Chaotic mixing and droplet dispersion characteristics of liquid - liquid with elastic combined impeller

Zuohua LIU; Chuang WANG; Wei SUN; Changyuan TAO; Yundong WANG

doi:10.11949/0438-1157.20200675

您当前的位置：

首页 >

文章列表页 >

Chaotic mixing and droplet dispersion characteristics of liquid - liquid with elastic combined impeller

Fluid dynamics and transport phenomena | 更新时间：2025-11-25

- Chaotic mixing and droplet dispersion characteristics of liquid - liquid with elastic combined impeller
- CIESC Journal Vol. 71, Issue 10, Pages: 4611-4620(2020)
- 作者机构：
  
  1.重庆大学化学化工学院，重庆400044
  2.清华大学化学工程系，北京 100084
- 作者简介：
- 基金信息：
- DOI：10.11949/0438-1157.20200675
  CLC： TQ 027.2
- Received：02 June 2020，
  
  Revised：2020-07-29，
  
  Published：05 October 2020
- 稿件说明：
移动端阅览
刘作华, 王闯, 孙伟, 陶长元, 王运东. 弹性搅拌桨强化液-液两相混沌混合及液滴分散特性的研究[J]. 化工学报, 2020, 71(10): 4611-4620

LIU Zuohua, WANG Chuang, SUN Wei, TAO Changyuan, WANG Yundong. Chaotic mixing and droplet dispersion characteristics of liquid - liquid with elastic combined impeller[J]. CIESC Journal, 2020, 71(10): 4611-4620
刘作华, 王闯, 孙伟, 陶长元, 王运东. 弹性搅拌桨强化液-液两相混沌混合及液滴分散特性的研究[J]. 化工学报, 2020, 71(10): 4611-4620 DOI： 10.11949/0438-1157.20200675.

LIU Zuohua, WANG Chuang, SUN Wei, TAO Changyuan, WANG Yundong. Chaotic mixing and droplet dispersion characteristics of liquid - liquid with elastic combined impeller[J]. CIESC Journal, 2020, 71(10): 4611-4620 DOI： 10.11949/0438-1157.20200675.

摘要

传统的混合澄清槽一般采用刚性搅拌桨来实现液-液两相的混合萃取，普遍存在效率低、能耗高等问题。将一种弹性搅拌桨应用在混合澄清槽中，以强化液-液两相混沌混合及分散特性。以最大Lyapunov指数（LLE）和多尺度熵（MSE）表征体系混沌状态，以分散相液滴粒径分布、Sauter平均粒径（

）等表征分散效果，分别研究了桨叶类型（弹性搅拌桨、刚柔组合桨及刚性桨）、弹簧长度、线径、外径等因素对混沌混合效果和分散特性的影响。结果表明，相比较刚性搅拌桨和刚柔组合搅拌桨，弹性搅拌桨通过弹簧的形变和储能作用，强化了搅拌能量的传递方式，提高了分散相的分散效果，有利于液液两相的混沌混合，在搅拌转速

=200 r/min、弹簧线径为0.6 mm、弹簧相对长度为1.2、弹簧外径为7 mm时，弹性搅拌桨体系的LLE和MSE更大，且MSE值波动最强；同时，各搅拌体系内分散相平均粒径

与转速呈对数线性关系，弹性搅拌桨体系内分散相液滴尺寸更小且数量更多。

Abstract

Traditional mixing and clarification tanks generally use rigid stirring blades to achieve liquid-liquid two-phase mixed extraction

which generally suffers from low efficiency and high energy consumption. A kind of elastic combined impeller was used in the mixing clarifier in this work to enhance the liquid-liquid biphase mixing behavior. Lyapunov exponent (LLE) and multiscale entropy (MSE) were used to characterize the chaotic state of the system

the particle size distribution and

were used to characterize the dispersion effect. The influence of impeller type (elastic combined impeller

rigid-flexible combined impeller and rigid impeller)

spring length

wire diameter and outer diameter on mixing effect was studied. The results indicated that compared with the rigid impeller and the rigid-flexible combined impeller

the elastic combined impeller strengthens the energy dissipation mode of the flow field through the deformation and energy storage of the spring

improves the dispersion effect of the dispersed phase

and was conducive to the chaotic mixing of the liquid-liquid biphase. When stirring speed

= 200 r/min

the spring wire diameter was 0.6 mm

the relative length of the spring was 1.2

and the external diameter of the spring was 7 mm

the LLE value and the amplitude of MSE were the largest and the MSE values fluctuate most strongly. At the same time

there was a log-linear relationship between the

of dispersed phase and the stirring speed in each stirring system

and the droplet size of dispersed phase in the elastic combined impeller system was smaller and more.

关键词

Keywords

references

袁孝竞 , 干爱华 , 田桂林 , 等 . 规整填料塔在国内的应用 [J]. 石油化工设计 , 1996 , 13 ( 2 ): 55 .

Yuan X J , Gan A H , Tian G L , et al . Structure packed column technology and its applications [J]. Petrochemical Design , 1996 , 13 ( 2 ): 55 .

费维扬 , 温晓明 , 陈德宏 , 等 . 填料萃取塔设计和应用和若干特点 [J]. 炼油设计 , 1998 , 28 ( 2 ): 49 - 52 .

Fei W Y , Wen X M , Chen D H , et al . Characteristics of design and application of packed extraction tower [J]. Petroleum Refinery Engineering , 1998 , 28 ( 2 ): 49 - 52 .

夏清 , 陈常贵 . 化工原理(下) [M]. 天津 : 天津大学出版社 , 2005 .

Xia Q , Chen C G . Principles of Chemical Engineering (Ⅱ) [M]. Tianjin : Tianjin University Press , 2005 .

Srilatha C , Savant A R , Patwardhan A W , et al . Head-flow characteristics of pump-mix mixers [J]. Chemical Engineering & Processing: Process Intensification , 2008 , 47 ( 9 ): 1678 - 1692 .

Schlesinger M E , King M J , Sole K C , et al . Extractive Metallurgy of Copper [M]. 5th ed . Elsevier , 2011 .

Singh K K , Mahajani S M , Shenoy K T , et al . CFD modeling of pump-mix action in continuous flow stirred tank [J]. American Institute of Chemical Engineers Journal , 2010 , 54 ( 1 ): 42 - 55 .

Singh K K , Mahajani S M , Shenoy K T , et al . CFD modeling of pilot-scale pump-mixer: single-phase head and power characteristics [J]. Chemical Engineering Science , 2007 , 62 ( 5 ): 1308 - 1322 .

Shahcheraghi S H , Khayati G R , Ranjbar M . Improved dynamic modeling and simulation of an industrial copper solvent extraction process [J]. Hydrometallurgy , 2016 , 166 : 266 - 278 .

叶思施 , 唐巧 , 乔军帅 , 等 . P507-煤油体系物性测量及其在澄清槽内的CFD模拟 [J]. 化工学报 , 2016 , 67 ( 2 ): 458 - 468 .

Ye S S , Tang Q , Qiao J S , et al . Physical properties measurements and CFD simulations in settler of different P507-kerosene systems [J]. CIESC Journal , 2016 , 67 ( 2 ): 458 - 468 .

Sadeghi R , Mohebbi A , Sarrafi A , et al . CFD simulation and optimization of the settler of an industrial copper solvent extraction plant: a case study [J]. Hydrometallurgy , 2011 , 106 ( 3 ): 148 - 158 .

Emmerich J R , Tang Q , Wang Y , et al . Optical inline analysis and monitoring of particle size and shape distributions for multiple applications: scientific and industrial relevance [J]. Chinese Journal of Chemical Engineering , 2019 , 27 ( 2 ): 257 - 277 .

Zhou G , Kresta S M . Evolution of drop size distribution in liquid-liquid dispersions for various impellers [J]. Chemical Engineering Science , 1998 , 53 ( 11 ): 2099 - 2113 .

邱发成 , 刘作华 , 刘仁龙 , 等 . 偏心射流-刚柔组合桨搅拌器内混沌混合行为研究 [J]. 化工学报 , 2018 , 69 ( 2 ): 618 - 624 .

Qiu F C , Liu Z H , Liu R L , et al . Chaotic mixing performance in rigid-flexible impeller stirred tank with eccentric air jet [J]. CIESC Journal , 2018 , 69 ( 2 ): 618 - 624 .

Nomura T , Uchida T , Takahashi K . Enhancement of mixing by unsteady agitation of an impeller in an agitated vessel [J]. Journal of Chemical Engineering of Japan , 1997 , 30 ( 5 ): 875 - 879 .

Hirata Y , Dote T , Yoshioka T . Performance of chaotic mixing caused by reciprocating a disk in a cylindrical vessel [J]. Chemical Engineering Research and Design , 2007 , 85 ( A5 ): 576 - 582 .

Komoda Y , Inoue Y , Hirata Y . Mixing performance by reciprocating disk in cylindrical vessel [J]. Journal of Chemical Engineering of Japan , 2000 , 33 ( 6 ): 879 - 885 .

Komoda Y , Inoue Y , Hirata Y . Characteristics of laminar flow induced by reciprocating disk in cylindrical vessel [J]. Journal of Chemical Engineering of Japan , 2001 , 34 ( 7 ): 919 - 928 .

Komoda Y , Inoue Y , Hirata Y . Characteristics of turbulent flow induced by reciprocating disk in cylindrical vessel [J]. Journal of Chemical Engineering of Japan , 2001 , 34 ( 7 ): 929 - 935 .

Lamberto D J , Muzzio F J , Swanson P D . Using time dependent R/MIN to enhance mixing in stirred vessels [J]. Chemical Engineering Science , 1996 , 51 ( 5 ): 733 - 741 .

Lamberto D J , Alvarez M M , Muzzio F J . Computational analysis of regular and chaotic mixing in a stirred tank reactor [J]. Chemical Engineering Science , 2001 , 56 : 4887 - 4899 .

Arratia P E , Kukura J , Lacombe J , et al . Mixing of shear thinning fluids with yield stress in stirred tanks [J]. American Institute of Chemical Engineers Journal , 2006 , 52 ( 7 ): 2310 - 2322 .

Alvarez M M . Using spatio-temporal asymmetry to enhance mixing in chaotic flows: from maps to stirred tanks [D]. Piscataway : Rutgers University , 2000 .

Alvarez M M , Arratia P E , Muzzio F J . Laminar mixing in eccentric stirred tank systems [J]. Canadian Journal of Chemical Engineering , 2002 , 80 ( 4 ): 546 - 557 .

Karcz J , Cudak M , Szoplik J . Stirring of a liquid in a stirred tank with an eccentrically located impeller [J]. Chemical Engineering Science , 2005 , 60 : 2369 - 2380 .

Bouremel Y , Yianneskis M , Ducci A . Three-dimensional deformation dynamics of trailing vortex structures in a stirred vessel [J]. Industrial & Engineering Chemistry Research , 2009 , 48 ( 17 ): 8148 - 8158 .

Li Z P , Hu M T , Bao Y Y , et al . Particle image velocimetry experiments and large eddy simulations of merging flow characteristics in dual rushton turbine stirred tanks [J]. Industrial & Engineering Chemistry Research , 2012 , 51 ( 5 ): 2438 - 2450 .

刘作华 , 唐巧 , 王运东 , 等 . 刚柔组合搅拌桨增强混合澄清槽内流体宏观不稳定性 [J]. 化工学报 , 2014 , 65 ( 1 ): 78 - 86 .

Liu Z H , Tang Q , Wang Y D , et al . Enhancement of macro-instability in mixer-settler with rigid-flexible impeller [J]. CIESC Journal , 2014 , 65 ( 1 ): 78 - 86 .

刘作华 , 孙瑞祥 , 王运东 , 等 . 刚-柔组合搅拌桨强化流体混沌混合 [J]. 化工学报 , 2014 , 65 ( 9 ): 3340 - 3349 .

Liu Z H , Sun R X , Wang Y D , et al . Chaotic mixing intensified by rigid-flexible coupling impeller [J]. CIESC Journal , 2014 , 65 ( 9 ): 3340 - 3349 .

Liu Z H , Zheng X P , Liu D , et al . Enhancement of liquid-liquid mixing in a mixer-settler by a double rigid-flexible combination impeller [J]. Chemical Engineering and Processing: Process Intensification , 2014 , 86 : 69 - 77 .

刘作华 , 陈超 , 刘仁龙 , 等 . 刚柔组合搅拌桨强化搅拌槽中流体混沌混合 [J]. 化工学报 , 2014 , 65 ( 1 ): 61 - 70 .

Liu Z H , Chen C , Liu R L , et al . Chaotic mixing enhanced by rigid-flexible impeller in stirred vessel [J]. CIESC Journal , 2014 , 65 ( 1 ): 61 - 70 .

刘作华 , 曾启琴 , 杨鲜艳 , 等 . 刚柔组合搅拌桨与刚性桨调控流场结构的对比 [J]. 化工学报 , 2014 , 65 ( 6 ): 2078 - 2084 .

Liu Z H , Zeng Q Q , Yang X Y , et al . Flow field structure with rigid-flexible impeller and rigid impeller [J]. CIESC Journal , 2014 , 65 ( 6 ): 2078 - 2084 .

刘作华 , 杨鲜艳 , 谢昭明 , 等 . 柔性桨与自浮颗粒协同强化高黏度流体混沌混合 [J]. 化工学报 , 2013 , 64 ( 8 ): 2794 - 2800 .

Liu Z H , Yang X Y , Xie Z M , et al . Chaotic mixing performance of high-viscosity fluid synergistically intensified by flexible impeller and floating particles [J]. CIESC Journal , 2013 , 64 ( 8 ): 2794 - 2800 .

刘作华 , 许传林 , 何木川 , 等 . 穿流式刚柔组合搅拌桨强化混合澄清槽内油水两相混沌混合 [J]. 化工学报 , 2017 , 68 ( 2 ): 637 - 642 .

Liu Z H , Xu C L , He M C , et al . Oil-water biphase chaotic mixing enhanced by punched rigid-flexible combination impeller in mixer-settler [J]. CIESC Journal , 2017 , 68 ( 2 ): 637 - 642 .

吴雨馨 , 唐巧 , 张姬一哲 , 等 . 混合澄清槽混合与澄清特性的规律研究 [J]. 化工学报 , 2019 , 70 ( 10 ): 3932 - 3940 .

Wu Y X , Tang Q , Zhang J Y Z , et al . Study on mixing and settling characteristics in mixer-settler [J]. CIESC Journal , 2019 , 70 ( 10 ): 3932 - 3940 .

Tang Q , Zhang J , Wu Y , et al . An experimental study of immiscible liquid-liquid dispersions in a pump-mixer of mixer-settler [J]. Chinese Journal of Chemical Engineering , 2020 , 28 ( 1 ): 33 - 45 .

Tang Q , Ye S , Wang Y , et al . A study on liquid-liquid dispersions in a continuous mixer via computational fluid dynamics (CFD) simulation combined with population balance model (PBM) [J]. The Canadian Journal of Chemical Engineering , 2019 , 97 ( 2 ): 452 - 464 .

刘作华 , 王闯 , 陶长元 , 等 . 一种新型弹性搅拌桨搅拌反应器 : 108452758 A [P]. 2018 .

Liu Z H , Wang C , Tao C Y , et al . A new type of stirred reactor with elastic impeller : 108452758 A [P]. 2018 .

刘仁龙 , 李爽 , 刘作华 , 等 . 穿流-柔性组合桨强化搅拌槽中流体混沌混合特性 [J]. 化工学报 , 2015 , 66 ( 12 ): 4736 - 4742 .

Liu R L , Li S , Liu Z H , et al . Chaotic mixing enhanced by punched-flexible impeller in stirred vessel [J]. CIESC Journal , 2015 , 66 ( 12 ): 4736 - 4742 .

Li L , Wei J . Three-dimensional image analysis of mixing in stirred vessels [J]. American Institute of Chemical Engineers Journal , 1999 , 45 ( 9 ): 1855 - 1865 .

Packard N H , Crutchfield J P , Farmer J D , et al . Geometry from a time series [J]. Physical Review Letters , 1980 , 45 ( 9 ): 712 - 716 .

Eastwood C D , Armi L , Lasheras J C . The breakup of immiscible fluids in turbulent flows [J]. Journal of Fluid Mechanics , 2004 , 502 : 309 - 333 .

Daglas D , Stamatoudis M . Effect of impeller vertical position on drop sizes in agitated dispersions [J]. Chemical Engineering & Technology: Industrial Chemistry-Plant Equipment-Process Engineering-Biotechnology , 2000 , 23 ( 5 ): 437 - 440 .

Sechremeli D , Stampouli A , Stamatoudis M . Comparison of mean drop sizes and drop size distributions in agitated liquid-liquid dispersions produced by disk and open type impellers [J]. Chemical Engineering Journal , 2006 , 117 ( 2 ): 117 - 122 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Oil-water biphase chaotic mixing enhanced by punched rigid-flexible combination impeller in mixer-settler

Enhancement of macro-instability in mixer-settler with rigid-flexible impeller

Experimental study of particle motion and heat transfer in externally heated rotary kiln

Enhanced fluid chaotic mixing and heat transfer with vibrating blade coupled with flexible plate

Mixing behavior of pseudoplastic fluid in a fractal perforated impeller stirred tank

Related Author

LIU Zuohua

XU Chuanlin

HE Muchuan

GU Deyin

XU Huiqin

HE Haixian

TAO Changyuan

WANG Yundong

Related Institution

State Key Laboratory of Chemical Engineering, Department of Chemical Engineering, Tsinghua University

School of Energy and Power Engineering, Jiangsu University

Jiangsu Engineering Research Center for Intelligent Equipment of Advanced Powder Materials Handling

School of Energy and Environmental Engineering, Hebei University of Technology

Hebei Key Laboratory of Thermal Science and Energy Clean Utilization

⁰