Analysis of influencing factors on inhibition of lignite pulverization by liquefaction residue during co-pyrolysis in rotary kiln

QU Yang; CHU Mo; ZHU Shuquan; ZHANG Chao; HAO Chengliang; XU Fang

doi:10.11949/j.issn.0438-1157.20171114

您当前的位置：

首页 >

文章列表页 >

Analysis of influencing factors on inhibition of lignite pulverization by liquefaction residue during co-pyrolysis in rotary kiln

更新时间：2025-12-10

- Analysis of influencing factors on inhibition of lignite pulverization by liquefaction residue during co-pyrolysis in rotary kiln
- CIESC Journal Issue 5, Pages: 2166-2174(2018)
- 作者机构：
  
  中国矿业大学(北京)化学与环境工程学院,北京,100083
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20171114
  CLC： Q536.9
- Online First：05 May 2018，
  
  Published：05 May 2018
- 稿件说明：
移动端阅览
QU Yang, CHU Mo, ZHU Shuquan, et al. Analysis of influencing factors on inhibition of lignite pulverization by liquefaction residue during co-pyrolysis in rotary kiln[J]. CIESC Journal, 2018, (5): 2166-2174.
DOI：

QU Yang, CHU Mo, ZHU Shuquan, et al. Analysis of influencing factors on inhibition of lignite pulverization by liquefaction residue during co-pyrolysis in rotary kiln[J]. CIESC Journal, 2018, (5): 2166-2174. DOI： 10.11949/j.issn.0438-1157.20171114.

摘要

在公斤级回转窑中研究了共热解过程不同液化残渣与褐煤质量配比及粒度配比因素对抑制褐煤粉化效果的影响。结果表明：550℃共热解条件下，随液化残渣的添加比例由10%升至40%，共热解半焦的粉化率β由7.55%降至1.98%，造粒率λ由2.73%升至4.90%，液化残渣添加量的提升有效促进了对粉化的抑制及混合造粒；3～1 mm液化残渣与3～1 mm褐煤的共热解半焦β为2.82%，较与6～3/13～6/25～13 mm褐煤颗粒热解后的产物粉化率均低，而λ则达到24.99%，远高于其他粒度配比下的产物造粒率。灰色关联分析显示，粒度配比因素对β和λ的影响权重均大于质量配比因素。结合分析上述配比因素影响粉化抑制作用的内在诱因（强化粘连捕集颗粒行为，促进孔隙充填补强作用，颗粒穿层行为影响），形成了回转窑热解过程配比因素对抑制褐煤粉化的影响过程模型。

Abstract

The inhibitory effects of coal direct liquefaction residue (CDLR) on lignite pulverization were studied in a kilo rotary kiln during co-pyrolysis. Different CDLR to lignite quantity and particle size ratios were investigated in the study. The results showed that

with CDLR quantity ratio increased from 10% to 40% at 550℃

the co-pyrolysis char pulverization rate β was decreased from 7.55% to 1.98%

and the granulation rate λ was increased from 2.73% to 4.90%. Increasing CDLR quantity ratio effectively inhibited lignite pulverization and mixing granulation. Mixing 3-1 mm CDLR with 3-1 mm lignite reached the pulverization rate β of 2.82%

which is lower than the pulverization rate when mixing 6-3/13-6/25-13 mm CDLR with the same size lignite. Mixing 3-1 mm CDLR with 3-1 mm lignite reached the granulation rate λ of 24.99%

which was much higher than λ of mixing larger CDLR. Gray relational analysis indicated that the influence of CDLR size ratio on β and λ was greater than quantity ratio. A model of CDLR to lignite size and quantity ratio inhibiting lignite pulverization in rotary kiln during pyrolysis was constructed. The ratio factors affected pyrolysis along with other internal factors including strength of particle capturing

pore structure reinforcing and particle layer crossing behavior.

关键词

Keywords

references

Views

100

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Thermal fragmentation and pulverization characteristic during pyrolysis of Huadian oil shale

Characteristics of oil shale particles fragmentation/pulverization during thermal effect

Heat transfer characteristics of MSW and its typical components in rotary kiln at different pyrolysis stages

Storage, transportation and incineration characteristics of carbon-based skeleton-assisted thermally hydrolyzed sludge

Advantages and risks of swirling cooling granulation towers

Related Author

SUN Nanxiang

WANG Yue

BAI Xiangfei

QU Yang

CHU Mo

ZHANG Chao

BAI Shuxia

CHANG Zhibing

Related Institution

Beijing Research Institute of Coal Chemistry, Coal Science and Technology Research Institute Company Limited

State Key Laboratory of Coal Mining and Clean Utilization

Institute of Thermal & Environmental Engineering, Tongji University

Institute of Waste Treatment & Reclamation, College of Environmental Science and Engineering, Tongji University

State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology

⁰