system for commercial building in main climate zones [J]. Energy Conversion and Management , 2014 , 88 : 749 - 757 .

彭冬根 , 罗丹婷 , 李顺意 . 内热型除湿溶液再生器溶液再生方式及装置性能分析 [J]. 农业工程学报 , 2017 , 33 ( 18 ): 165 - 172 .

Peng D G , Luo D T , Li S Y . Analysis of performance and regeneration method of internally-heated liquid desiccant regenerator [J]. Transactions of the Chinese Society of Agricultural Engineering , 2017 , 33 ( 18 ): 165 - 172 .

彭冬根 , 罗丹婷 , 程小松 . 热回收型太阳能分级溶液集热/再生系统模型及环境适用性分析 [J]. 化工学报 , 2017 , 68 ( 8 ): 3242 - 3249 .

Peng D G , Luo D T , Cheng X S . Modeling and environmental applicability of solar solution grading collector/regenerator system with heat recovery [J]. CIESC Journal , 2017 , 68 ( 8 ): 3242 - 3249 .

Peng D G , Zhang X S . A modified model of solar collector/regenerator considering effect of the glazing temperature [J]. International Journal of Refrigeration , 2015 , 49 : 151 - 159 .

Khoudor K , Kameli G , Nesreen G . Study of solar regenerated membrane desiccant system to control humidity and decrease energy consumption in office spaces [J]. Applied Energy , 2015 , 138 : 121 - 132 .

殷勇高 , 潘雄伟 , 陈瑶 , 等．热空气用于溶液再生实验研究与能效分析 [J]. 工程热物理学报 , 2013 , 34 ( 4 ): 596 - 600 ．

Yin Y G , Pan X W , Chen Y , et al . Experimental study and energy efficiency analysis of liquid desiccant regeneration using hot air [J]. Journal of Engineering Thermophysics , 2013 , 34 ( 4 ): 596 - 600 .

Liu X H , Jiang Y , Yi X Q . Effect of regeneration mode on the performance of liquid desiccant packed bed regenerator [J]. Renewable Energy , 2009 , 34 : 209 - 216 .

Mehta J R , Rane M V . Liquid desiccant based solar air conditioning system with novel evacuated tube collector as regenerator [J]. Procedia Engineering , 2013 , 51 : 688 - 693 .

Rajat S D , Sanjeev J . Experimental investigations on a solar assisted liquid desiccant cooling system with indirect contact dehumidifier [J]. Solar Energy , 2017 , 153 : 289 - 300 .

Li X W , Zhang X S . Photovoltaic–electrodialysis regeneration method for liquid desiccant cooling system [J]. Solar Energy , 2009 , 83 : 2195 - 2204 .

Li X W , Zhang X S , Shuo Q . Single-stage and double-stage photovoltaic driven regeneration for liquid desiccant cooling system [J]. Applied Energy , 2011 , 88 : 4908 - 4917 .

Cheng Q , Xu W H . Performance analysis of a novel multi-function liquid desiccant regeneration system for liquid desiccant air-conditioning system [J]. Energy , 2017 , 140 : 240 - 252 .

Cheng Q , Zhang X S , Jiao S . Experimental comparative research on electrodialysis regeneration for liquid desiccant with different concentrations in liquid desiccant air-conditioning system [J]. Energy and Buildings , 2017 , 155 : 475 - 483 .

Cheng Q , Zhang X S , Li X W . Performance analysis of a new desiccant pre-treatment electrodialysis regeneration system for liquid desiccant [J]. Energy and Buildings , 2013 , 66 : 1 - 15 .

Cheng Q , Xu Y , Zhang X S . Experimental investigation of an electrodialysis regenerator for liquid desiccant [J]. Energy and Buildings , 2013 , 67 : 419 - 425 .

Alexander S R , Ananda K N , Srinivas G , et al . Modeling of a flat plate membrane-distillation system for liquid desiccant regeneration in air conditioning applications [J]. International Journal of Heat and Mass Transfer , 2011 , 54 : 3650 – 3660 .

Sciadone O , Albanese A , Angelo A , et al . Investigation of electrode material-redox couple systems for reverse electrodialysis processes (Ⅱ): Experiments in a stack with 10—50 cell pairs [J]. Journal of Electroanalytical Chemistry , 2013 , 704 : 1 - 9 .

Farrell E , Hassan M I , Tufa R A . Reverse electrodialysis powered greenhouse concept for water and energy-self-sufficient agriculture [J]. Applied Energy , 2017 , 187 : 390 - 409 .

Khoudor K , Kamel G , Nesreen G . Study of solar regenerated membrane desiccant system to control humidity and decrease energy consumption in office spaces [J]. Applied Energy , 2015 , 138 : 121 - 132 .

Keith A , Brian D , Troy F , et al . Failure analysis of an MVR (mechanical vapor recompressor) impeller [J]. Engineering Failure Analysis , 2010 , 17 : 1345 - 1358 .

邓赛峰 , 邹同华 , 张涛 , 等 . 真空条件下除湿溶液再生的模拟与实验研究 [J]. 真空科学与技术学报 , 2015 , 35 ( 5 ): 544 - 549 .

Deng S F , Zou T H , Zhang T , et al . Numerical simulation and experimental evaluation of desiccant-solution recycling in vacuum [J]. Chinese Journal of Vacuum Science and Technology , 2015 , 35 ( 5 ): 544 - 549 .

张涛 . 真空条件下溶液再生机理研究 [D]. 天津 : 天津商业大学 , 2013 .

Zhang T . Study on the regeneration mechanism of liquid under vacuum condition [D]. Tianjin : Tianjin University of Commerce , 2013 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Energy-saving analysis and experimental study of a new heat-source tower solution regeneration system

Research progress on frost-free air source heat pump technology

Oxygen mass transfer performance of hollow fiber non-bubble aeration membrane based on gas/liquid-phase measurement method

Performance analysis and application of thermal and humidity control system cascade driven by waste heat

Methods of adaptive prediction and abnormal states traceability for sulphur content in flue gas desulfurization process

Related Author

WEN Xiantai

CAO Xianqi

YU Pengfei

YU Jiao

Yi ZHANG

Guanmin ZHANG

Xueli LENG

Xiaohang QU

Related Institution

School of Energy and Power Engineering, Shandong University

Department of Energy and Power Engineering, Shandong University of Technology

⁰