Micromixing characteristics of tubular reactor packed with different packings

YUAN Pingfang; GUO Kai; ZHANG Xiaobo; LIU Chunjiang

doi:10.11949/j.issn.0438-1157.20161232

您当前的位置：

首页 >

文章列表页 >

Micromixing characteristics of tubular reactor packed with different packings

更新时间：2025-12-10

- Micromixing characteristics of tubular reactor packed with different packings
- CIESC Journal Issue 2, Pages: 653-659(2017)
- 作者机构：
  
  化学工程联合国家重点实验室, 天津大学化工学院,天津,300072
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20161232
  CLC： Q051.1
- Online First：05 February 2017，
  
  Published：05 February 2017
- 稿件说明：
移动端阅览
YUAN Pingfang, GUO Kai, ZHANG Xiaobo, et al. Micromixing characteristics of tubular reactor packed with different packings[J]. CIESC Journal, 2017, (2): 653-659.
DOI：

YUAN Pingfang, GUO Kai, ZHANG Xiaobo, et al. Micromixing characteristics of tubular reactor packed with different packings[J]. CIESC Journal, 2017, (2): 653-659. DOI： 10.11949/j.issn.0438-1157.20161232.

摘要

采用碘化物-碘酸盐平行竞争反应为工作体系，以离集指数（XS）表征微观混合性能，实验考察了Reynolds数Re、物料体积流量比对装填扁环填料和网架填料的管式反应器的微观混合性能的影响及离集指数在管式反应器轴向、径向的分布。结果表明，XS随着Re的增大而下降，而物料体积流量比的增加会导致XS增加，相同条件下网架填料的XS小于扁环填料，离集指数在轴向上呈现先明显降低后基本不变的趋势。在实验研究的基础上，利用团聚模型计算装填网架填料的管式反应器的微观混合时间（tm）为4.82~2.27 ms。与扁环填料对比，网架填料最小值（2.27 ms）低于扁环填料的最小值（2.73 ms），同时二者均小于空管的最小值（3.79 ms），表明装填填料可以改善管式反应器的微观混合性能，网架填料的微观混合性能略优于扁环填料。

Abstract

The micromixing characteristics of a tubular reactor packed with different packings were investigated by adopting the competitive parallel reaction

namely

the Villermaux-Dushman reaction. Experimental results showed that the tube packed with rhombus mesh frame packing (RMFP) presented better micromixing efficiency

compared to the tube with mini ring or empty tube. It could be found that the segregation index (XS) decreased as Reynolds number increased while it increased with increasing volumetric flow ratio. Moreover

the micromixing time (tm) was calculated using an incorporation model based on the experimental data. The minimum tm value of the tube packed with RMFP (tm=2.27 ms) was less than that of the tube with mini ring (tm=2.73 ms) or empty tube (tm=3.79 ms).

关键词

Keywords

references

Views

409

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Micromixing in rotating packed bed with ceramic foam packing

Flow characteristics and micromixing performance of micro-CSTR with magnetic stirring

Effects of Xinjiang high calcium coal co-firing on melting characteristics of Ca-bearing minerals in ash

Experimental study of particle motion and heat transfer in externally heated rotary kiln

Progress of solar photo-thermo-catalysis for ammonia synthesis and decomposition under mild conditions

Related Author

ZHANG Wenjie

CHU Guangwen

LUO Yong

XIANG Yang

ZOU Haikui

CHEN Jianfeng

ZHONG Zihao

LIU Sai'er

Related Institution

Research Center of the Ministry of Education for High Gravity Engineering and Technology, Beijing University of Chemical Technology

Key Laboratory of Thin Film and Microfabrication (Ministry of Education), School of Chemistry and Chemical Engineering, Shanghai Jiao Tong University

State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology

Southern Research, National Carbon Capture Center (NCCC), Wilsonville

Department of Chemical Engineering and Institute for Clean and Secure Energy, University of Utah

⁰