Instantaneous steady state of pumpless organic Rankine cycle driven by low temperature heat source

LU Huitong; JIANG Long; WANG Liwei; WANG Ruzhu

doi:10.11949/j.issn.0438-1157.20170405

您当前的位置：

首页 >

文章列表页 >

Instantaneous steady state of pumpless organic Rankine cycle driven by low temperature heat source

更新时间：2025-12-10

- Instantaneous steady state of pumpless organic Rankine cycle driven by low temperature heat source
- CIESC Journal Issue 12, Pages: 4709-4716(2017)
- 作者机构：
  
  上海交通大学制冷与低温工程研究所, 动力机械与工程教育部重点实验室,上海,200240
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20170405
  CLC： K09
- Online First：05 December 2017，
  
  Published：05 December 2017
- 稿件说明：
移动端阅览
LU Huitong, JIANG Long, WANG Liwei, et al. Instantaneous steady state of pumpless organic Rankine cycle driven by low temperature heat source[J]. CIESC Journal, 2017, (12): 4709-4716.
DOI：

LU Huitong, JIANG Long, WANG Liwei, et al. Instantaneous steady state of pumpless organic Rankine cycle driven by low temperature heat source[J]. CIESC Journal, 2017, (12): 4709-4716. DOI： 10.11949/j.issn.0438-1157.20170405.

摘要

建立了一套低温热源驱动的小型无泵有机朗肯循环系统，研究无泵有机朗肯循环回收利用余热发电的性能。该系统中热水温度为75～95℃，冷却水温度为25℃，选择制冷剂R245fa作为系统工质，选择涡旋膨胀机将热能转换为机械能，并通过发电机进行发电。实验结果表明当热水进口温度为95℃时，最大瞬时发电功率为232 W，并可以在250 s的时间内保持稳定在230 W左右，总的发电持续时间为380 s。随着热源水温度下降，功率输出减小，但发电持续时间增加。系统稳定发电平均效率最大为3.92%，此时热源水温度为95℃，最低为3.02%，此时热源水温度为85℃。

Abstract

A small scale pumpless ORC (organic Rankine cycle) system which can recover waste heat from low temperature heat resource is established to investigate the performance of the cycle. The system is mainly composed of two high efficient heat exchangers

one scroll expander

one generator

four refrigerant valves and eight water valves. The flow direction of the water and refrigerant is controlled by the valves. The water heated by electric heating boiler is used to simulate the low temperature heat resource. The temperature of the hot water ranges from 75℃ to 95℃ and the temperature gradient is 5℃. The cooling water from the cooling tower is 25℃ accordingly. The refrigerant R245fa is selected as the working fluid. The results show that the largest power output is 232 W

and the stable power output is about 230 W when the inlet water temperature is 95℃. The total time of power generation last 380 s. One more thing is that the higher inlet water temperature

the less time of power generation process. For the average steady power generation

the maximum energy efficiency is 3.92% and the minimum energy efficiency is 3.02% when the inlet water temperature is 95℃ and 85℃

respectively.

关键词

Keywords

references

Views

225

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Thermodynamic performance of tower-type solar-assisted supercritical compression CO2 energy storage system

Design and experimental analysis for waste heat power generation system from aluminum reduction cell's sidewalls based on RC318 working fluid

Research on thermodynamic properties of supercritical compressed carbon dioxide energy storage system with waste heat recovery

Research on characteristics of compression-absorption refrigeration system driven by waste heat in liquid-cooled data center

Selection of ternary zeotropic mixtures for high-temperature heat pumps on multiparameter evaluation principles

Related Author

ZHANG Dong

LI Yueyi

SU Xinyue

DING Yong

BAI Jianhua

DU Xiaoze

AN Zhoujian

MING Yong

Related Institution

School of Energy, Power and Mechanical Engineering, North China Electric Power University

School of Aerospace Engineering, Guizhou University of Science and Technology

School of Energy and Power Engineering, Lanzhou University of Technology

School of Energy Science and Engineering, Central South University

School of Intelligent Manufacturing, Changde University

⁰