Effect of lower temperature on performance of upflow microaerobic sludge reactor treating manure-free piggery wastewater with high NH<sub>4</sub><sup>+</sup>-N and low COD/TN ratio

HE Jiamin; MENG Jia; ZHANG Yong; LI Jianzheng

doi:10.11949/j.issn.0438-1157.20161733

您当前的位置：

首页 >

文章列表页 >

Effect of lower temperature on performance of upflow microaerobic sludge reactor treating manure-free piggery wastewater with high NH₄⁺-N and low COD/TN ratio

更新时间：2025-12-10

- Effect of lower temperature on performance of upflow microaerobic sludge reactor treating manure-free piggery wastewater with high NH₄⁺-N and low COD/TN ratio
- CIESC Journal Issue 5, Pages: 2074-2080(2017)
- 作者机构：
  
  哈尔滨工业大学城市水资源与水环境国家重点实验室,黑龙江,哈尔滨,150090
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20161733
  CLC： 703.1
- Online First：05 May 2017，
  
  Published：05 May 2017
- 稿件说明：
移动端阅览
HE Jiamin, MENG Jia, ZHANG Yong, et al. Effect of lower temperature on performance of upflow microaerobic sludge reactor treating manure-free piggery wastewater with high NH₄⁺-N and low COD/TN ratio[J]. CIESC Journal, 2017, (5): 2074-2080. DOI: 10.11949/j.issn.0438-1157.20161733.
DOI：

HE Jiamin, MENG Jia, ZHANG Yong, et al. Effect of lower temperature on performance of upflow microaerobic sludge reactor treating manure-free piggery wastewater with high NH₄⁺-N and low COD/TN ratio[J]. CIESC Journal, 2017, (5): 2074-2080. DOI: 10.11949/j.issn.0438-1157.20161733. DOI：

摘要

针对干清粪养猪废水高氨氮低碳氮比的特点，前期研发了升流式微氧活性污泥反应器（UMSR），在23℃条件下可实现碳氮的高效同步去除。为降低处理成本，在HRT 8 h和出水回流比45：1的条件下，对UMSR在20℃、17℃和15℃下的COD、NH4+-N和TN去除效果进行了考察。结果表明，当温度阶段性地从20℃降低为15℃时，UMSR对养猪废水COD的去除率变化不大，均可保持在60%以上，但NH4+-N和TN去除率分别从98.9%和79.8%左右大幅下降到了61.8%和39.7%左右。在17℃条件下，UMSR对COD、NH4+-N和TN的去除率分别平均为62.4%、80.7%和71.2%，出水浓度分别为71、55.5和80.7 mg·L-1左右，完全满足《畜禽养殖业污染物排放标准》（GB 18596—2001）的要求。在15～20℃范围内，温度的降低并没有显著改变UMSR系统的脱氮机制，仍然保持着以anammox为主要脱氮途径的特征。

Abstract

An upflow microaerobic sludge reactor (UMSR) has previously been constructed to treat manure-free piggery wastewater with high NH4+-N and low COD/TN ratio

and illustrated a well synchronous removal of COD

NH4+-N and TN at 23℃ with a hydraulic retention time (HRT) 8.0 h and an effluent reflux ratio 45:1. To decrease the cost of wastewater treatment

effect of lower temperature on the performance of the UMSR was investigated in the present study. With the same HRT and effluent reflux ratio

the temperature in the UMSR was decreased from 20℃ to 17℃ and then to 15℃ stage by stage. The results showed that the drop of temperature had no observable effect on COD removal in the UMSR

which remained above 60% throughout the operation. However

the lower temperature showed a remarkable effect on nitrogen removal. When the USBR got steady in performance at 20℃

the NH4+-N and TN removal reached 98.9% and 79.8%

respectively. Since the temperature dropped to 15℃

NH4+-N and TN removal in the USBR was decreased to 61.8% and 39.7%

respectively. At 17℃

the COD

NH4+-N and TN removal averaged 62.4%

80.7% and 71.2%. The effluent COD

NH4+-N and TN of 71

55.5 and 80.7 mg·L-1

respectively

well met the Discharge Standard of Pollutants for Livestock and Poultry Breeding (GB 18596—2001). It was found that complete nitrification-denitrification

shortcut nitrification-denitrification and anaerobic ammonium oxidation (ANAMMOX) coexisted in the UMSR. Among the denitrification processes

ANAMMOX was the most important approach for NH4+-N and TN removal

and had not been changed by the dropped temperature.

关键词

Keywords

references

Views

185

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Effects of ammonia concentration on physico-chemical characteristics of anaerobic granular sludge

Biological treatment of high concentration NO2--N in passivation washing wastewater and process control strategy

Physics-informed neural networks for intelligent prediction of petrochemical wastewater treatment processes

Preparation of Zn-CuOx/MgO-SiO2 aerogel catalyst with strong electron transfer ability and its catalytic ozonation mechanism and toxicity evaluation on sulfamethoxazole

Deformation and fragmentation characteristics of liquid marbles under the action of non-uniform electric field

Related Author

SU Chengyuan

LU Yuxiang

QIN Jingjing

HUANG Mei

ZHENG Peng

LIN Xiangfeng

HUANG Zhi

DONG Yijun

Related Institution

School of Environment and Resources, Guangxi Normal University

Key Laboratory of Ecology of Rare and Endangered Species and Environmental Protection, Ministry of Education

Key Laboratory of Beijing for Water Quality Science and Water Environment Recovery Engineering, Engineering Research Center of Beijing, Beijing University of Technology

Petro-CyberWorks Information Technology Co., Ltd.

School of Chemical Engineering, Northeast Electric Power University

⁰

Effect of lower temperature on performance of upflow microaerobic sludge reactor treating manure-free piggery wastewater with high NH4+-N and low COD/TN ratio

DOI：10.11949/j.issn.0438-1157.20161733

摘要

Abstract

关键词

Keywords

references

Effect of lower temperature on performance of upflow microaerobic sludge reactor treating manure-free piggery wastewater with high NH₄⁺-N and low COD/TN ratio