Effect of solubility between R32 and new PVE oil on performance of air conditioning system

JIN Wufeng; YU Bin; GAO Pan; XU Lei

doi:10.11949/j.issn.0438-1157.20170091

您当前的位置：

首页 >

文章列表页 >

Effect of solubility between R32 and new PVE oil on performance of air conditioning system

更新时间：2025-12-10

- Effect of solubility between R32 and new PVE oil on performance of air conditioning system
- CIESC Journal Issue 4, Pages: 1631-1637(2018)
- 作者机构：
  
  天津商业大学机械工程学院,天津,300134
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20170091
  CLC： B61+2
- Online First：05 April 2018，
  
  Published：05 April 2018
- 稿件说明：
移动端阅览
JIN Wufeng, YU Bin, GAO Pan, et al. Effect of solubility between R32 and new PVE oil on performance of air conditioning system[J]. CIESC Journal, 2018, (4): 1631-1637.
DOI：

JIN Wufeng, YU Bin, GAO Pan, et al. Effect of solubility between R32 and new PVE oil on performance of air conditioning system[J]. CIESC Journal, 2018, (4): 1631-1637. DOI： 10.11949/j.issn.0438-1157.20170091.

摘要

首先自主设计搭建溶油性测试系统，测试获得新型PVE油与R32的两相分离温度曲线，分析其互溶性，接着将R32与POE，R32与PVE两种组合使用至某型号热泵分体式空调，对比研究了R32与新型PVE油配合使用对空调性能的影响。结果表明，在测试含油率范围内，R32与R410A专用POE油的互溶性不理想，分离温度高于R410A与POE组合，而PVE油与R32的互溶性有较大改善，最低分离温度可比R410A与POE低8.4℃；空调性能影响方面，R32配合PVE的使用可降低配合POE使用时排气温度约2.6℃，在制冷量和COP方面也具优势。

Abstract

The oil soluble test system was built to get the two phase separation temperature curve of new PVE oil and R32. The mutual solubility of new PVE oil and R32 was analyzed. Then the air conditioning performance of a heat pump split air conditioner was tested at two conditions

one is charging R32 combined with POE oil and the other is charging R32 combined with PVE oil. The results showed that the mutual solubility of R32 and POE oil was not ideal in the test range of oil content. The two phase separation temperature at condition of charging R32 combined with POE oil was higher than that of R410A and POE. The mutual solubility of PVE oil and R32 was better. The minimum separation temperature was 8.4℃ which is lower than that of R410A and POE. In the aspect of the effect on air conditioner performance

the exhaust temperature in case of using PVE oil was 2.6℃ which is lower than that of using POE oil. It also had improvement on cooling capacity and COP by using PVE oil.

关键词

Keywords

references

Views

155

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Study on impact of impurities in coal chemical waste salt on solvation of NaCl and Na2SO4

Experimental investigation on solubility of CO2 in two dipentaerythritol esters

Multi-temperature phase equilibria of quaternary system NH4+, Mg2+, Ca2+// SO42- - H2O and its application

Amination of bromaminic acid catalyzed by Mn-containing basic copper carbonate electrocatalyst based on electrochemical reduction

Experimental study of solubility and viscosity of R513A and PVE lubricants

Related Author

CHENG Wenting

WANG Enqi

CHENG Fangqin

CHI Chenhan

DANG Wenzhe

WANG Xiaopo

WU Changhao

CHEN Ke

Related Institution

Institute of Resourees and Environental Engineering, Shanxi University

National Engineering Research Center of Solid Waste Resource Recovery

Key Laboratory of Thermo-Fluid Science and Engineering, Ministry of Education, Xi'an Jiaotong University

College of Materials and Chemistry Chemical Engineering, Chengdu University of Technology

Tianfu Yongxing Laboratory

⁰