Numerical simulation of fluid mixing time in liquid impinging streams reactor

LUO Yan; ZHOU Jianqiu; GUO Zhao; YU Bei; XIONG Hui; YANG Xia

doi:10.11949/j.issn.0438-1157.20141158

您当前的位置：

首页 >

文章列表页 >

Numerical simulation of fluid mixing time in liquid impinging streams reactor

更新时间：2025-12-10

- Numerical simulation of fluid mixing time in liquid impinging streams reactor
- CIESC Journal Issue 6, Pages: 2049-2054(2015)
- 作者机构：
  
  1. 南京工业大学机械与动力工程学院,江苏,南京,210009
  2. 武汉工程大学机电工程学院,湖北,武汉,430073
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20141158
  CLC： Q05
- Online First：05 June 2015，
  
  Published：05 June 2015
- 稿件说明：
移动端阅览
LUO Yan, ZHOU Jianqiu, GUO Zhao, et al. Numerical simulation of fluid mixing time in liquid impinging streams reactor[J]. CIESC Journal, 2015, (6): 2049-2054.
DOI：

LUO Yan, ZHOU Jianqiu, GUO Zhao, et al. Numerical simulation of fluid mixing time in liquid impinging streams reactor[J]. CIESC Journal, 2015, (6): 2049-2054. DOI： 10.11949/j.issn.0438-1157.20141158.

摘要

在混合时间理论计算基础上利用CFD技术模拟连续操作的LISR混合过程

数值计算与验证混合时间的变化规律。结果表明

随着输入比有效功率增大

混合时间先急剧减小后逐渐趋于平稳;LISR撞击区一次撞击局部混合时间在0.25 s以内

与经验公式或理论公式计算所得结果在数量级上完全一致

证明数值方法分析一次撞击局部混合时间是可行的

而且可以弥补实验无法测定中间过程参量的不足;进一步数值分析宏观混合时间与微观混合时间发现

二者大小相差1个数量级

但二者变化规律处于一种联动平衡状态

该结果与前期理论分析结果一致;本研究所得结论可为后续LISR混合强化机理与性能研究提供定量参考。

Abstract

On the basis of theoretical calculation

the mixing process under continuous operation in liquid impinging streams reactor (LISR) was simulated by CFD and the change of mixing time was calculated and verified numerically. With increasing effective specific power

mixing time decreased rapidly at first and then tended to be smooth and steady. The local mixing time in one stroke of impinging mixing was less than 0.25 s

which fully agreed with the order of magnitude figured out by empirical model and theoretical model. It was demonstrated that using the numerical method to analyze local mixing time is feasible. It could also make up for the deficiency of experimental research. To further study macromixing time and micromixing time numerically

it was found that macromixing time was one order of magnitude greater than micromixing time

but both changes were fundamentally consistent and were in a linkage state of equilibrium which was in accordance with our previous theoretical analysis. These conclusions could be used as the mechanism methods and quantitative reference for follow-up study of mixing enhancement mechanism of LISR.

关键词

Keywords

references

Views

296

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Numerical study on vortex characteristics in submerged impinging stream reactor

Analysis of dynamic characteristics of flow field in impinging stream reactor based on step jet

Hydrogen thermal coupling transfer mechanism based on metal hydride high temperature heat storage technology

Research on the effects of rotor cascade geometric parameters on flow field and aerodynamic performance of turbine reactors

Engineering verification and NO emission control of rare earth Y2O3-based catalytic coatings on a metal fiber surface burner

Related Author

Jianwei ZHANG

Weifeng GAO

Xin DONG

Ying FENG

Jianwei ZHANG

Fengyuan AN

Xin DONG

Ying FENG

Related Institution

School of Mechanical and Power Engineering, Shenyang University of Chemical Technology

Shenyang University of Chemical Technology, School of Mechanical and Power Engineering

School of Chemical Engineering and Technology, State Key Laboratory of Multiphase Flow in Power Engineering, Xi’an Jiaotong University

Key Laboratory of Pressure Systems and Safety, Ministry of Education，School of Mechanical and Power Engineering, East China University of Science and Technology

School of Mechanical and Power Engineering, East China University of Science and Technology

⁰