Antifouling performance of graphene oxide modified PVDF microfiltration membranes in membrane bioreactor

ZHAO Chuanqi; YANG Yuesuo; XU Xiaochen; YANG Fenglin

doi:10.11949/j.issn.0438-1157.20160769

您当前的位置：

首页 >

文章列表页 >

Antifouling performance of graphene oxide modified PVDF microfiltration membranes in membrane bioreactor

更新时间：2025-11-26

- Antifouling performance of graphene oxide modified PVDF microfiltration membranes in membrane bioreactor
- CIESC Journal Issue 1, Pages: 375-384(2017)
- 作者机构：
  
  1. 沈阳大学环境学院,辽宁,沈阳,110044
  2. 大连理工大学环境学院,辽宁,大连,116024
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20160769
  CLC： 703.1
- Online First：05 January 2017，
  
  Published：05 January 2017
- 稿件说明：
移动端阅览
ZHAO Chuanqi, YANG Yuesuo, XU Xiaochen, et al. Antifouling performance of graphene oxide modified PVDF microfiltration membranes in membrane bioreactor[J]. CIESC Journal, 2017, (1): 375-384.
DOI：

ZHAO Chuanqi, YANG Yuesuo, XU Xiaochen, et al. Antifouling performance of graphene oxide modified PVDF microfiltration membranes in membrane bioreactor[J]. CIESC Journal, 2017, (1): 375-384. DOI： 10.11949/j.issn.0438-1157.20160769.

摘要

利用强亲水性氧化石墨烯（GO）作为添加剂，自制了PVDF/GO复合微滤膜，并将其应用于MBR系统中，进行长期应用研究。研究发现，共混膜的表面性质得到改善，其表面含氧基团达到29.33%（GO=3%）；共混膜与PVDF膜对污染物的去除效果相近，但共混膜（GO=3%）仅进行了一次清洗，清洗周期是PVDF的4倍；PVDF/GO共混膜的膜阻力要低于PVDF膜，并且共混膜的不可逆污染阻力显著下降，其数值仅仅是PVDF膜的9.0%（GO=3%）；EPS分析发现，共混膜表面的EPS浓度明显减少，其降幅分别达到59.98%（GO=1%）和69.57%（GO=3%），抗污染性能显著提高；通过SEM与CLSM分析发现，随着氧化石墨烯加入量的提高，共混膜表面形成了滤饼层变得疏松，厚度也变薄，甚至露出了部分膜表面（GO=3%），保证了共混膜稳定的渗透率。

Abstract

Polyvinylidene fluoride(PVDF)/graphene oxide(GO) nanocomposite membranes

which were made of PVDF naocomposites with different content of super hydrophilic graphene oxide(GO) nanosheets

were assessed for long term application in a membrane bioreactor(MBR) system.Critical flux

MBR performance

membrane resistance

and anti-fouling properties were intensively studied.Surface hydrophilicity of PVDF/GO membranes was improved with presence of surficial oxygen-containing groups up to 29.33%(GO=3%).PVDF/GO membranes showed similar anti-fouling to PVDF control membrane

however

PVDF/GO(GO=3%) membrane required only one cleaning with cleaning cycle 4 times longer than PVDF control.PVDF/GO membrane had lower membrane resistance than PVDF control and significant reduction in irreversible fouling resistance.As an example

PVDF/GO(GO=3%) membrane had about 9% of irreversible fouling resistance of PVDF control.Antifouling improvement of PVDF/GO membrane was further shown by EPS study that much lower EPS intensities were observed with a reduction of 59.98%(GO=1%) and 69.57%(GO=3%) in comparison to PVDF control.Scanning electron microscopy(SEM) and confocal laser scanning microscope(CLSM) results showed that cake layer on nanocomposite membrane became looser and thinner with the increase of GO content.Part of PVDF/GO(GO=3%) membrane surface was exposed

resulting in high stable permeability over a long period of time.

关键词

Keywords

references

Views

362

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Constructing nano-composite nanofiltration membranes by in-situ growth: membrane preparation and application

Molecular dynamics study of ion rejection process based on Janus nanochannel

Effects of POSS modified graphene oxide in anti-corrosion and hydrophobic properties of coatings

Preparation of a novel separation-sensing membrane and its dynamic monitoring of blood glucose

Optimization of polyamide selective layer for preparation of high permselectivity reverse osmosis membranes

Related Author

WANG Yu

FENG Yingnan

WANG Tao

ZHAO Zhiping

LI Zirui

QI Kai

WANG Jun

XIA Guodong

Related Institution

School of Chemistry and Chemical Engineering，Beijing Institute of Technology

Beijing Key Laboratory of Heat Transfer and Energy Conversion, Beijing University of Technology

College of Chemical & Pharmaceutical Engineering, Hebei University of Science &Technology

State Key Laboratory of Materials-oriented Chemical Engineering, College of Chemical Engineering, Nanjing Tech University

Department of Anesthesiology, Nanjing Drum Tower Hospital, The Affiliated Hospital of Nanjing University Medical School

⁰