Effects of temperature gradient and product flow on distribution of pyrolysis products of Xianfeng lignite

ZHOU Guojiang; LIU Zhutao; ZHAN Jinhui; LAI Dengguo; LIU Xiaoxing

doi:10.11949/j.issn.0438-1157.20171345

您当前的位置：

首页 >

文章列表页 >

Effects of temperature gradient and product flow on distribution of pyrolysis products of Xianfeng lignite

更新时间：2025-12-10

- Effects of temperature gradient and product flow on distribution of pyrolysis products of Xianfeng lignite
- CIESC Journal Issue 6, Pages: 2672-2680(2018)
- 作者机构：
  
  1. 黑龙江科技大学环境与化工学院,黑龙江,哈尔滨,150022
  2. 中国科学院过程工程研究所多相复杂系统国家重点实验室,北京,100190
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20171345
  CLC： Q530.2
- Online First：05 June 2018，
  
  Published：05 June 2018
- 稿件说明：
移动端阅览
ZHOU Guojiang, LIU Zhutao, ZHAN Jinhui, et al. Effects of temperature gradient and product flow on distribution of pyrolysis products of Xianfeng lignite[J]. CIESC Journal, 2018, (6): 2672-2680.
DOI：

ZHOU Guojiang, LIU Zhutao, ZHAN Jinhui, et al. Effects of temperature gradient and product flow on distribution of pyrolysis products of Xianfeng lignite[J]. CIESC Journal, 2018, (6): 2672-2680. DOI： 10.11949/j.issn.0438-1157.20171345.

摘要

通过两段固定床反应器分离了煤热解和二次反应过程，模拟了传统外热式固定床反应器和外热式内构件固定床反应器内挥发性热解产物流动与固相反应颗粒间的相互作用，研究了不同温度的半焦对先锋褐煤热解产物分布和品质的影响。结果表明：当半焦的温度在500～900℃时，焦油发生剧烈的二次反应，热解气收率增加，焦油收率大幅下降，H/C同时大量降低且均低于空白样，油品质下降；在100～400℃半焦作用下，焦油发生轻微的二次反应，热解气收率略微增加，焦油收率缓慢下降，但H/C均高于空白样，油品质提升。该结果验证内构件外热式固定床反应器热解产生的焦油具有更高的收率及品质。

Abstract

The processes of coal pyrolysis and secondary reactions were separated by using two-stage fixed bed reactor to simulate the product flow and the interactions among reaction particles for coal pyrolysis in the traditional indirect heating reactor and indirect heating reactor with internals

and to investigate the effects of different temperature char on the distribution and quality of pyrolysis products of Xianfeng lignite. The results showed that the drastic secondary reactions occurred when tar flowed through the 500-900℃ char layer

the yield of pyrolysis gas increased

the tar yield and atomic H/C ratio were lower than those of blank control experiment

and the quality of oil decreased. Under the action of 100-400℃ char layer

the slight secondary reaction of the tar occurred

the yield of pyrolysis gas increased slightly

the tar yield had a little decrease

the atomic H/C ratio was higher than that of blank control

and the oil quality increased. The results verified the conclusion that the tar with indirect heating reactor with internals produced higher yield and better quality.

关键词

Keywords

references

Views

118

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Catalytic cracking of coal pyrolysis product for oil and gas upgrading over char-based catalysts

Revealing reaction compromise in competition for volatile radicals during coal pryolysis via ReaxFF MD simulation

Interaction between functional groups during slow pyrolysis of Naomaohu coal

Nitrification characteristics and application research of high-efficiency embedded filler

Effect of temperature and pressure on formation process of single-hole bubbles

Related Author

WANG Xingdong

HAN Jiangze

LU Jiangyin

GAO Shiqiu

XU Guangwen

Mo ZHENG

Xiaoxia LI

Yingjie YANG

Related Institution

Key Laboratory of Oil and Gas Fine Chemicals of Ministry of Education, Xinjiang University

State Key Laboratory of Multiphase Complex Systems, Institute of Process Engineering, Chinese Academy of Sciences

School of Chemical Engineering, University of Chinese Academy of Sciences

Innovation Academy for Green Manufacture, Chinese Academy of Sciences

Institute of Coal Chemical Engineering, School of Chemical Engineering, Dalian University of Technology

⁰