Experiments on phase-change heat transfer of propane intermediate fluid vaporizer

CHEN Shuangshuang; JI Xin; LIN Wensheng

doi:10.11949/j.issn.0438-1157.20151091

您当前的位置：

首页 >

文章列表页 >

Experiments on phase-change heat transfer of propane intermediate fluid vaporizer

更新时间：2025-12-10

- Experiments on phase-change heat transfer of propane intermediate fluid vaporizer
- CIESC Journal Issue S2, Pages: 192-197(2015)
- 作者机构：
  
  上海交通大学制冷与低温工程研究所,上海,200240
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20151091
  CLC： Q028.8
- Online First：31 August 2015，
  
  Published：31 August 2015
- 稿件说明：
移动端阅览
CHEN Shuangshuang, JI Xin, LIN Wensheng. Experiments on phase-change heat transfer of propane intermediate fluid vaporizer[J]. CIESC Journal, 2015, (S2): 192-197.
DOI：

CHEN Shuangshuang, JI Xin, LIN Wensheng. Experiments on phase-change heat transfer of propane intermediate fluid vaporizer[J]. CIESC Journal, 2015, (S2): 192-197. DOI： 10.11949/j.issn.0438-1157.20151091.

摘要

为了模拟中间流体气化器(IFV)中中间介质丙烷的换热情况

设计并搭建了一个IFV换热模拟实验台。采用水作为热源

冷氮气为冷源

在两个套管式光滑圆管中进行了丙烷的沸腾和冷凝换热实验

分析了水入口温度、水流量和实验管倾斜程度对丙烷换热的影响。结果发现丙烷的沸腾传热系数随着热通量的增大而增大

换热管倾斜时

其换热有所增强

实验值与Cooper方程对其换热的预测值的变化趋势是一致的

误差基本在30%以内。丙烷的冷凝传热系数随着壁面过冷度的增大而减小

传热管倾斜时

其换热也有所增强

传热系数的实验值和Nusselt方程预测值的变化趋势一致

误差在40%以内。

Abstract

To simulate the heat process of propane in the intermediate fluid vaporizer(IFV)

the test rig has been designed and built.Using water as the heat source

cold nitrogen as cold source

the boiling heat transfer and condensing heat transfer experiments of propane were conducted in two smooth concentric circular tubes.Inlet water temperature

water mass flow rate and gradient of tubes were analyzed to see how those factors affeted.With the increase of heat flux

the boiling heat transfer coefficient of propane increases and the tendency goes gentle.The boiling heat transfer coefficient is bigger in declining tubes.The experimental results show the same trend with prediction results from Cooper equation

with 30% of deviation.With the increase of wall sub-cooling

the condensation heat transfer coefficient of propane decreases and the tendency becomes gentle.The condensation heat transfer coefficient of propane is slightly bigger in declining tubes.The experimental results show the same trend with prediction results from Nusselt equation

with 40% of deviation.

关键词

Keywords

references

Views

118

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Numerical simulation for flow condensation of methanol in horizontal tube

Heat transfer characteristics of capillary pumping-replenishment evaporation on nanowire clusters surfaces with V-grooves

Prediction of heat transfer coefficient of horizontal tube falling film evaporation based on GA-BP neural network

Study on evaporation and heat transfer of charged sessile droplet based on lattice Boltzmann method

Research progress on optimizing two-phase refrigerant distribution and boiling heat transfer in microchannel evaporators

Related Author

GUO Jiangyue

CHANG Shoujin

HU Haitao

WANG Yudan

XU Chen

RUAN Da

CHUN Jiang

MA Xuehu

Related Institution

School of Mechanical Engineering, Shanghai Jiao Tong University

Liaoning Key Laboratory of Clean Utilization of Chemical Resource, Institute of Chemical Engineering, Dalian University of Technology

Department of Mechanical and Aerospace Engineering, The Hong Kong University of Science and Technology

College of Energy and Power Engineering, Dalian University of Technology

School of Electric Power Engineering, South China University of Technology

⁰