Reactions between P<sub>2</sub>O<sub>5</sub> and calcium phosphate in kiln phosphoric acid

LÜ Li; LIANG Bin; LIU Qiang; LIU Weizao; YANG Honghui; WU Pan; LI Chun

doi:10.11949/j.issn.0438-1157.20160688

Your Location：

Home >

Browse articles >

Reactions between P₂O₅ and calcium phosphate in kiln phosphoric acid

Updated：2025-11-26

- Reactions between P₂O₅ and calcium phosphate in kiln phosphoric acid
- CIESC Journal Vol. 67, Issue 10, Pages: 4399-4405(2016)
- Affiliations：
  
  School of Chemical Engineering, Sichuan University,Sichuan,Chengdu,China,610065
- Author bio：
- Funds：
- DOI：10.11949/j.issn.0438-1157.20160688
  CLC： P273
- Online First：05 October 2016，
  
  Published：05 October 2016
- Accepted：
Scan QR Code
LÜ Li, LIANG Bin, LIU Qiang, et al. Reactions between P₂O₅ and calcium phosphate in kiln phosphoric acid[J]. CIESC Journal, 2016, 67(10): 4399-4405. DOI: 10.11949/j.issn.0438-1157.20160688.
DOI：

LÜ Li, LIANG Bin, LIU Qiang, et al. Reactions between P₂O₅ and calcium phosphate in kiln phosphoric acid[J]. CIESC Journal, 2016, 67(10): 4399-4405. DOI: 10.11949/j.issn.0438-1157.20160688. DOI：

Abstract

Side reactions of gaseous product P2O5 with phosphate ores (so-called P2O5 back absorption) in rotary kiln produce large quantities of low melting point solid products, which could form a kiln ring, block material flow and cause unstable operation of the kiln. The back absorption of gaseous P2O5 with calcium phosphate was studied at different temperatures and the products were characterized for P2O5 content, morphology, phase composition, structure and thermal stability by chemical analysis and other techniques of SEM, XRD, IR, Raman, TG and DSC. The experimental results show that temperature significantly affected the back absorption, which was occurred above 500℃. Calcium metaphosphate was formed at 500-900℃ with almost pure calcium metaphosphate at 900℃. Calcium metaphosphate decomposed into calcium pyrophosphate and P2O5 at 1000-1300℃ with almost pure calcium pyrophosphate at 1300℃.

Keywords

rotary kiln phosphoric acid;P;O;back absorption;calcium metaphosphate;calcium pyrophosphate;fouling;sintering;chemical processes

摘要

窑法磷酸生产中，气体产物P2O5与磷矿发生副反应（俗称P2O5反吸）生成大量低熔点物料，导致窑内结圈堵料，造成生产装置不能稳定运行。以磷酸钙与P2O5的反应为研究对象，采用化学分析与SEM、XRD、IR、Raman、TG及DSC等表征手段对不同温度下该反应产物的P2O5含量、形貌、物相组成、结构及热稳定性能等进行研究，探讨磷矿对P2O5的反吸行为。研究表明，反吸过程与反应温度密切相关，磷酸钙与P2O5在500℃以上发生反应，在500～900℃时，磷酸钙与P2O5反应生成偏磷酸钙，900℃反吸产物几乎为纯偏磷酸钙；在1000～1300℃时，反吸产物偏磷酸钙分解为稳定的焦磷酸钙，同时释放出P2O5气体，1300℃时反吸产物几乎为纯焦磷酸钙。

Abstract

Side reactions of gaseous product P2O5 with phosphate ores (so-called P2O5 back absorption) in rotary kiln produce large quantities of low melting point solid products

which could form a kiln ring

block material flow and cause unstable operation of the kiln. The back absorption of gaseous P2O5 with calcium phosphate was studied at different temperatures and the products were characterized for P2O5 content

morphology

phase composition

structure and thermal stability by chemical analysis and other techniques of SEM

XRD

Raman

TG and DSC. The experimental results show that temperature significantly affected the back absorption

which was occurred above 500℃. Calcium metaphosphate was formed at 500-900℃ with almost pure calcium metaphosphate at 900℃. Calcium metaphosphate decomposed into calcium pyrophosphate and P2O5 at 1000-1300℃ with almost pure calcium pyrophosphate at 1300℃.

关键词

Keywords

references

Views

228

Downloads

CSCD

Alert me when the article has been cited

Submit

Tools

Publicity Resources

Interpretative analysis of carbon deposition process of methanol to olefins catalyst based on NMI-GBR-SHAP

Research progress on direct remediation and regeneration of cathode materials from spent lithium iron phosphate batteries

A semi-supervised soft sensor modeling method based on the Tri-training GPR

An adaptive variable-step homotopy-based algorithm for process simulation with cyclic streams

Particle size prediction of cobalt oxalate synthesis process based on slow feature analysis and least squares support vector regression

Related Author

LI Wenliang

ZHANG Hao

CHEN Mingrui

LIANG Chen

ZHAI Chi

ZHONG Yi

ZHOU Shiyu

JIU Lianchao

Related Institution

School of Chemical Engineering, Kunming University of Science and Technology

School of Chemistry and Chemical Engineering, Southwest University

Hongde Academy, Beijing University of Chemical Technology

College of Chemical Engineering, Beijing University of Chemical Technology

Key Laboratory of Advanced Process Control for Light Industry (Ministry of Education), Jiangnan University

⁰

Reactions between P2O5 and calcium phosphate in kiln phosphoric acid

DOI：10.11949/j.issn.0438-1157.20160688

Abstract

Keywords

摘要

Abstract

关键词

Keywords

references

Reactions between P₂O₅ and calcium phosphate in kiln phosphoric acid