Effect of stirring speed and its change time on phase inversion of high impact polystyrene

LI Zhidan; SHAN Guorong; PAN Pengju

doi:10.11949/j.issn.0438-1157.20160639

您当前的位置：

首页 >

文章列表页 >

Effect of stirring speed and its change time on phase inversion of high impact polystyrene

更新时间：2025-12-10

- Effect of stirring speed and its change time on phase inversion of high impact polystyrene
- CIESC Journal Issue 2, Pages: 788-794(2017)
- 作者机构：
  
  化学工程联合国家重点实验室, 浙江大学化学工程与生物工程学院,浙江,杭州,310027
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20160639
  CLC： Q325.2
- Online First：05 February 2017，
  
  Published：05 February 2017
- 稿件说明：
移动端阅览
LI Zhidan, SHAN Guorong, PAN Pengju. Effect of stirring speed and its change time on phase inversion of high impact polystyrene[J]. CIESC Journal, 2017, (2): 788-794.
DOI：

LI Zhidan, SHAN Guorong, PAN Pengju. Effect of stirring speed and its change time on phase inversion of high impact polystyrene[J]. CIESC Journal, 2017, (2): 788-794. DOI： 10.11949/j.issn.0438-1157.20160639.

摘要

以四官能度过氧化物JWEB50为引发剂，本体接枝共聚法制备高抗冲聚苯乙烯（HIPS）。分别采用透射电镜以及相对扭矩变化对聚合体系的粒子结构、黏度变化进行研究，来分析恒定搅拌以及分段搅拌条件下聚合过程的相转变。研究发现，两种分析方法所得结果相近，相转变时的转化率随恒定搅拌速率的增大而降低。采用分段搅拌方式时，相转变前降低搅拌速率可使相转变时的转化率增大，相转变后降低搅拌速率对相转变时的转化率无影响；相转变过程对应的搅拌速率才是影响相转变的“有效搅拌速率”。上述结果对HIPS的产品性能控制具有极其重要的参考价值。

Abstract

High impact polystyrene (HIPS) was prepared by bulk graft copolymerization with four tetrafunctional peroxide JWEB50 as initiator. Phase inversion at constant and staged stirring conditions was analyzed through study of particle structure and viscosity of the polymerization system by transmission electron microscope and change in relative torque. Similar results were obtained from both analyses. For constant stirring

conversion at phase inversion decreased with the increase of stirring speed. For staged stirring

conversion at phase inversion increased when stirring speed was reduced before phase inversion and no effect on conversion at phase inversion was observed if stirring speed was reduced after phase inversion. Therefore

only “effective stirring speed” corresponding to the stirring speed at phase inversion process actually influenced phase inversion. These results could be very important for performance control of HIPS.

关键词

Keywords

references

Views

384

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Controlled synthesis and properties of gradient copolymers

Research on the characterization of the molecular weight and its distribution of perfluoropolyether

Study on flash evaporation characteristics as well as thermodynamic variation performance in liquid hydrogen tank during on-orbit venting

Study on enhanced pool boiling heat transfer based on self-driven jet device

Research on the thermal physical properties and heat storage performance of FeCoNC carbon material-reinforced composite phase change materials

Related Author

GUO Yunlong

LUO Yingwu

LUO Qinjian

ZHANG Wenhui

QI Yuxuan

CUI Xili

XING Huabin

LIANG Ge

Related Institution

State Key Laboratory of Chemical Engineering, College of Chemical and Biological Engineering, Zhejiang University

College of Chemical and Biological Engineering, Zhejiang University

ZJU-Hangzhou Global Scientific and Technological Innovation Center

Department of Refrigeration and Cryogenic Engineering, Xi’an Jiaotong University

Shanghai Aerospace System Engineering

⁰