New air gap membrane distillation module for desalination

ZHANG Chunyao; GENG Hongxin; LANG Qingcheng; LI Pingli; WU Xiaoyan

doi:10.11949/j.issn.0438-1157.20150105

您当前的位置：

首页 >

文章列表页 >

New air gap membrane distillation module for desalination

更新时间：2025-12-10

- New air gap membrane distillation module for desalination
- CIESC Journal Issue 10, Pages: 4000-4006(2015)
- 作者机构：
  
  1. 天津大学化工学院,天津,300072
  2. 天津市膜科学与海水淡化技术重点实验室,天津,300072
  3. 中华全国供销合作总社天津再生资源研究所,天津,300191
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20150105
  CLC： Q028.8
- Online First：05 October 2015，
  
  Published：05 October 2015
- 稿件说明：
移动端阅览
ZHANG Chunyao, GENG Hongxin, LANG Qingcheng, et al. New air gap membrane distillation module for desalination[J]. CIESC Journal, 2015, (10): 4000-4006.
DOI：

ZHANG Chunyao, GENG Hongxin, LANG Qingcheng, et al. New air gap membrane distillation module for desalination[J]. CIESC Journal, 2015, (10): 4000-4006. DOI： 10.11949/j.issn.0438-1157.20150105.

摘要

利用基于聚丙烯中空纤维膜和聚丙烯中空纤维换热管的新型能量回收式膜组件(AGMD-HF)

以70 g·L-1的氯化钠溶液为研究对象

考察了膜组件长度和膜孔径大小对膜组件脱盐性能的影响。为直接衡量操作条件、组件参数以及温差、浓差极化现象对传质系数的影响

引入总传质系数

并研究进料温度和膜孔径对总传质系数的影响。实验结果表明

总传质系数随着温度的升高、膜孔径的增大而增大

提高膜孔径可有效提高总传质系数

同时可有效提高通量和造水比。通量随组件长度的增大而减小

而造水比增大

因此在应用过程中可综合考虑通量和造水比以便选择合适的组件长度。

Abstract

A new air gap membrane distillation module based on hollow fiber with energy recovery was developed for desalination using 70 g·L-1 NaCl solution as the feed. The effects of membrane module length and membrane pore size were investigated. For measuring directly the effects of operating conditions

membrane module properties

and temperature and concentration polarization on the mass transfer coefficient

the total mass transfer coefficient was introduced. The effects of membrane pore size

feeding temperature and feeding flow rate were studied. The results showed that the total mass transfer coefficient increased with the increase of membrane pore size and feeding temperature. The membrane flux and gained-out put ratio were increased effectively with increasing membrane pore size. Since increasing membrane module length would reduce the membrane flux while enhance the gained-out put ratio

the membrane flux and gained-out put ratio should be considered comprehensively for selection of the appropriate membrane module length in the application process.

关键词

Keywords

references

Views

309

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

The impact of novel flow channel structure with sudden-expansion ratio on seawater-activated battery

Oxygen mass transfer performance of hollow fiber non-bubble aeration membrane based on gas/liquid-phase measurement method

Construction and performance optimization of five-chamber microbial desalination cell for enhanced desalination and bioelectricity generation

Construction and tetracycline hydrochloride degradation performance of g-C3N4/Fe3O4 microchannel reactor

Advances in separation technologies for difficult-to-separate systems in petrochemical industry

Related Author

CHEN Peiqiang

ZHENG Qun

JIANG Yuting

CHEN Jinmao

WANG Xudong

HUANG Long

SU Xing

RUAN Man

Related Institution

College of Power and Energy Engineering, Harbin Engineering University

Institute of Systems Engineering, Academy of Military Sciences

School of Civil Engineering and Transportation, Guangzhou University

Key Laboratory for Water Quality and Conservation of the Pearl River Delta, Ministry of Education

Zhejiang Kai Chuang Environment Technology Co., Ltd.

⁰