CoTPP-TBAB catalyzed tandem transformation of styrene carbonate from styrene in the presence of O<sub>2</sub> and CO<sub>2</sub>

CHEN Yaju; LIANG Zhongxiu; ZHOU Xiantai; JI Hongbing

doi:10.11949/0438-1157.20200248

您当前的位置：

首页 >

文章列表页 >

CoTPP-TBAB catalyzed tandem transformation of styrene carbonate from styrene in the presence of O₂ and CO₂

Celebration Column for School of Chemistry and Chemical Engineering\, Nanjing University | 更新时间：2026-07-24

- CoTPP-TBAB catalyzed tandem transformation of styrene carbonate from styrene in the presence of O₂ and CO₂
- CIESC Journal Vol. 71, Issue 11, Pages: 4981-4989(2020)
- 作者机构：
  
  1.广东石油化工学院化学学院，广东茂名 525000
  2.中山大学化学学院精细化工研究院，广东广州 510275
- 作者简介：
- 基金信息：
- DOI：10.11949/0438-1157.20200248
  CLC： O 643
- Received：11 March 2020，
  
  Revised：2020-05-18，
  
  Online First：03 November 2020，
  
  Published：05 November 2020
- 稿件说明：
移动端阅览
陈亚举, 梁中秀, 周贤太, 纪红兵. 钴卟啉-四丁基溴化铵串联催化苯乙烯在氧气和二氧化碳中合成碳酸苯乙烯酯[J]. 化工学报, 2020, 71(11): 4981-4989

CHEN Yaju, LIANG Zhongxiu, ZHOU Xiantai, JI Hongbing. CoTPP-TBAB catalyzed tandem transformation of styrene carbonate from styrene in the presence of O₂ and CO₂[J]. CIESC Journal, 2020, 71(11): 4981-4989 DOI: 10.11949/0438-1157.20200248.
陈亚举, 梁中秀, 周贤太, 纪红兵. 钴卟啉-四丁基溴化铵串联催化苯乙烯在氧气和二氧化碳中合成碳酸苯乙烯酯[J]. 化工学报, 2020, 71(11): 4981-4989 DOI： 10.11949/0438-1157.20200248.

CHEN Yaju, LIANG Zhongxiu, ZHOU Xiantai, JI Hongbing. CoTPP-TBAB catalyzed tandem transformation of styrene carbonate from styrene in the presence of O₂ and CO₂[J]. CIESC Journal, 2020, 71(11): 4981-4989 DOI: 10.11949/0438-1157.20200248. DOI：

摘要

通过仿生催化，将苯乙烯、氧气（O

）和二氧化碳（CO

）直接合成环状碳酸酯在现代化学中极具学术研究意义和工业应用价值。采用钴卟啉-四丁基溴化铵为双组分催化剂，以2-氧代环戊烷羧酸甲酯为助剂，在O

和CO

条件下，直接将苯乙烯转化为碳酸苯乙烯酯。系统考察了催化剂用量等因素对催化性能的影响。在最佳反应条件下，苯乙烯的转化率高达99%，环状碳酸酯的收率可达35%。利用在线紫外与在线红外探讨了该串联反应可能的机理。结果表明，钴中心与2-氧代环戊烷羧酸甲酯的环内氧原子配位后活化氧气形成过氧活性物种，进而形成高价钴-氧中间体，其通过传递氧原子给苯乙烯而生成环氧苯乙烷。而后，环氧苯乙烷在四丁基溴化铵的催化作用下开环，并通过CO

插入反应和分子内闭环反应最终生成环状碳酸酯。

Abstract

The direct synthesis cyclic carbonate from styrene

and CO

is of great academic attraction and industrial value in modern chemistry. The metalloporphyrin/tetrabutylammonium bromide was employed as binary catalyst for this reaction in the presence of O

and CO

by using methyl 2-cyclopentanone-carboxylate as co-catalysts. The effects of reaction parameters on catalytic performance were investigated systematically. Under the optimal reaction conditions

conversion of styrene (99%) and selectivity to cyclic carbonate (35%) were obtained. The possible mechanism of cascade reaction was proposed by using

situ

ultraviolet and infrared spectroscopy. The results show that the cobalt center is coordinated with the ring oxygen atom of methyl 2-oxocyclopentanecarboxylate to activate oxygen to form a peroxy active species

thereby forming a high-valent cobalt-oxygen intermediate

which passes oxygen atoms to styrene and generate epoxy styrene. Then

styrene oxide opened ring under the catalysis of tetrabutylammonium bromide

and finally formed cyclic carbonate through CO

insertion reaction and intramolecular ring-closing reaction.

关键词

Keywords

references

Rahman F A , Aziz M M A , Saidur R , et al . Pollution to solution: capture and sequestration of carbon dioxide (CO 2 ) and its utilization as a renewable energy source for a sustainable future [J ] . Renew. Sust. Energy Rev. , 2017 , 71 : 112 - 126 .

Appel A M , Bercaw J E , Bocarsly A B , et al . Frontiers, opportunities, and challenges in biochemical and chemical catalysis of CO 2 fixation [J ] . Chem. Rev. , 2013 , 113 ( 8 ): 6621 - 6658 .

Tapia J F D , Lee J Y , Ooi R E H , et al . A review of optimization and decision-making models for the planning of CO 2 capture, utilization and storage (CCUS) systems [J ] . Sustainable Production Consumption , 2018 , 13 : 1 - 15 .

Dowell N M , Fennell P S , Shah N , et al . The role of CO 2 capture and utilization in mitigating climate change [J ] . Nat. Clim. Change , 2017 , 7 ( 4 ): 243 - 249 .

He M Y , Sun Y H , Han B X . Green carbon science: scientific basis for integrating carbon resource processing, utilization, and recycling [J ] . Angew. Chem. Int. Ed. , 2013 , 52 ( 37 ): 9620 - 9633 .

Artz J , Muller T E , Thenert K , et al . Sustainable conversion of carbon dioxide: an integrated review of catalysis and life cycle assessment [J ] . Chem. Rev. , 2018 , 118 ( 2 ): 434 - 504 .

Sakakura T , Choi J C , Yasuda H . Transformation of carbon dioxide [J ] . Chem. Rev. , 2007 , 107 ( 6 ): 2365 - 2387 .

Aresta M , Dibenedetto A , Angelini A . Catalysis for the valorization of exhaust carbon: from CO 2 to chemicals, materials, and fuels. Technological use of CO 2 [J ] . Chem. Rev. , 2014 , 114 ( 3 ): 1709 - 1742 .

张文珍 , 张宁 , 郭春晓 , 等 . 二氧化碳参与的环化反应最新研究进展 [J ] . 有机化学 , 2017 , 37 ( 6 ): 1309 - 1321 .

Zhang W Z , Zhang N , Guo C X , et al . Recent progress in the cyclization reactions using carbon dioxide [J ] . Chin. J. Org. Chem. , 2017 , 37 ( 6 ): 1309 - 1321 .

Song Q W , Zhou Z H , He L N . Efficient, selective and sustainable catalysis of carbon dioxide [J ] . Green Chem. , 2017 , 19 ( 16 ): 3707 - 3728 .

Sakakura T , Kohno K . The synthesis of organic carbonates from carbon dioxide [J ] . Chem. Commun. , 2009 , ( 11 ): 1312 - 1330 .

Shaikh R R , Pornpraprom S , D&#x 1001 b3;Elia V. Catalytic strategies for the cycloaddition of pure, diluted and waste CO 2 to epoxides under ambient conditions [J ] . ACS Catal., 2018 , 8 ( 1 ): 419 - 450 .

Schäffner B , Friederike S , Verevkin S P , et al . Organic carbonates as solvents in synthesis and catalysis [J ] . Chem. Rev. , 2010 , 110 ( 8 ): 4554 – 4581 .

Shaikh A G , Sivaram S . Organic carbonates [J ] . Chem. Rev. , 1996 , 96 ( 3 ): 951 - 976 .

North M , Pasquale R , Young C . Synthesis of cyclic carbonates from epoxides and CO 2 [J ] . Green Chem. , 2010 , 12 ( 9 ): 1514 - 1539 .

Liang J , Huang Y B , Cao R . Metal-organic frameworks and porous organic polymers for sustainable fixation of carbon dioxide into cyclic carbonates [J ] . Coord. Chem. Rev. , 2019 , 378 : 32 - 65 .

罗荣昌 , 周贤太 , 杨智 , 等 . 均相体系中酸碱协同催化二氧化碳与环氧化物的环加成反应 [J ] . 化工学报 , 2016 , 67 ( 1 ): 258 - 276 .

Luo R C , Zhou X T , Yang Z , et al . Acid-base synergistic effect promoted cycloaddition reaction from CO 2 with epoxide in homogenous catalysis systems [J ] . CIESC Journal , 2016 , 67 ( 1 ): 258 - 276 .

Liu J , Yang G Q , Liu Y , et al . Metal-free imidazolium hydrogen carbonate ionic liquids as bifunctional catalysts for the one-pot synthesis of cyclic carbonates from olefins and CO 2 [J ] . Green Chem. , 2019 , 21 ( 14 ): 3834 - 3838 .

Sun J , Fujita S , Bhanage B M , et al . One-pot synthesis of styrene carbonate from styrene in tetrabutylammonium bromide [J ] . Catal. Today , 2004 , 93-95 : 383 - 388 .

Sun J , Fujita S , Bhanage B M , et al . Direct oxidative carboxylation of styrene to styrene carbonate in the presence of ionic liquids [J ] . Catal. Commun. , 2004 , 5 ( 2 ): 83 - 87 .

Sun J M , Fujita S , Zhao F Y , et al . A direct synthesis of styrene carbonate from styrene with the Au/SiO 2 ZnBr 2 /Bu 4 NBr catalyst system [J ] . J. Catal. , 2005 , 230 ( 2 ): 398 - 405 .

孙建敏 , 王路 , 王亚丽 , 等 . 溴化锌-卤化正四丁基铵高效催化合成苯乙烯环状碳酸酯 [J ] . 高等学校化学学报 , 2007 , 28 ( 3 ): 502 - 505 .

Sun J M , Wang L , Wang Y L , et al . Synthesis of styrene carbonate catalyzed by efficiently by zinc bromide and tetra- n -butylammonium halides [J ] . Chem. J. Chin. Univ. , 2007 , 28 ( 3 ): 502 - 505 .

Wang Y L , Sun J H , Xiang D , et al . A facile, direct synthesis of styrene carbonate from styrene and CO 2 catalyzed by Au/Fe(OH) 3 -ZnBr 2 /Bu 4 NBr system [J ] . Catal. Lett. , 2009 , 129 ( 3/4 ): 437 - 443 .

Xiang D , Liu X F , Sun J S , et al . A novel route for synthesis of styrene carbonate using styrene and CO 2 as substrates over basic resin R201 supported Au catalyst [J ] . Catal. Today , 2009 , 148 ( 3/4 ): 383 - 388 .

Han Q X , Qi B , Ren W M , et al . Polyoxometalate-based homochiral metal-organic frameworks for tandem asymmetric transformation of cyclic carbonates from olefins [J ] . Nat.Commun. , 2015 , 6 : 10007 - 10014 .

Ono F , Qiao K , Tomida D , et al . Direct preparation of styrene carbonates from styrene using an ionic-liquid-based one-pot multistep synthetic process [J ] . Appl. Catal. A , 2007 , 333 ( 1 ): 107 - 113 .

Eghbali N , Li C J . Conversion of carbon dioxide and olefins into cyclic carbonates in water [J ] . Green Chem. , 2007 , 9 ( 3 ): 213 - 215 .

Zou B , Hu C W . Synthesis of cyclic carbonates from alkenyl and alkynyl substrates [J ] . Chin. J. Chem. , 2017 , 35 ( 5 ): 541 - 550 .

Mukherjee A . Biomimetics, Learning from Nature [M ] . Vukovar : IntechOpen , 2010 .

Que L J , Tolman W B . Biologically inspired oxidation catalysis [J ] . Nature , 2008 , 455 : 333 - 340 .

Pereira M M , Dias L D , Calvete M J F . Metalloporphyrins: bioinspired oxidation catalysts [J ] . ACS Catal. , 2018 , 8 ( 11 ): 10784 - 10808 .

周贤太 , 纪红兵 . 金属卟啉仿生催化氧化合成有机化工产品 [J ] . 精细化工 , 2013 , 30 ( 4 ): 425 - 432 .

Zhou X T , Ji H B . synthesis of organic chemical products by metalloporphyrins-based biomimetic catalytic oxidation [J ] . Fine Chem. , 2013 , 30 ( 4 ): 425 - 432 .

Zhou X T , Ji H B . Biomimetic kinetics and mechanism of cyclohexene epoxidation catalyzed by metalloporphyrins [J ] . Chem. Eng. J. , 2010 , 156 ( 2 ): 411 - 417 .

Zhou X T , Tang Q H , Ji H B . Remarkable enhancement of aerobic epoxidation reactivity for olefins catalyzed by μ-oxo-bisiron(III) porphyrins under ambient conditions [J ] . Tetrahedron Lett. , 2009 , 50 ( 47 ): 6601 - 6605 .

Schroder K , Join B , Amali A J , et al . A biomimetic iron catalyst for the epoxidation of olefins with molecular oxygen at room temperature [J ] . Angew. Chem. Int. Ed. , 2011 , 50 ( 6 ): 1425 - 1429 .

Rocha C C , Onfroy T , Launay F . Towards a combined use of Mn(Salen) and quaternary ammonium salts as catalysts for the direct conversion of styrene to styrene carbonate in the presence of dioxygen and carbon dioxide [J ] . Comptes Rendus Chimie , 2015 , 18 ( 3 ): 270 - 276 .

Niño M E , Giraldo S A , Páez-Mozo E A . Olefin oxidation with dioxygen catalyzed by porphyrins and phthalocyanines intercalated in α-zirconium phosphat [J ] . J . Mol. Catal. A-Chem. , 2001 , 175 ( 1/2 ): 139 - 151 .

Luo R C , Zhou X T , Zhang W Y , et al . New bi-functional zinc catalysts based on robust and easy-to-handle N-chelating ligands for the synthesis of cyclic carbonates from epoxides and CO 2 under mild conditions [J ] . Green Chem. , 2014 , 16 ( 9 ): 4179 - 4189 .

D'Elia V , Ghani A A , Monassier A , et al . Dynamics of the NbCl 5 -catalyzed cycloaddition of propylene oxide and CO 2 : assessing the dual role of the nucleophilic Co-catalysts [J ] . Chem. Eur. J. , 2014 , 20 ( 37 ): 11870 - 11882 .

Punniyamurthy T , Bhatia B , Reddy M M , et al . A versatile cobalt(Ⅱ)-Schiff base catalyzed oxidation of organic substrates with dioxygen: scope and mechanism [J ] . Tetrahedron , 1997 , 53 ( 22 ): 7649 - 7670 .

Yang Z Z , Zhao Y N , He L N . CO 2 chemistry: task-specific ionic liquids for CO 2 capture/activation and subsequent conversion [J ] . RSC Adv. , 2011 , 1 ( 4 ): 545 - 567 .

Chen Y J , Luo R C , Bao J H , et al . Function-oriented ionic polymers having high-density active sites for sustainable carbon dioxide conversion [J ] . J. Mater. Chem. A , 2018 , 6 ( 19 ): 9172 - 9182 .

Chen Y J , Luo R C , Xu Q H , et al . Charged metalloporphyrin polymers for cooperative synthesis of cyclic carbonates from CO 2 under ambient conditions [J ] . ChemSusChem , 2017 , 10 ( 11 ): 2534 - 2541 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Study on the photocatalytic oxidative dehydrogenation of ethane with CO2 over Pd-Rh /TiO2 catalyst

The CO2 adsorption performance under flue gas for TEPA-impregnated composited oxidized activated carbon

Acid-base synergistic effect promoted cycloaddition reaction from CO2 with epoxide in homogenous catalysis systems

Zn-doped PdO/ZrO2 with rich oxygen vacancies for the synthesis of diphenyl carbonate from CO2 and phenol

Progress in research of selective oxidation of low carbon polyols over nano-Au catalysts with precise electronic effect regulation

Related Author

LI Qianqian

TANG Siyang

YUE Hairong

LIU Changjun

MA Kui

ZHONG Shan

LIANG Bin

WANG Yanxia

Related Institution

School of Chemical Engineering, Sichuan University

Institute of New Energy and Low Carbon Technology, Sichuan University

State Key Laboratory of High-efficiency Utilization of Coal and Green Chemical Engineering, Ningxia University

School of Chemistry and Chemical Engineering, Sun Yat-sen University

State Key Laboratory of Heavy Oil Processing, China University of Petroleum

⁰

CoTPP-TBAB catalyzed tandem transformation of styrene carbonate from styrene in the presence of O2 and CO2

DOI：10.11949/0438-1157.20200248

摘要

Abstract

关键词

Keywords

references

CoTPP-TBAB catalyzed tandem transformation of styrene carbonate from styrene in the presence of O₂ and CO₂