Solubility of light alkanes and alkenes in ionic liquids

Rui ZHANG; Shuyuan DONG; Luo WU; Zhichang LIU; Chunming XU; Haiyan LIU; Xianghai MENG

doi:10.11949/0438-1157.20200735

您当前的位置：

首页 >

文章列表页 >

Solubility of light alkanes and alkenes in ionic liquids

Separation engineering | 更新时间：2025-11-25

- Solubility of light alkanes and alkenes in ionic liquids
- CIESC Journal Vol. 71, Issue 10, Pages: 4674-4687(2020)
- 作者机构：
  
  中国石油大学（北京）重质油国家重点实验室，北京 102249
- 作者简介：
- 基金信息：
- DOI：10.11949/0438-1157.20200735
  CLC： TE 624
- Received：10 June 2020，
  
  Revised：2020-08-12，
  
  Published：05 October 2020
- 稿件说明：
移动端阅览
张睿, 董淑媛, 伍洛, 刘植昌, 徐春明, 刘海燕, 孟祥海. 小分子烷烃与烯烃在离子液体中的溶解性能[J]. 化工学报, 2020, 71(10): 4674-4687

ZHANG Rui, DONG Shuyuan, WU Luo, LIU Zhichang, XU Chunming, LIU Haiyan, MENG Xianghai. Solubility of light alkanes and alkenes in ionic liquids[J]. CIESC Journal, 2020, 71(10): 4674-4687
张睿, 董淑媛, 伍洛, 刘植昌, 徐春明, 刘海燕, 孟祥海. 小分子烷烃与烯烃在离子液体中的溶解性能[J]. 化工学报, 2020, 71(10): 4674-4687 DOI： 10.11949/0438-1157.20200735.

ZHANG Rui, DONG Shuyuan, WU Luo, LIU Zhichang, XU Chunming, LIU Haiyan, MENG Xianghai. Solubility of light alkanes and alkenes in ionic liquids[J]. CIESC Journal, 2020, 71(10): 4674-4687 DOI： 10.11949/0438-1157.20200735.

摘要

研究了多种离子液体对小分子烃类的溶解性能，发现含有Cu(Ⅰ)的离子液体对烃类具有较高的溶解度和烯烃/烷烃溶解选择性，优选出了Et

NHCl-2.1CuCl离子液体。考察了温度和压力对小分子烃类溶解性能的影响规律，发现低温和高压有利烃类的溶解，烯烃/烷烃溶解选择性随温度和压力的升高而减小；在30℃和0.2 MPa的条件下，烯烃/烷烃溶解选择性均在8.3以上。烃类在离子液体中的初始溶解速率较大，但随时间的延长快速降低，相同条件下烯烃的溶解速率高于烷烃的溶解速率。烯烃/烷烃分离选择性随混合气中烯烃含量的减小而增大。升温可以解吸出离子液体中的烃类，烷烃比烯烃容易解吸，优化条件下的解吸率可达92%以上。离子液体对小分子烷烃和烯烃的吸收分离具有良好的重复使用性能。利用Gaussian 09软件对离子液体的阴离子与烯烃、烷烃的作用进行了计算分析，解释了烯烃和烷烃在不同离子液体中溶解性能差异的原因。

Abstract

The solubility of light hydrocarbons in a variety of ionic liquids was studied

and it was found that ionic liquids containing Cu(Ⅰ) had higher solubility for hydrocarbons and alkene/alkane solubility selectivity

and Et

NHCl-2.1CuCl ionic liquid was preferred. The effects of temperature and pressure on the solubility of light hydrocarbons were investigated for the selected ionic liquid. It was found that low temperature and high pressure were favorable for the dissolution of light hydrocarbons

and the alkene/alkane solubility selectivity decreased with the increase of temperature and pressure. The alkene/alkane solubility selectivity was above 8.3 at the temperature of 30℃ and the pressure of 0.2 MPa. The initial dissolution rate of hydrocarbons in ionic liquid was large

but it decreased rapidly with prolonging time

and the dissolution rate of alkenes was higher than that of alkanes at the same conditions. The alkene/alkane separation selectivity increased with decreasing content of alkenes in the mixture of alkenes and alkanes. Light hydrocarbons dissolved in ionic liquids could be desorbed by means of increasing temperature

restoring the dissolution capability of ionic liquids to hydrocarbons. Alkanes were easier to be desorbed than alkenes

and small-molecule hydrocarbons were easier to be desorbed than large-molecule hydrocarbons. The desorption percentage exceeded 92% under optimal conditions. Ionic liquid had a good reusable performance in the absorption and separation of light alkanes and alkenes. The solubility only decreased by less than 5% when it was reused five times

and the alkane/alkane solubility selectivity was basically not affected by reusing times. Software Gaussian 09 was used to study the interaction between anions of ionic liquids and light alkanes and alkanes

and the solubility difference of light alkenes and alkanes in different ionic liquids was well explained.

关键词

Keywords

references

Gao Y F , Neal L , Ding D , et al . Recent advances in intensified ethylene production— a review [J]. ACS Catalysis , 2019 , 9 : 8592 - 8621 .

王梦瑶 , 周嘉文 , 任天华 , 等 . 催化裂化多产丙烯 [J]. 化工进展 , 2015 , 34 ( 6 ): 1619 - 1624 .

Wang M Y , Zhou J W , Ren T H , et al . Catalytic cracking processes for maximizing propylene production [J]. Chemical Industry and Engineering Progress , 2015 , 34 ( 6 ): 1619 - 1624 .

Ali M A , Ahmed S , Al-Baghli N , et al . A comprehensive review covering conventional and structured catalysis for methanol to propylene conversion [J]. Catalysis Letters , 2019 , 149 : 3395 - 3424 .

Shi L , Wang Y , Yan B , et al . Progress in selective oxidative dehydrogenation of light alkanes to olefins promoted by boron nitride catalysts [J]. Chemical Communications , 2018 , 54 : 10936 - 10946 .

Azhin M , Kaghazchi T , Rahmani M . A review on olefin/paraffin separation using reversible chemical complexation technology [J]. Journal of Industrial and Engineering Chemistry , 2008 , 14 ( 5 ): 622 - 638 .

杨学萍 . 轻质烯烃-烷烃分离新工艺开发进展 [J]. 化工进展 , 2005 , 24 ( 4 ): 367 - 371 .

Yang X P . Advances in light olefin - paraffin separation technology [J]. Chemical Industry and Engineering Progress , 2005 , 24 ( 4 ): 367 - 371 .

Lei Z G , Li C Y , Chen B H . Extractive distillation: a review [J]. Separation and Purification Reviews , 2003 , 32 ( 2 ): 121 - 213 .

Matsuyama E , Ikeda A , Komatsuzaki M , et al . High-temperature propylene/propane separation through silica hybrid membranes [J]. Separation and Purification Technology , 2014 , 128 : 25 - 30 .

Lei Z G , Dai C N , Chen B H . Gas solubility in ionic liquids [J]. Chemical Reviews , 2014 , 114 ( 2 ): 1289 - 1326 .

赵旭 , 邢华斌 , 李如龙 , 等 . 离子液体在气体分离中的应用 [J]. 化学进展 , 2011 , 23 ( 11 ): 2258 - 2268 .

Zhao X , Xing H B , Li R L , et al . Gas separation based on ionic liquids [J]. Progress in Chemistry , 2011 , 23 ( 11 ): 2258 - 2268 .

曹领帝 , 曾少娟 , 张香平 , 等 . 离子液体吸收分离硫化氢进展 [J]. 化工学报 , 2015 , 66 : 1 - 9 .

Cao L D , Zeng S J , Zhang X P , et al . Progress on hydrogen sulfide removal using ionic liquids [J]. CIESC Journal , 2015 , 66 : 1 - 9 .

王兰云 , 李振东 , 位亚南 , 等 . 基于离子液体吸收法的气体分离研究进展 [J]. 煤炭学报 , 2018 , 43 ( 3 ): 704 - 716 .

Wang L Y , Li Z D , Wei Y N , et al . Gas separation by absorption in pure ionic liquids [J]. Journal of China Coal Society , 2018 , 43 ( 3 ): 704 - 716 .

Zhang X P , Zhang X C , Dong H F , et al . Carbon capture with ionic liquids: overview and progress [J]. Energy & Environmental Science , 2012 , 5 : 6668 - 6681 .

Cadena C , Anthony J L , Shah J K , et al . Why is CO 2 so soluble in imidazolium-based ionic liquids [J]. Journal of the American Chemical Society , 2004 , 126 ( 16 ): 5300 - 5308 .

孟祥海 , 刘植昌 , 张睿 , 等 . 用于吸收酸性气体的含胺基离子液体及其制备方法与应用 : 101993378 [P]. 2011-03-30 .

Meng X H , Liu Z H , Zhang R , et al . Amine-containing ionic liquids used for absorbing acid gases and their preparation and application : 101993378 [P]. 2011-03-30 .

Hu P C , Zhang R , Liu Z H , et al . Absorption performance and mechanism of CO 2 in aqueous solutions of amine-based ionic liquids [J]. Energy & Fuels , 2015 , 29 : 6019 - 6024 .

Moura M , Santini C C , Gomes M F C . Gaseous hydrocarbon separations using functionalized ionic liquids [J]. Oil & Gas Science and Technology - Revue d'IFP Energies Nouvelles , 2016 , 71 ( 2 ): 1 - 11 .

Moura L , Darwich W , Santini C C , et al . Imidazolium-based ionic liquids with cyano groups for the selective absorption of ethane and ethylene [J]. Chemical Engineering Journal , 2015 , 280 : 755 - 762 .

Xing H B , Zhao X , Li R L , et al . Improved efficiency of ethylene/ethane separation using a symmetrical dual nitrile-functionalized ionic liquid [J]. ACS Sustainable Chemistry & Engineering , 2013 , 1 ( 11 ): 1357 - 1363 .

Mokrushin V , Assenbaum D , Paape N , et al . Ionic liquids for propene-propane separation [J]. Chemical Engineering Technology , 2010 , 33 ( 1 ): 63 - 73 .

Jacquemin J , Gomes M F C , Husson P , et al . Solubility of carbon dioxide, ethane, methane, oxygen, nitrogen, hydrogen, argon, and carbon monoxide in 1-butyl-3-methylimidazolium tetrafluoroborate between temperatures 283 K and 343 K and at pressures close to atmospheric [J]. Journal of Chemical Thermodynamics , 2006 , 38 ( 4 ): 490 - 502 .

Anthony J L , Maginn E J , Brennecke J F . Solubilities and thermodynamic properties of gases in the ionic liquid 1- n -butyl-3-methylimidazolium hexafluorophosphate [J]. Journal of Physical Chemistry B , 2002 , 106 ( 29 ): 7315 - 7320 .

Lee B C , Outcalt S L . Solubilities of gases in the ionic liquid 1- n -butyl-3-methylimidazolium bis(trifluoromethylsulfonyl)imide [J]. Journal of Chemical and Engineering Data , 2006 , 51 ( 3 ): 892 - 897 .

Fallanza M , González-Miquel M , Ruiz E , et al . Screening of RTILs for propane/propylene separation using COSMO-RS methodology [J]. Chemical Engineering Journal , 2013 , 220 : 284 - 293 .

Kilaru P K , Condemarin R A , Scovazzo P . Correlations of low-pressure carbon dioxide and hydrocarbon solubilities in imidazolium-, phosphonium-, and ammonium-based room-temperature ionic liquids(1):Using surface tension [J]. Industrial & Engineering Chemistry Research , 2008 , 47 ( 3 ): 900 - 909 .

Palgunadi J , Kim H S , Lee J M , et al . Ionic liquids for acetylene and ethylene separation: material selection and solubility investigation [J]. Chemical Engineering and Processing: Process Intensification , 2010 , 49 ( 2 ): 192 - 198 .

Xing H B , Zhao X , Yang Q W , et al . Molecular dynamics simulation study on the absorption of ethylene and acetylene in ionic liquids [J]. Industrial & Engineering Chemistry Research , 2013 , 52 ( 26 ): 9308 - 9316 .

Huang Y Q , Zhang Y B , Xing H B . Separation of light hydrocarbons with ionic liquids: a review [J]. Chinese Journal of Chemical Engineering , 2019 , 27 ( 6 ): 1374 - 1382 .

Sánchez L M G , Meindersma G W , Haan A B . Potential of silver-based room-temperature ionic liquids for ethylene/ethane separation [J]. Industrial & Engineering Chemistry Research , 2009 , 48 ( 23 ): 10650 - 10656 .

Ortiz A , Gorri D , Irabien A , et al . Separation of propylene/propane mixtures using Ag + -RTIL solutions. Evaluation and comparison of the performance of gas-liquid contactors [J]. Journal of Membrane Science , 2010 , 360 ( 1/2 ): 130 - 141 .

Marcos F , Ortiz A , Gorri D , et al . Propylene and propane solubility in imidazolium, pyridinium, and tetralkylammonium based ionic liquids containing a silver salt [J]. Journal of Chemical & Engineering Data , 2013 , 58 ( 8 ): 2147 - 2153 .

Shen X L , Abro R , Alhumaydhi I A , et al . Separation of propylene and propane by functional mixture of imidazolintum chloride ionic liquid - organic solvent - cuprous salt [J]. Separation and Purification Technology , 2017 , 175 : 177 - 184 .

Ortiz A , Galan L M , Gorri D , et al . Reactive ionic liquid media for the separation of propylene/propane gaseous mixtures [J]. Industrial & Engineering Chemistry Research , 2010 , 49 ( 16 ): 7227 - 7233 .

Yu G R , Zhang L , Alhumaydhi I A , et al . Separation of propylene and propane by alkylimidazolium thiocyanate ionic liquids with Cu + salt [J]. Separation and Purification Technology , 2015 , 156 : 356 - 362 .

Yu G R , Deng L Y , Abdeltawab A A , et al . Functional solution composed of Cu(Ⅰ) salt and ionic liquids to separate propylene from propane [J]. Industrial & Engineering Chemistry Research , 2014 , 53 ( 34 ): 13430 - 13435 .

Neese F . The ORCA program system [J]. Wiley Interdisciplinary Reviews: Computational Molecular Science , 2012 , 2 ( 1 ): 73 - 78 .

Lu T , Chen F . Multiwfn: a multifunctional wavefunction analyzer [J]. Journal of Computational Chemistry , 2012 , 33 ( 5 ): 580 - 592 .

Humphrey W , Dalke A , Schulten K . VMD: visual molecular dynamics [J]. Journal of Molecular Graphics , 1996 , 14 ( 1 ): 33 - 38 .

Safarik D J , Eldridge R B . Olefin/paraffin separations by reactive absorption: a review [J]. Industrial & Engineering Chemistry Research , 1998 , 37 ( 7 ): 2571 - 2581 .

Pipek J , Mezey P G . A fast intrinsic localization procedure applicable for abinitio and semiempirical linear combination of atomic orbital wave functions [J]. The Journal of Chemical Physics , 1989 , 90 ( 9 ): 4916 - 4926 .

Becke A D , Edgecombe K E . A simple measure of electron localization in atomic and molecular systems [J]. The Journal of Chemical Physics , 1990 , 92 ( 9 ): 5397 - 5403 .

Schmider H L , Becke A D . Chemical content of the kinetic energy density [J]. Journal of Molecular Structure: THEOCHEM , 2000 , 527 ( 1/2/3 ): 51 - 61 .

Davidson E R , Chakravorty S . A test of the Hirshfeld definition of atomic charges and moments [J]. Theoretica Chimica Acta , 1992 , 83 ( 5/6 ): 319 - 330 .

Geerlings P , De Proft F , Langenaeker W . Conceptual density functional theory [J]. Chemical Reviews , 2003 , 103 ( 5 ): 1793 - 1874 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Sulfur dioxide absorption by PEG-based functionalized ionic liquids

Vapor-liquid equilibrium of ethylene in low viscous dicyanamide-based ionic liquids

Continuous atmospheric water harvester based on solar interfacial evaporation of LiCl solution

High capacity absorption of SO2 using imidazole ionic liquid mixtures

Mass transfer performance of CO2 absorption into ionic liquid/ethanol mixture in microchannel

Related Author

CHEN Ying

WANG Jianying

LIU Chao

JIANG Haichao

LIU Yumin

HU Yongqi

Rui YANG

Li DONG

Related Institution

College of Chemical and Pharmaceutical Engineering, Hebei University of Science and Technology

School of Chemical and Environmental Engineering, China University of Mining and Technology, Beijing

Beijing Key Laboratory of Ionic Liquids Clean Process, Institute of Process Engineering, Chinese Academy of Sciences

Institute of Refrigeration and Cryogenics, Shanghai Jiao Tong University

School of Chemistry and Chemical Engineering, Nanjing University

⁰