Cooling and freezing law for liquid drop in ultrasound wave

GAO Penghui; ZHANG Meng; DU Yuji; CHENG Bo; ZHANG Donghai; ZHOU Guoqing

doi:10.11949/j.issn.0438-1157.20170381

您当前的位置：

首页 >

文章列表页 >

Cooling and freezing law for liquid drop in ultrasound wave

更新时间：2025-12-10

- Cooling and freezing law for liquid drop in ultrasound wave
- CIESC Journal Issue 11, Pages: 4095-4104(2017)
- 作者机构：
  
  1. 中国矿业大学力学与土木工程学院,江苏,徐州,221116
  2. 中节能城市节能研究院有限公司,江苏,常州,213001
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20170381
  CLC： B66
- Online First：05 November 2017，
  
  Published：05 November 2017
- 稿件说明：
移动端阅览
GAO Penghui, ZHANG Meng, DU Yuji, et al. Cooling and freezing law for liquid drop in ultrasound wave[J]. CIESC Journal, 2017, (11): 4095-4104.
DOI：

GAO Penghui, ZHANG Meng, DU Yuji, et al. Cooling and freezing law for liquid drop in ultrasound wave[J]. CIESC Journal, 2017, (11): 4095-4104. DOI： 10.11949/j.issn.0438-1157.20170381.

摘要

超声波液体辅助冻结在食品、海水淡化及冰蓄冷等方面的应用得到了广泛关注。结合声场理论，在对液滴界面处热质传递分析的基础上，建立了超声波作用下的液滴冷却冻结数学模型，讨论了不同超声波频率、强度及作用时间对液滴界面处热质传递的影响，得到了超声波作用下液滴的冷却冻结规律。结果表明：超声波作用下界面处的传质系数随着超声波强度的增加而增大，但随超声波频率的增加而减小；在液滴冷却冻结过程中，质量传递与热量传递的方向相同，液滴的冷却冻结在超声波作用下得到了强化。在超声波频率为20000 Hz（强度为400 W·m-2），经过相同的时间（60 s），超声波作用下的液滴温度比无超声作用的温度低2.0~2.5℃。研究将有助于深入理解超声波辅助冷却冻结机理，并为其工程应用提供了指导和参考。

Abstract

The application of ultrasound to liquid freezing got much attention over the last few years and its potential seems very promising. In order to make clear droplet freezing assisted by ultrasound

the heat and mass transfer characteristic was studied based on ultrasound theory

penetration theory of mass transfer and energy conservation. The ultrasound frequency

ultrasound intensity and operation time were studied in the process of the liquid drop freezing. The results showed that ultrasound could accelerate mass transfer and make droplet rapidly cooling. In the effect of ultrasound

the bubble size in the droplet was decreased with ultrasound frequency

and the bubble number in the droplet was increased with ultrasound frequency. Mass transfer coefficient of droplet was increased with ultrasound intensity and reduced with ultrasound frequency. For the mass transfer and heat transfer

the direction were same in the droplet freezing process

the heat transfer was strengthened by mass transfer in the droplet freezing process. Comparing with no ultrasound

droplet temperature with ultrasound (ultrasound frequency 20000 Hz and ultrasound intensity 400 W·m-2) was lower 2.0-2.5℃ after the same time (60 s). Hence the ultrasound helps to cool and freeze droplet. This study is favor to understanding the freezing by ultrasound and its application.

关键词

Keywords

references

Views

194

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Influence of ultrasonic treatment on NaCl aqueous solution and MgSO4 aqueous solution in nanofiltration membrane transport

The impact of novel flow channel structure with sudden-expansion ratio on seawater-activated battery

Oxygen mass transfer performance of hollow fiber non-bubble aeration membrane based on gas/liquid-phase measurement method

Construction and tetracycline hydrochloride degradation performance of g-C3N4/Fe3O4 microchannel reactor

Advances in separation technologies for difficult-to-separate systems in petrochemical industry

Related Author

MU Chao

HU Guoxin

CHEN Peiqiang

ZHENG Qun

JIANG Yuting

CHEN Jinmao

WANG Xudong

HUANG Long

Related Institution

School of Mechanical Engineering, Shanghai Jiao Tong University

College of Power and Energy Engineering, Harbin Engineering University

Institute of Systems Engineering, Academy of Military Sciences

School of Civil Engineering and Transportation, Guangzhou University

Key Laboratory for Water Quality and Conservation of the Pearl River Delta, Ministry of Education

⁰