Fate of heavy metals in CaO-conditioned sludge gasification

LU Geng; LIU Huan; HU Hongyun; ZHANG Qiang; YI Linlin; YAO Hong

doi:10.11949/j.issn.0438-1157.20161018

您当前的位置：

首页 >

文章列表页 >

Fate of heavy metals in CaO-conditioned sludge gasification

更新时间：2025-11-26

- Fate of heavy metals in CaO-conditioned sludge gasification
- CIESC Journal Issue 1, Pages: 272-280(2017)
- 作者机构：
  
  1. 华中科技大学能源与动力工程学院, 煤燃烧国家重点实验室,湖北,武汉,430074
  2. 华中科技大学中欧清洁与可再生能源学院,湖北,武汉,430074
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20161018
  CLC： K16
- Online First：05 January 2017，
  
  Published：05 January 2017
- 稿件说明：
移动端阅览
LU Geng, LIU Huan, HU Hongyun, et al. Fate of heavy metals in CaO-conditioned sludge gasification[J]. CIESC Journal, 2017, (1): 272-280.
DOI：

LU Geng, LIU Huan, HU Hongyun, et al. Fate of heavy metals in CaO-conditioned sludge gasification[J]. CIESC Journal, 2017, (1): 272-280. DOI： 10.11949/j.issn.0438-1157.20161018.

摘要

以CaO为主要成分的石灰常用于污泥的调理和稳定。为探究其对污泥气化过程中重金属迁移转化规律的影响，在沉降炉-固定床反应器和固定床上于600、800、1000℃进行了污泥的热解及气化实验，并分析了不同污泥样品、热解焦和气化灰中典型重金属（Mn、Zn、Cu、Cr、Ni）的含量及形态分布。结果表明，CaO的加入将稀释调理污泥中的重金属，并使Mn、Zn、Cr向稳定态转化；CaO会使重金属离子与OH-结合生成沉淀，继而在气化反应中分解成氧化物。在气化过程中，CaO会提高重金属的残留率，也会吸收其氯化物、硫酸盐等在高温下分解生成的HCl、SO2等酸性气体，促使氧化物的生成和抑制重金属的释放。

Abstract

Lime

which is mainly presented as CaO

is often used in sludge conditioning and stabilization.To study the effects of CaO on the fate of heavy metals in pyrolysis and sludge gasification process

the sludge pyrolysis and gasification experiments were conducted with a drop-tube furnace and a fixed-bed system.The content and speciation of typical heavy metals(Mn

Ni) were also analyzed.Samples included different sludges(raw sludge

CaO conditioned sludge)

their corresponding pyrolysis chars and gasification ashes.The results indicated that after CaO conditioning

the content of heavy metals reduced due to the dilution effect.Mn

Cr transformed to stable state.Some heavy metals ions reacted with OH-to form precipitate which then decomposed to produce oxide during sludge gasification process.In addition

CaO can increase the residual rate of heavy metals in solids

and also absorb HCl

SO2 and other acid gases from decomposition of chloride or sulfate to promote the formation of oxides at high temperatures.Subsequently

eutectic was generated in the reactions between these oxides and compounds such as Al3O2

SiO2

Fe2O3 and CaO

thus suppressing the release of heavy metals.

关键词

Keywords

references

Views

275

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Progress of molten salt-assisted thermochemical high-value conversion of biomass

Molecular mechanism study on chemical looping gasification of cellulose over iron oxide nanocluster

Establishment of machine learning-driven biomass pyrolysis model and optimization of volatiles chemical looping reforming hydrogen production process

Extraction and separation of carbon from coal water slurry gasification fine slag by waterflow classifier

High-efficiency adsorption of heavy metal ions by Na2S modified biochar: preparation and adsorption mechanism

Related Author

CAO Wenxuan

WU Boyang

LI Jun

LIU Tianji

ZENG Kuo

YANG Haiping

CHEN Hanping

ZHANG Siwen

Related Institution

School of Energy and Power Engineering, Huazhong University of Science and Technology

EU Institute for Clean and Renewable Energy, Huazhong University of Science and Technology

School of Energy and Power Engineering, Nanjing Institute of Technology

Shaanxi Province Energy and Chemical Process Strengthening Key Laboratory, School of Chemical Engineering and Technology, Xi’an Jiaotong University

State Key Laboratory of Clean and Efficient Coal Utilization, Taiyuan University of Technology

⁰