Release and transformation characteristics of chlorine, sulfur and AAEMs during cornstalk torrefaction

JIANG Hao; ZHU Youjian; LIU Heng; SHAO Jing'ai; CHENG Wei; YANG Peng; WU Guihao; YANG Haiping; CHEN Hanping

doi:10.11949/0438-1157.20200628

您当前的位置：

首页 >

文章列表页 >

Release and transformation characteristics of chlorine, sulfur and AAEMs during cornstalk torrefaction

Energy and environmental engineering | 更新时间：2026-07-24

- Release and transformation characteristics of chlorine, sulfur and AAEMs during cornstalk torrefaction
- CIESC Journal Vol. 71, Issue 12, Pages: 5785-5792(2020)
- 作者机构：
  
  1.华中科技大学能源与动力工程学院煤燃烧国家重点实验室，湖北武汉 430074
  2.华中科技大学中欧清洁与可再生能源学院，湖北武汉 430074
  3.郑州轻工业大学能源与动力工程学院，河南郑州 450002
  4.华中科技大学能源与动力工程学院新能源科学与工程系，湖北武汉 430074
- 作者简介：
- 基金信息：
- DOI：10.11949/0438-1157.20200628
  CLC： TK 6
- Received：22 May 2020，
  
  Revised：2020-08-05，
  
  Online First：17 December 2020，
  
  Published：05 December 2020
- 稿件说明：
移动端阅览
蒋好, 朱有健, 刘恒, 邵敬爱, 成伟, 杨鹏, 吴贵豪, 杨海平, 陈汉平. 秸秆烘焙过程氯、硫释放及AAEMs迁徙转化特性研究[J]. 化工学报, 2020, 71(12): 5785-5792

JIANG Hao, ZHU Youjian, LIU Heng, SHAO Jing’ai, CHENG Wei, YANG Peng, WU Guihao, YANG Haiping, CHEN Hanping. Release and transformation characteristics of chlorine, sulfur and AAEMs during cornstalk torrefaction[J]. CIESC Journal, 2020, 71(12): 5785-5792
蒋好, 朱有健, 刘恒, 邵敬爱, 成伟, 杨鹏, 吴贵豪, 杨海平, 陈汉平. 秸秆烘焙过程氯、硫释放及AAEMs迁徙转化特性研究[J]. 化工学报, 2020, 71(12): 5785-5792 DOI： 10.11949/0438-1157.20200628.

JIANG Hao, ZHU Youjian, LIU Heng, SHAO Jing’ai, CHENG Wei, YANG Peng, WU Guihao, YANG Haiping, CHEN Hanping. Release and transformation characteristics of chlorine, sulfur and AAEMs during cornstalk torrefaction[J]. CIESC Journal, 2020, 71(12): 5785-5792 DOI： 10.11949/0438-1157.20200628.

摘要

利用固定床管式炉研究了玉米秆中氯、硫、碱及碱土金属（AAEMs）在不同烘焙温度下的释放和迁徙转化规律。研究发现氯、硫的释放率随烘焙温度升高呈递增趋势，在220~300℃范围内氯和硫的释放率分别为10%~40%和27%~60%。烘焙后样品中氯的绝对含量相比原样有所增加，并且以碱金属氯化物形式存在的无机氯占比减少，有机氯占比增加；硫的绝对含量显著降低，烘焙后可达到Ⅰ级成型燃料中硫含量要求。AAEMs在烘焙过程中释放率均较低，但赋存形态发生一定变化，主要表现为水溶性AAEMs含量降低，有机结合态AAEMs含量增加，此外盐酸酸溶性和不溶性Ca、Mg的占比也有一定程度增加。

Abstract

A fixed-bed tube furnace was used to study the release and migration and transformation of chlorine

sulfur

alkali and alkaline earth metals (AAEMs) in corn stalks at different baking temperatures. It was found that the release ratios of chlorine and sulfur

which increased continuously with temperature in the range of 220—300℃

were 10%—40% and 27%—60%

respectively. However

the absolute content of chlorine increased after torrefaction with the decreased ratio of alkali metal chloride and increased ratio of organochlorine (C—Cl). The absolute content of sulfur decreased significantly after torrefaction

meeting the sulfur requirement of commercial biomass pellets. In addition

the proportion of acid-soluble and insoluble Ca and Mg in hydrochloric acid also increased to a certain extent.

关键词

Keywords

references

Goyal H B, Seal D, Saxena R C. Bio-fuels from thermochemical conversion of renewable resources: a review[J ] . Renewable and Sustainable Energy Reviews, 2008, 12 (2): 504-517.

Chen X, Che Q, Li S, et al. Recent developments in lignocellulosic biomass catalytic fast pyrolysis: strategies for the optimization of bio-oil quality and yield[J ] . Fuel Processing Technology, 2019, 196 : 106180.

Keipi T, Tolvanen H, Kokko L, et al. The effect of torrefaction on the chlorine content and heating value of eight woody biomass samples[J ] . Biomass and Bioenergy, 2014, 66 : 232-239.

陈应泉, 杨海平, 朱波, 等. 农业秸秆烘焙特性及对其产物能源特性的影响[J ] . 农业机械学报, 2012, 43 (4): 75-82.

Chen Y Q, Yang H P, Zhu B, et al. Torrefaction of agriculture straw and its effect on material and energy characteristics[J ] . Transactions of the Chinese Society for Agricultural Machinery, 2012, 43 (4): 75-82.

Vassilev S V, Baxter D, Andersen L K, et al. An overview of the organic and inorganic phase composition of biomass[J ] . Fuel, 2012, 94 : 1-33.

杜胜磊, 陈汉平, 杨海平, 等. 生物质热解过程中F和Cl的迁徙行为研究[J ] . 中国电机工程学报, 2010, 30 (14): 115-120.

Du S L, Chen H P, Yang H P, et al. Transformation behavior of F and Cl during biomass pyrolysis[J ] . Proceedings of the CSEE, 2010, 30 (14): 115-120.

Björkman E, Strömberg B. Release of chlorine from biomass at pyrolysis and gasification conditions[J ] . Energy & Fuels, 1997, 11 (5): 1026-1032.

Johansen J M, Jakobsen J G, Frandsen F J, et al. Release of K, Cl, and S during pyrolysis and combustion of high-chlorine biomass[J ] . Energy & Fuels, 2011, 25 (11): 4961-4971.

杜胜磊, 杨海平, 钱柯贞, 等. 生物质热解过程中碱及碱土金属迁徙规律研究[J ] . 中国电机工程学报, 2013, 33 (26): 48-53.

Du S L, Yang H P, Qian K Z, et al. Releasing behavior of alkali and alkaline earth metals during biomass pyrolysis[J ] . Proceedings of the CSEE, 2013, 33 (26): 48-53.

孟晓晓, 孙锐, 袁皓, 等. 不同热解温度下玉米秸秆中碱金属K和Na的释放及半焦中赋存特性[J ] . 化工学报, 2017, 68 (4): 1600-1607.

Meng X X, Sun R, Yuan H, et al. Effect of different pyrolysis temperature on alkali metal K and Na emission and existence in semi-char[J ] . CIESC Journal, 2017, 68 (4): 1600-1607.

叶家铭, 靳熹, 杨金鑫, 等. 生物质热解和燃烧过程中钾的析出迁移特性研究[J ] . 工程热物理学报, 2017, 38 (9): 2033-2037.

Ye J M, Jin X, Yang J X, et al. Study on release and transformation of potassium during pyrolysis and combustion of biomass[J ] . Journal of Engineering Thermophysics, 2017, 38 (9): 2033-2037.

Jensen P A, Frandsen F J, Dam-Johansen K, et al. Experimental investigation of the transformation and release to gas phase of potassium and chlorine during straw pyrolysis[J ] . Energy & Fuels, 2000, 14 (6): 1280-1285.

Sheng C, Azevedo J L T. Estimating the higher heating value of biomass fuels from basic analysis data[J ] . Biomass and Bioenergy, 2005, 28 (5): 499-507.

Yani S, Gao X, Wu H. Emission of inorganic PM10 from the combustion of torrefied biomass under pulverized-fuel conditions[J ] . Energy & Fuels, 2015, 29 (2): 800-807.

Chen H, Chen X, Qiao Z, et al. Release and transformation behavior of Cl during pyrolysis of torrefied rice straw[J ] . Fuel, 2016, 183 : 145-154.

Chen H, Chen X, Qiao Z, et al. Release and transformation characteristics of K and Cl during straw torrefaction and mild pyrolysis[J ] . Fuel, 2016, 167 : 31-39.

Andrea Jordan C, Akay G. Speciation and distribution of alkali, alkali earth metals and major ash forming elements during gasification of fuel cane bagasse[J ] . Fuel, 2012, 91 (1): 253-263.

梅艳阳. 生物质低温脱氧机理及其对热解的影响研究[D]. 武汉: 华中科技大学, 2016.

Mei Y Y. Study on the mechanism of biomass low-temperature deoxygenation and its effect on pyrolysis[D]. Wuhan: Huazhong University of Science and Technology, 2016.

Liu Z, Quek A, Kent Hoekman S, et al. Production of solid biochar fuel from waste biomass by hydrothermal carbonization[J ] . Fuel, 2013, 103 : 943-949.

Knudsen J N, Jensen P A, Lin W G, et al. Sulfur transformations during thermal conversion of herbaceous biomass[J ] . Energy & Fuels, 2004, 18 (3): 810-819.

Wang Y, Wu H, Sarossy Z, et al. Release and transformation of chlorine and potassium during pyrolysis of KCl doped biomass[J ] . Fuel, 2017, 197 : 422-432.

Saleh S B, Flensborg J P, Shoulaifar T K, et al. Release of chlorine and sulfur during biomass torrefaction and pyrolysis[J ] . Energy & Fuels, 2014, 28 (6): 3738-3746.

Tsubouchi N, Saito T, Ohtaka N, et al. Evolution of hydrogen chloride and change in the chlorine functionality during pyrolysis of argonne premium coal samples[J ] . Energy & Fuels, 2012, 27 (1): 87-96.

Tsubouchi N, Saito T, Ohtaka N, et al. Chlorine release during fixed-bed gasification of coal chars with carbon dioxide[J ] . Energy & Fuels, 2013, 27 (9): 5076-5082.

谢敏, 程健, 陈刚, 等. 橄榄废弃物低温热解过程中氯的析出规律[J ] . 化工学报, 2018, 69 (8): 3693-3700.

Xie M, Cheng J, Chen G, et al. Chlorine release during low-temperature pyrolysis of olive residue[J ] . CIESC Journal, 2018, 69 (8): 3693-3700.

Knudsen J N, Jensen P A, Dam-Johansen K. Transformation and release to the gas phase of Cl, K, and S during combustion of annual biomass[J ] . Energy & Fuels, 2004, 18 (5): 1385-1399.

Liu S, Qiao Y, Lu Z, et al. Release and transformation of sodium in kitchen waste during torrefaction[J ] . Energy & Fuels, 2014, 28 (3): 1911-1917.

van Lith S C, Jensen P A, Frandsen F J, et al. Release to the gas phase of inorganic elements during wood combustion(Part 2): Influence of fuel composition[J ] . Energy & Fuels, 2008, 22 (3): 1598-1609.

Jiang L, Hu S, Xiang J, et al. Release characteristics of alkali and alkaline earth metallic species during biomass pyrolysis and steam gasification process[J ] . Bioresource Technology, 2012, 116 : 278-284.

郭飞强, 刘元, 郭成龙, 等. 微型流化床内碱金属和碱土金属对稻壳热解动力学的影响特性[J ] . 化工学报, 2017, 68 (10): 3795-3804.

Guo F Q, Liu Y, Guo C L, et al. Influence of AAEM on kinetic characteristics of rice husk pyrolysis in micro-fluidized bed reactor[J ] . CIESC Journal, 2017, 68 (10): 3795-3804.

Wang Z, Wang L, Lin J, et al. The influence of the addition of sodium on the transformation of alkali and alkaline-earth metals during oxy-fuel combustion[J ] . Journal of the Energy Institute, 2018, 91 (4): 502-512.

Shoulaifar T K, Demartini N, Zevenhoven M, et al. Ash-forming matter in torrefied birch wood: changes in chemical association[J ] . Energy & Fuels, 2013, 27 (10): 5684-5690.

Aho M, Ferrer E. Importance of coal ash composition in protecting the boiler against chlorine deposition during combustion of chlorine-rich biomass[J ] . Fuel, 2005, 84 (2): 201-212.

赵辉, 周劲松, 曹小伟, 等. 生物质烘焙预处理对气流床气化的影响[J ] . 太阳能学报, 2008, 29 (12): 1578-1586.

Zhao H, Zhou J S, Cao X W, et al. Torrefaction impact on biomass entrained flow gasification[J ] . Acta Energiae Solaris Sinica, 2008, 29 (12): 1578-1586.

杜一帆. 非惰性气氛烘焙稻壳与煤的混燃特性研究[D]. 武汉: 华中科技大学, 2017.

Du Y F. Investigation of co-combustion characteristics of non-inert torrefied rice husk and coal[D]. Wuhan: Huazhong University of Science and Technology, 2017.

Liu Z, Hu W, Jiang Z, et al. Investigating combustion behaviors of bamboo, torrefied bamboo, coal and their respective blends by thermogravimetric analysis[J ] . Renewable Energy, 2016, 87 : 346-352.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Effects of torrefaction with flue gas on grindability of corn stalk

Effects of the addition of NH4H2PO4 in corn stalk on torrefaction and PM emissions in fixed bed combustion

Effect of calcium phosphate monobasic on ash fusion and sintering characteristics of cornstalk

Preparation of mechanically activated starch-based composite hydrogel for controlled release of urea

Exothermic characteristics of energy carrier for calcium looping thermo-chemical energy storage

Related Author

LIU Fangqi

YU Xin

HAN Jingkun

LI Jiayi

YU Dunxi

WANG Shaozhuang

CHEN Hanping

YANG Haiping

Related Institution

State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology

State Pipe Network Group Southwest Pipeline Co. Ltd. Guizhou Pipe Network Co. Ltd.

EU Institute for Clean and Renewable Energy, Huazhong University of Science & Technology

State Key Laboratory of Coal Combustion, School of Energy and Power Engineering, Huazhong University of Science & Technology

Energy and Power Engineering Institute, Zhengzhou University of Light Industry

⁰