Study on optimal heating power for internally-heated ultrasonic atomization liquid desiccant regeneration system

Hui NI; Zili YANG; Ke ZHONG; Ruiyang TAO; Yuqian GU

doi:10.11949/0438-1157.20190697

您当前的位置：

首页 >

文章列表页 >

Study on optimal heating power for internally-heated ultrasonic atomization liquid desiccant regeneration system

Fluid dynamics and transport phenomena | 更新时间：2020-06-24

- Study on optimal heating power for internally-heated ultrasonic atomization liquid desiccant regeneration system
- CIESC Journal Vol. 71, Issue 3, Pages: 1035-1044(2020)
- 作者机构：
  
  东华大学环境科学与工程学院，上海 201620
- 作者简介：
- 基金信息：
- DOI：10.11949/0438-1157.20190697
  CLC： TU 834.9
- Received：20 June 2019，
  
  Revised：2019-10-21，
  
  Published：05 March 2020
- 稿件说明：
移动端阅览
倪辉, 杨自力, 钟珂, 陶睿杨, 谷雨倩. 内热型超声雾化溶液再生系统最优内热量的研究[J]. 化工学报, 2020, 71(3): 1035-1044

NI Hui, YANG Zili, ZHONG Ke, TAO Ruiyang, GU Yuqian. Study on optimal heating power for internally-heated ultrasonic atomization liquid desiccant regeneration system[J]. CIESC Journal, 2020, 71(3): 1035-1044
倪辉, 杨自力, 钟珂, 陶睿杨, 谷雨倩. 内热型超声雾化溶液再生系统最优内热量的研究[J]. 化工学报, 2020, 71(3): 1035-1044 DOI： 10.11949/0438-1157.20190697.

NI Hui, YANG Zili, ZHONG Ke, TAO Ruiyang, GU Yuqian. Study on optimal heating power for internally-heated ultrasonic atomization liquid desiccant regeneration system[J]. CIESC Journal, 2020, 71(3): 1035-1044 DOI： 10.11949/0438-1157.20190697.

摘要

基于质量守恒、能量守恒定律，建立了内热型超声雾化溶液再生系统（IH-UARS）的再生性能预测模型并进行了充分的实验验证，通过研究不同内热量下IH-UARS的再生性能及其变化规律，寻求系统所需的最佳内热量并明确其可能的影响因素。结果表明：IH-UARS系统存在最优的内热量范围，使其再生系统性能最佳；所需最优内热量随着再生溶液流量增大呈显著的对数增长，但受空气流量的影响较弱；在该研究中的标准工况下，IH-UARS所需最优内热量约为275~350 W。此外研究发现：内热量的增长有益于促进初始浓度较高的溶液进一步浓缩再生，如当IH-UARS中内热量增至800 W时，其初始浓度为36%的溶液比24%的溶液浓度增量指标改善幅度高37%。研究所得结果可对提高溶液再生性能及经济性提供积极参考。

Abstract

Based on the laws of mass conservation and energy conservation

the regeneration performance prediction model of IH-UARS is established and verified by experiments. Besides

experimental runs were conducted to verify the feasibility of the developed model. The results show that there exists an optimal range of internal heating

which makes the regeneration system present the most energy-efficient regeneration. The optimal heating power was found increasing logarithmically with the growth of the flow rate of the desiccant solution but is weakly affected by the flow rate of the scavenging airflow. Under the standard operating conditions of the present study

the optimal heat power for IH-UARS was around 275 to 350 W. Furthermore

it was also found that the internal heating seems to be more beneficial for regenerating the dilute desiccant solution with a higher initial mass fraction. For instance

by increasing the internal heating power to 800 W

the

http://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=11083451&type=

http://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=11083449&type=

10.92199993

4.23333359

of the desiccant solution

with inlet concentration of 36% was better than the desiccant solution with inlet concentration of 24%

with the improvement of

http://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=11083456&type=

http://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=11083454&type=

10.92199993

4.23333359

amplitude reached 37%. The study may help realize the optimal running of the internally-heated desiccant regeneration system.

关键词

Keywords

references

刘晓华 , 张涛 , 江亿 . 采用吸湿剂处理湿空气的流程优化分析 [J]. 暖通空调 , 2011 , 41 ( 3 ): 77 - 87 .

Liu X H , Zhang T , Jiang Y . Optimization of heat and mass transfer processes between desiccant and moist air [J]. Journal of HV&AC , 2011 , 41 ( 3 ): 77 - 87 .

Ahmed H A , Ge G M , Carey J S . Performance analysis of a membrane liquid desiccant air-conditioning system [J]. Energy and Buildings , 2013 , 62 : 559 - 569 .

刘晓华 , 李震 , 张涛 . 溶液除湿 [M]. 北京 : 中国建筑工业出版社 , 2014 : 23 - 89 .

Liu X H , Li Z , Zhang T . Liquid Desiccant Dehumidification [M]. Beijing : China Architecture & Building Press , 2014 : 23 - 89 .

殷勇高 , 潘雄伟 , 陈瑶 , 等 . 顺流型溶液与空气热质交换性能 [J]. 化工学报 , 2012 , 63 : 26 - 31 .

Yin Y G , Pan X W , Chen Y , et al . Heat and mass transfer performance between liquid desiccant and air with parallel flow [J]. CIESC Journal , 2012 , 63 : 26 - 31 .

彭冬根 , 程小松 , 李霜玲 , 等 . 一种新型溶液除湿装置数学模型及性能分析 [J]. 太阳能学报 , 2019 , 40 ( 2 ): 474 - 479 .

Peng D G , Cheng X S , Li S L , et al . Mathematical model and performance analysis of a new liquid desiccant dehumidifer [J]. Acta Energiae Solaris Sinica , 2019 , 40 ( 2 ): 474 - 479 .

Zhang T , Liu X H , Jiang J J , et al . Experimental analysis of an internally-cooled liquid desiccant dehumidifier [J]. Building and Environment , 2013 , 63 : 1 - 10 .

Lun W , Li K N , Liu B , et al . Experimental analysis of a novel internally-cooled dehumidifier with self-cooled liquid desiccant [J]. Building and Environment , 2018 , 141 : 117 - 126 .

常晓敏 , 刘晓华 , 江亿 . 内冷型溶液除湿器的热质交换分析及流型比较研究 [J]. 太阳能学报 , 2009 , 30 ( 2 ): 170 - 176 .

Chang X M , Liu X H , Jiang Y . Research on the heat and mass transfer performance and flow-pattern comparison of the internally-cooled liquid desiccant dehumidifers [J]. Acta Energiae Solaris Sinica , 2009 , 30 ( 2 ): 170 - 176 .

张凡 , 殷勇高 . 一种低位热驱动除湿冷却空调系统的热性能分析 [J]. 化工学报 , 2016 , 67 : 275 - 283 .

Zhang F , Yin Y G . Thermal performance analysis of liquid desiccant evaporative cooling air-condetioning system driven by low-grade heat [J]. CIESC Journal , 2016 , 67 : 275 - 283 .

高文忠 , 柳建华 , 章学来 . 太阳能叉流溶液除湿空调除湿性能实验分析 [J]. 太阳能学报 , 2012 , 33 ( 9 ): 1547 - 1552 .

Gao W Z , Liu J H , Zhang X L . Experimental analysis of dehumidifier in the solar-driven cross-flow liquid desiccant air conditioning [J]. Acta Energiae Solaris Sinica , 2012 , 33 ( 9 ): 1547 - 1552 .

彭冬根 , 罗丹婷 , 程小松 . 热回收型太阳能分级溶液集热/再生系统模型及环境适用性分析 [J]. 化工学报 , 2017 , 68 ( 8 ): 3242 - 3249 .

Peng D G , Luo D T , Cheng X S . Modeling and environmental applicability of solar solution grading collector/regenerator system with heat recovery [J]. CIESC Journal , 2017 , 68 ( 8 ): 3242 - 3249 .

程清 , 张小松 . 一种双级光电光热电渗析再生系统性能研究 [J]. 太阳能学报 , 2015 , 36 ( 8 ): 1890 - 1894 .

Cheng Q , Zhang X S . Performance analysis of double stage PV/T electrodialysis regeneration system [J]. Acta Energiae Solaris Sinica , 2015 , 36 ( 8 ): 1890 - 1894 .

殷勇高 , 潘雄伟 , 陈瑶 , 等 . 热空气用于溶液再生实验研究与能效分析 [J]. 工程热物理学报 , 2013 , 34 ( 4 ): 596 - 600 .

Yin Y G , Pan X W , Chen Y , et al . Experimental study and energy efficiency analysis of liquid desiccant regeneration using hot air [J]. Journal of Engineering Thermophysics , 2013 , 34 ( 4 ): 596 - 600 .

Liu X H , Jiang Y , Chang X M , et al . Experimental investigation of the heat and mass transfer between air and liquid desiccant in a cross-flow regenerator [J]. Renewable Energy , 2007 , 32 ( 10 ): 1623 - 1636 .

Liu X H , Jiang Y , Yi X Q . Effect of regeneration mode on the performance of liquid desiccant packed bed regenerator [J]. Renewable Energy , 2009 , 34 ( 1 ): 209 - 216 .

戴智超 . 不同填料溶液除湿/再生器及热质传递性能研究比较 [D]. 南京 : 东南大学 , 2015 .

Dai Z C . Study on different type of fillers liquid dehumidifer/regenerator and their comparison about heat and mass transfer performance [D]. Nanjing : Southeast University , 2015 .

殷勇高 , 郑宝军 , 高龙飞 , 等 . 一种新的Z型填料及其溶液再生性能 [J]. 化工学报 , 2014 , 65 : 280 - 285 .

Yin Y G , Zheng B J , Gao L F , et al . A novel Z-type packing used for desiccant regenerator [J]. CIESC Journal , 2014 , 65 : 280 - 285 .

钱俊飞 , 殷勇高 , 潘雄伟 , 等 . 平板降膜溶液除湿再生过程实验研究及模型验证 [J]. 化工学报 , 2014 , 65 ( 6 ): 2070 - 2077 .

Qian J F ， Yin Y G , Pan X W , et al . Experimental investigation and model validation for liquid desiccant dehumidification and regeneration in falling-film plate [J]. CIESC Journal , 2014 , 65 ( 6 ): 2070 - 2077 .

姚晔 , 连之伟 , 刘世清 . 超声波强化再生除湿的除湿空调装置 : 200510110441.8 [P]. 2005-11-17 .

Yao Y , Lian Z W , Liu S Q . Ultrasound-atomizing regeneration/ dehumidification for liquid desiccant air conditioning system : 200510110441.8 [P]. 2005-11-17 .

Wang L , Lian Z W . Improvement of conventional liquid desiccant dehumidification technology [J]. Journal of Southeast University , 2010 , 26 ( 2 ): 212 - 216 .

Yao Y , Zhang W J , He B X . Investigation on the kinetic models for the regeneration of silica gel by hot air combined with power ultrasonic [J]. Energy Conversion and Management , 2011 , 52 ( 11 ): 3319 - 3326 .

Yao Y . Research and application of ultrasound in HVAC field: a review [J]. Renewable and Sustainable Energy Reviews , 2016 , 58 : 52 - 68 .

王俐 , 连之伟 , 刘蔚巍 . 结合超声雾化技术的液体除湿系统分析 [J]. 中南大学学报(自然科学版) , 2011 , 42 ( 1 ): 240 - 246 .

Wang L , Lian Z W , Liu W W . Analysis of liquid-desiccant dehumidifying system combined with ultrasound atomization technology [J]. Journal of Central South University (Science and Technology) , 2011 , 42 ( 1 ): 240 - 246 .

Yang Z L , Zhang K S , Hwang Y , et al . Performance investigation on the ultrasonic atomization liquid desiccant regeneration system [J]. Applied Energy , 2016 , 171 : 12 - 25 .

殷勇高 , 李士强 , 张小松 . 绝热型和内热型再生过程热性能对比 [J]. 化工学报 , 2010 , 61 : 157 - 163 .

Yin Y G , Li S Q , Zhang X S . Comparative study on dynamic performance of internally heated and adiabatic regenerators [J]. CIESC Journal , 2010 , 61 : 157 - 163 .

Yin Y G , Zhang X S . Comparative study on internally heated and adiabatic regenerators in liquid desiccant air conditioning system [J]. Building and Environment , 2010 , 45 ( 8 ): 1799 - 1807 .

Yin Y G , Zhang X S , Peng D G , et al . Model validation and case study on internally cooled/heated dehumidifier/regenerator of liquid desiccant systems [J]. International Journal of Thermal Sciences , 2009 , 48 : 1664 - 1671 .

Liu J , Zhang T , Liu X H , et al . Experimental analysis of an internally-cooled/heated liquid desiccant dehumidifier/regenerator made of thermally conductive plastic [J]. Energy and Buildings , 2015 , 99 : 75 - 86 .

王琴 , 吴薇 , 刘松松 . 内热型与绝热型溶液再生器再生过程性能 [J]. 化工学报 , 2016 , 67 : 186 - 194 .

Wang Q , Wu W , Liu S S . Performance of regeneration processes of internally heated and adiabatic regenerators [J]. CIESC Journal , 2016 , 67 : 186 - 194 .

Conde M R . Properties of aqueous solutions of lithium and calcium chlorides: formulations for use in air conditioning equipment design [J]. International Journal of Thermal Sciences , 2004 , 43 ( 4 ): 367 - 382 .

Wen T , Lu L , Yang H , et al . Investigation on the regeneration and corrosion characteristics of an anodized aluminum plate regenerator [J]. Energies , 2018 , 11 ( 5 ): 1209 - 1215 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Influencing factors of air states in liquid desiccant dehumidification systems

Research on prediction of regeneration rate of mine dehumidification solution

Experimental study on a novel waste heat recovery system based on desiccant coated exchanger in data center

CO working capacity and operating conditions of Co-MOF-74 and Mg-MOF-74

Isothermal evaporation salt-forming regions of the ternary water-salt systems K+(Mg2+), Ca2+//Cl--H2O

Related Author

Hongshuo QU

Lun ZHANG

Xiaosong ZHANG

Wenbin JI

HUANG Rongting

TAO Yichun

CHEN Jianglin

LI Shihang

Related Institution

School of Energy and Environment, Southeast University

Technical Support Department of Gerui Smart Human Environment Technology Limited Company

State Key Laboratory of Coal Mine Disaster Prevention and Control, School of Safety Engineering, China University of Mining and Technology

Key Laboratory of Gas and Fire Control for Coal Mines, Ministry of Education， China University of Mining and Technology

National Engineering Research Center for Coal Gas Control, China University of Mining and Technology

⁰