Design of multi-period heat exchanger networks for overdesign control

KANG Lixia; LIU Yongzhong

doi:10.11949/j.issn.0438-1157.20171132

您当前的位置：

首页 >

文章列表页 >

Design of multi-period heat exchanger networks for overdesign control

更新时间：2025-12-10

- Design of multi-period heat exchanger networks for overdesign control
- CIESC Journal Issue 3, Pages: 1022-1029(2018)
- 作者机构：
  
  西安交通大学化工系,陕西,西安,710049
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20171132
  CLC： Q021.8
- Online First：05 March 2018，
  
  Published：05 March 2018
- 稿件说明：
移动端阅览
KANG Lixia, LIU Yongzhong. Design of multi-period heat exchanger networks for overdesign control[J]. CIESC Journal, 2018, (3): 1022-1029.
DOI：

KANG Lixia, LIU Yongzhong. Design of multi-period heat exchanger networks for overdesign control[J]. CIESC Journal, 2018, (3): 1022-1029. DOI： 10.11949/j.issn.0438-1157.20171132.

摘要

实际多周期换热网络的设计不但要满足多个离散周期的操作条件要求，还应该满足单个周期下的柔性要求，以补偿实际操作中单周期下可能出现的参数波动。而根据工程经验增加换热面积裕量和采用文献中的最大面积思想进行设计，都会造成多周期换热网络中换热面积的过度冗余，导致资源的浪费和投资成本的增加。针对以上问题，在综合考虑多周期操作条件要求和单周期柔性要求的基础上，提出了一种控制面积冗余的多周期换热网络设计方法。该方法首先在单周期换热网络集成的基础上获取一个初始的多周期换热网络设计方案。然后以此方案为基础，构建一个基于单周期换热网络模型和柔性分析模型的换热网络修正模型，并通过求解该模型获得初始多周期换热网络在各周期下的最优修正方案。通过综合初始多周期换热网络设计和修正方案，即可完成最终的多周期换热网络设计。最后，通过将所得多周期换热网络与文献中所得结果进行对比，验证了方法的有效性。

Abstract

A practical multi-period heat exchanger network (HEN) design is required to satisfy not only the operating requirements in several discrete sub-periods

but also the flexibility requirements in all sub-periods that help to compensate the potential fluctuations of the parameters in each sub-period. However

the problem of overdesign arise in most cases where the heat transfer areas are determined by increasing the margin or using the maximum area concept during the multi-period HEN design. These factors will lead to a waste of resource and capital. To address these problems

a method of multi-period HEN design considering overdesign control is proposed by taking both the requirements of multi-period operation and single period flexibility into account. In the proposed method

an initial multi-period HEN is first obtained by the single period HEN optimization. A HEN modification model

on the basis of stage-wise superstructure model and flexibility index model

is then developed and solved to determine the optimal modifications of the initial multi-period HEN in each sub-period. The final multi-period HEN is thus finished by combing the initial multi-period HEN and the corresponding modifications. The application and effectiveness of the proposed method are finally verified through a comparison of the results in this work and those in literature.

关键词

Keywords

references

Views

122

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Integrating optimization of hydrogenation units in multi-period hydrogen network

Energy system integration and catalyst regeneration cycle optimization of benzene hydrogenation to cyclohexene process

Fine search strategy applied to mass exchange network synthesis

Distillation column pressure optimization integrated with the heat exchanger network

Surrogate-assisted multi-objective optimization of hydrogen networks with light hydrocarbon recovery unit

Related Author

HUANG Zhihong

ZHOU Li

CHAI Shiyang

JI Xu

ZHAO Liwen

LIU Guilian

Ling YANG

Guomin CUI

Related Institution

School of Chemical Engineering, Sichuan University

School of Chemical Engineering and Technology, Xi’an Jiaotong University

School of Energy and Power Engineering, University of Shanghai for Science and Technology,Shanghai Key Laboratory of Multiphase Flow and Heat Transfer in Power Engineering

School of Chemical Engineering, China University of Petroleum

School of Materials and Energy, Guangdong University of Technology

⁰