Pump-compressor cascade phase-change refrigeration system

YUAN Junfei; YAN Xiaona; ZHANG Minhui; WANG Lin

doi:10.11949/j.issn.0438-1157.20161412

您当前的位置：

首页 >

文章列表页 >

Pump-compressor cascade phase-change refrigeration system

更新时间：2025-11-26

- Pump-compressor cascade phase-change refrigeration system
- CIESC Journal Issue S2, Pages: 142-148(2016)
- 作者机构：
  
  河南科技大学土木工程学院,河南,洛阳,471023
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20161412
  CLC： B61+1
- Online First：30 December 2016，
  
  Published：30 December 2016
- 稿件说明：
移动端阅览
YUAN Junfei, YAN Xiaona, ZHANG Minhui, et al. Pump-compressor cascade phase-change refrigeration system[J]. CIESC Journal, 2016, (S2): 142-148.
DOI：

YUAN Junfei, YAN Xiaona, ZHANG Minhui, et al. Pump-compressor cascade phase-change refrigeration system[J]. CIESC Journal, 2016, (S2): 142-148. DOI： 10.11949/j.issn.0438-1157.20161412.

摘要

泵-压缩机复叠式相变冷却系统是针对高热通量发热元件散热问题的主动式冷却技术，以机械泵循环为重点，实验研究了系统的启动特性、稳定运行特性以及环境适应性等工作特性。结果表明：在机械泵启动时，由于入口抽吸作用和系统内工质的流动特性，系统的压力先降低后升高，热源启动时，系统蒸发器和储液器压力温度波动较小，热源启动稳定。稳定运行阶段，系统流量从2.22 g·s-1增加至5.56 g·s-1时，蒸发器出口工质干度下降，蒸发器进出口的压降增大、压降的振荡幅度增加，蒸发器表面温度下降。在高温环境中，冷却系统能够满足热源的散热需求，储液器压力和蒸发器出口温度波动增大。

Abstract

The phase-change refrigeration system of cascade pump-compressor is aimed at high heat flux components heat radiation cooling technology.The characteristics of starting and stable operation and the adaptability on high-temperature environment are investigated in this paper.The results show that at the first stage of the mechanical pump starting

because of the flow characteristics of the refrigerant and the inlet suction effect

the pressure increased firstly and then decreased.At the start time of the heat source

less pressure and temperature fluctuations

heat source starts stably.At stable operation stage

not only the flow rate of system increases from 2.22 g·s-1 to 5.56 g·s-1

but also the dryness of the evaporator' outlet declines

pressure drop of the evaporator' outlet increases and the surface temperature of evaporator declines.In the high temperature environment

the refrigeration system can meet the demand of the cooling requirement of heat source

and the fluctuation of pressure and outlet temperature rises.

关键词

Keywords

references

Views

135

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Capillary liquid film condensation and heat transfer enhancement driven by superhydrophilic porous metal structure

Research status and prospect of CO2 absorption and separation by phase-change ionic liquid systems

Heat transfer characteristics of phase-change thermal control unit

Study on microstructure of NaCl solution ice centrifugal separation based on Micro-CT and deep learning

Study on entropy wave production and dissipation in partially premixed swirl flames subject to inlet perturbations

Related Author

ZHANG Ben

WANG Songbai

WEI Ziya

HAO Tingting

MA Xuehu

WEN Rongfu

ZHANG Jian

ZENG Shaojuan

Related Institution

State Key Laboratory of Fine Chemicals, Liaoning Key Laboratory of Clean Utilization of Chemical Resources, School of Chemical Engineering, Dalian University of Technology

Henan Institute of Advanced Technology, Zhengzhou University

Beijing Key Laboratory of Ionic Liquids Clean Process, State Key Laboratory of Multiphase Complex Systems, Institute of Process Engineering, Chinese Academy of Sciences

Innovation Academy for Green Manufacture Institute, Chinese Academy of Sciences

Sinopec Petroleum Engineering Corporation, Sinopec Key Laboratory of Carbon Capture, Utilization and Storage (CCUS)

⁰