Flash evaporation characteristics of ethanol solution droplets under depressurization

HUANG Liang; ZHANG Xuelai

doi:10.11949/j.issn.0438-1157.20160151

您当前的位置：

首页 >

文章列表页 >

Flash evaporation characteristics of ethanol solution droplets under depressurization

更新时间：2025-12-10

- Flash evaporation characteristics of ethanol solution droplets under depressurization
- CIESC Journal Issue 9, Pages: 3762-3767(2016)
- 作者机构：
  
  上海海事大学蓄冷技术研究所,上海,201306
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20160151
  CLC： 552.6
- Online First：05 September 2016，
  
  Published：05 September 2016
- 稿件说明：
移动端阅览
HUANG Liang, ZHANG Xuelai. Flash evaporation characteristics of ethanol solution droplets under depressurization[J]. CIESC Journal, 2016, (9): 3762-3767.
DOI：

HUANG Liang, ZHANG Xuelai. Flash evaporation characteristics of ethanol solution droplets under depressurization[J]. CIESC Journal, 2016, (9): 3762-3767. DOI： 10.11949/j.issn.0438-1157.20160151.

摘要

基于液滴低压闪蒸理论，设计了一套悬垂液滴的真空闪蒸可视化实验装置，研究了质量分数为0、5%、10%、20%的乙醇溶液液滴的降压闪蒸特性，记录了液滴的成核结晶过程。液滴在降压条件下会经历液态蒸发、伴随气泡生长的蒸发、稳态蒸发结冰、伴随气泡生长的结冰、外部结冰内部气泡逸出最终爆裂5种形态。研究表明乙醇溶液的浓度越高，液滴的凝固点越低，液滴结晶所需时间越长；同时还发现一定浓度的乙醇溶液可以提高液滴结晶时的闪蒸室压力，降低了对系统真空度的要求。

Abstract

Based on the flash evaporation theory of a liquid droplet under low pressure

a visual vacuum flash evaporation device was designed for experiment of a suspension droplet. The experiment was performed to investigate the depressurized flash evaporation characteristics of ethanol solution droplets with the mass fraction of 0

10% and 20%

and record the nucleation crystallization process. The liquid droplet went through five morphological changes

respectively:liquid evaporation process

evaporation with bubble growth process

steady evaporation ice process

ice formation with bubble growth process and external ice and internal bubbles escape eventually burst under depressurization. The research showed that the higher the ethanol solution concentration was

the lower the droplets freezing point and the longer the droplet freezing time were. Moreover

it was also found that the ethanol solution in some concentration could increase the pressure of flash chamber when the droplets crystallized and reduced the vacuum requirements of the system.

关键词

Keywords

references

Views

490

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Efficient solar interfacial evaporation using laser-induced graphene

Experimental study on solar interfacial evaporation based on vapor pressure characteristics of different solutions

New technology from sodium vanadate to vanadium oxide by calcification and carbonization-ammonium process

Heat pipe-based experimental study on water separation process in vacuum evaporator

Heat and mass transfer characteristics of evaporation and salt crystallization process of a saline droplet during depressurization

Related Author

CHEN Xuemei

WANG Tong

GAO Yubo

PENG Dingcheng

LUO Yuting

Jiebing WANG

Jintong GAO

Zhenyuan XU

Related Institution

School of Energy and Power Engineering, Nanjing University of Science and Technology

Institute of Refrigeration and Cryogenic Engineering, Shanghai Jiao Tong University

Key Laboratory for Green Process and Engineering, Institute of Process Engineering, Chinese Academy of Sciences

University of Chinese Academy of Sciences

Merchant Marine College, Shanghai Maritime University

⁰