Graphitization of Shenfu coal

ZHANG Yating; ZHANG Xiaoqian; LIU Guoyang; SI Yunpeng; YUN Hui; ZHOU Anning

doi:10.11949/j.issn.0438-1157.20141401

您当前的位置：

首页 >

文章列表页 >

Graphitization of Shenfu coal

更新时间：2025-12-10

- Graphitization of Shenfu coal
- CIESC Journal Issue 4, Pages: 1514-1520(2015)
- 作者机构：
  
  1. 西安科技大学化学与化工学院,陕西,西安,710054
  2. 陕西延长石油集团有限责任公司碳氢高效利用技术研究中心,陕西,西安,710075
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20141401
  CLC： Q536.1
- Online First：05 April 2015，
  
  Published：05 April 2015
- 稿件说明：
移动端阅览
ZHANG Yating, ZHANG Xiaoqian, LIU Guoyang, et al. Graphitization of Shenfu coal[J]. CIESC Journal, 2015, (4): 1514-1520.
DOI：

ZHANG Yating, ZHANG Xiaoqian, LIU Guoyang, et al. Graphitization of Shenfu coal[J]. CIESC Journal, 2015, (4): 1514-1520. DOI： 10.11949/j.issn.0438-1157.20141401.

摘要

寻求来源广、价格低、纯度高的炭质原料是目前高性能石墨材料制备研究的一个重要方向。以陕北神府煤为原料

探讨了在高温及惰性气氛下

煤粉粒度、催化剂种类及添加量等因素对煤炭石墨化过程的影响

并通过X射线衍射、扫描电镜及拉曼光谱等技术对煤炭高温热处理产物进行了分析和表征。结果表明:当以低变质程度的神府煤为原料时

在2500℃、惰性气氛及一定催化剂存在的条件下

神府煤可以制备得到超细石墨粉;神府煤煤粉粒径越小

超细石墨粉的石墨化程度越高;氯化铁、硼酸等均可以作为神府煤高温石墨化的催化剂

并且当以硼酸作为催化剂

煤粉粒径D90< 20 mm时

由神府原煤可制得石墨化度为80.35%的超细石墨粉。

Abstract

One of the most important orientations of preparation of high-performance graphite materials is to seek carbonaceous materials which have the properties of wide source

low cost and high purity. The influence of coal particle size and catalyst on the graphitization process of ultrafine Shenfu coal at 2500℃ under inert atmosphere was discussed. The degree of graphitization of the products was analyzed with XRD and Raman spectroscopy. The Shenfu coal could change to ultrafine graphite powder at 2500℃ under inert atmosphere

and the degree of graphitization of ultrafine graphite powder increased with decreasing particle size of the Shenfu coal. Furthermore

graphitization of the Shenfu coal with boric acid or ferric chloride as catalyst was compared

and the catalytic activity of boric acid was higher than that of ferric chloride. When the particle size (D90) of the Shenfu coal was smaller than 20 μm

the degree of graphitizations of obtained ultrafine graphite powder from the Shenfu coal was 80.35% by using boric acid as catalyst.

关键词

Keywords

references

Views

396

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Progress of solar photo-thermo-catalysis for ammonia synthesis and decomposition under mild conditions

Bimetallic Ni2P/Fe2P/Fe2O3@NF heterostructure catalyzes oxygen evolution reaction through coupled mechanism and promotes overall water splitting

Research progress in electrocatalytic synthesis of urea from carbon dioxide and nitrate

Construction of Ni-N co-doped carbon aerogel and its performance in electrocatalytic reduction of CO2

Preparation of Zn-CuOx/MgO-SiO2 aerogel catalyst with strong electron transfer ability and its catalytic ozonation mechanism and toxicity evaluation on sulfamethoxazole

Related Author

MA Rong

GUO Guangchao

SUN Jie

LI Donghui

ZHANG Jing

LI Chunlei

ZHAO Yu

LI Ning

Related Institution

Petrochemical Engineering College, Lanzhou University of Technology

School of Chemical Engineering and Technology, Xi’an Jiaotong University

Dalian Institute of Chemical Physics, Chinese Academy of Sciences

Lanzhou Jinchuan Technology Park Co., Ltd.

Qinghai Shenglong New Material Technology Co., Ltd.

⁰