Mass transfer performance of CO<sub>2</sub> absorption into DEA/ethanol solution in microchannel

ZHOU Xu; WANG Xiaojing; ZHU Chunying; MA Youguang; XU Yiming

doi:10.11949/j.issn.0438-1157.20151821

您当前的位置：

首页 >

文章列表页 >

Mass transfer performance of CO₂ absorption into DEA/ethanol solution in microchannel

更新时间：2025-11-26

- Mass transfer performance of CO₂ absorption into DEA/ethanol solution in microchannel
- CIESC Journal Issue 7, Pages: 2901-2906(2016)
- 作者机构：
  
  1. 天津大学化工学院, 化学工程联合国家重点实验室, 天津化学化工协同创新中心,天津,300072
  2. 中建安装工程有限公司,江苏,南京,210000
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20151821
  CLC： Q021.4
- Online First：05 July 2016，
  
  Published：05 July 2016
- 稿件说明：
移动端阅览
ZHOU Xu, WANG Xiaojing, ZHU Chunying, et al. Mass transfer performance of CO₂ absorption into DEA/ethanol solution in microchannel[J]. CIESC Journal, 2016, (7): 2901-2906. DOI: 10.11949/j.issn.0438-1157.20151821.
DOI：

ZHOU Xu, WANG Xiaojing, ZHU Chunying, et al. Mass transfer performance of CO₂ absorption into DEA/ethanol solution in microchannel[J]. CIESC Journal, 2016, (7): 2901-2906. DOI: 10.11949/j.issn.0438-1157.20151821. DOI：

摘要

利用高速摄像仪实验研究了微通道内二乙醇胺（DEA）/乙醇溶液吸收CO2的传质过程。采用图像法得到微通道内气泡的体积变化，根据微通道进出口压力，计算得到了气液两相从开始接触到平衡时的平均传质系数k。分别考察了气液相流量和DEA浓度对传质系数的影响。结果表明：传质系数随着液相流量和溶液中DEA浓度增大而增大。对于给定的液相流量和DEA浓度，k随着气相流量增大而增大并逐渐趋于一个恒定值。提出了一个传质系数预测式，预测值和实验结果吻合良好。

Abstract

A high-speed camera was used to investigate the mass transfer process of CO2 chemical absorption into diethanolamine (DEA)/ethanol solution in microchannel. The volume evolution of the bubbles in the microchannel was obtained by the image-analysis method. By means of the gas pressure at the inlet and outlet of the microchannel

the average mass transfer coefficient (k) from the contact of two phases to equilibrium was attained. The influences of flow rates of gas and liquid and DEA concentration on the mass transfer coefficient were investigated. The experiment results indicated that k increased with increasing liquid flow rate and DEA concentration. For a given liquid flow rate and DEA concentration

k increased gradually up to a constant value with increasing gas phase flow rate. A correlation for estimating k was proposed and the calculated values by the present model agreed well with the experimental data.

关键词

Keywords

references

Views

296

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Numerical simulation of CO2 absorption by alkali liquor in T-junction cylindrical microchannels

Mass transfer performance of CO2 absorption into ionic liquid/ethanol mixture in microchannel

Mechanism and model of ammonia-based carbon dioxide trapping enhanced by gypsum particles

Mass transfer study of CO2 absorption by TETA/DEEA biphasic absorbent in the microchannel

Effects of contamination on the motion and mass transfer of single bubble

Related Author

YANG Yong

ZU Zixuan

LI Yukun

WANG Dongliang

FAN Zongliang

ZHOU Huairong

ZHANG Fanbin

ZHU Chunying

Related Institution

School of Petrochemical Engineering, Lanzhou University of Technology

Key Laboratory of Low Carbon Energy and Chemical Engineering of Gansu Province

State Key Laboratory of Chemical Engineering, Collaborative Innovation Center of Chemical Science and Engineering(TianjinTianjin), School of Chemical Engineering and Technology, Tianjin University

School of Chemical Engineering, Sichuan University

Puguang Branch of SINOPEC Zhongyuan Oilfield

⁰

Mass transfer performance of CO2 absorption into DEA/ethanol solution in microchannel

DOI：10.11949/j.issn.0438-1157.20151821

摘要

Abstract

关键词

Keywords

references

Mass transfer performance of CO₂ absorption into DEA/ethanol solution in microchannel