Analysis of influence of carbon fiber structure arrangement on its radiation characteristics

Jinying YIN; Jiangyue HAN; Caihui QI

doi:10.11949/0438-1157.20190610

您当前的位置：

首页 >

文章列表页 >

Analysis of influence of carbon fiber structure arrangement on its radiation characteristics

Material science and engineering, nanotechnology | 更新时间：2020-06-24

- Analysis of influence of carbon fiber structure arrangement on its radiation characteristics
- CIESC Journal Vol. 70, Issue S2, Pages: 356-362(2019)
- 作者机构：
  
  哈尔滨理工大学测控技术与通信工程学院, 黑龙江哈尔滨 150080
- 作者简介：
- 基金信息：
- DOI：10.11949/0438-1157.20190610
  CLC： TK 124
- Received：02 June 2019，
  
  Revised：2019-06-24，
  
  Published：05 September 2019
- 稿件说明：
移动端阅览
殷金英, 韩江月, 祁彩辉. 碳纤维结构排布对其辐射特性影响的分析[J]. 化工学报, 2019, 70(S2): 356-362

YIN Jinying, HAN Jiangyue, QI Caihui. Analysis of influence of carbon fiber structure arrangement on its radiation characteristics[J]. CIESC Journal, 2019, 70(S2): 356-362
殷金英, 韩江月, 祁彩辉. 碳纤维结构排布对其辐射特性影响的分析[J]. 化工学报, 2019, 70(S2): 356-362 DOI： 10.11949/0438-1157.20190610.

YIN Jinying, HAN Jiangyue, QI Caihui. Analysis of influence of carbon fiber structure arrangement on its radiation characteristics[J]. CIESC Journal, 2019, 70(S2): 356-362 DOI： 10.11949/0438-1157.20190610.

摘要

为了研究碳纤维的光谱辐射特性，利用时域有限差分法模拟计算了不同排布方式下的碳纤维辐射特性。结果表明：在2D随机排布方式下等半径碳纤维散射因子随着碳纤维含量的降低而减小，当含量降低17.12%，散射因子的最大值降低35%；在2D随机排布方式下非等半径碳纤维，不仅碳纤维含量对材料辐射特性有影响，碳纤维圆柱体的半径也影响其辐射特性，在2.5～3.5 µm波段同含量下碳纤维根数由26增加至56时散射因子增大20%；而且碳纤维3D随机排布方式和2D随机排布的辐射特性偏差较大，2D排布模型代替3D随机排布模型会使碳纤维吸收截面偏差40%。

Abstract

In order to study the spectral radiation characteristics of carbon fiber

the finite difference time-domain method is used to investigate the radiation characteristics of carbon fiber in different configurations. The results show that the scattering factor of carbon fiber with the same radius in 2D random distribution decreases with the decrease in content of carbon fiber. When the content decreased by 17.12%

the maximum value of the scattering factor is decreased by 35%. Under the 2D random distribution of non-uniform radius carbon fiber

besides of the influence of carbon fiber content on the material’s radiation characteristics

the number of carbon fiber particles with small radius under the same content will increase the scattering factor by 20% in the 2.5—3.5 μm band. Compared with 2D random arrangement

3D random arrangement can significantly enhance the radiation characteristics of carbon fiber.

关键词

Keywords

references

张健 , 揣雪冰 . 碳纤维的发展及其应用现状 [J]. 化工管理 , 2017 , ( 23 ): 60 .

Zhang J , Chuai X B . Development and application status of carbon fiber [J]. Chemical Industry Management , 2017 , ( 23 ): 60 .

王雪娟 . 碳纤维的发展及其应用 [J]. 四川理工学院学报(社会科学版) , 2009 , 24 : 202 - 206 .

Wang X J . Development and application of carbon fiber [J]. Journal of Sichuan University of Science and Technology (Social Science Edition) , 2009 , 24 : 202 - 206 .

Chen T F , Gong W P , Liu G S . Effects of fiber-types on braking behavior of carbon–carbon composites [J]. Materials Science & Engineering A , 2006 , 441 ( 1/2 ): 73 - 78 .

隋志军 , 李平 , 周静红 . 纳米碳纤维的微观结构调控与催化作用 [J]. 化工学报 , 2014 , 65 ( 1 ): 22 - 31 .

Sui Z J , Li P , Zhou J H . Microstructure regulation and catalysis of carbon nanofibers [J]. CIESC Journal , 2014 , 65 ( 1 ): 22 - 31 .

杨连威 , 姚广春 , 王东署 . 碳纤维镀铜及其对铜基复合材料界面影响 [J]. 化工学报 , 2005 , 56 ( 7 ): 1343 - 1348 .

Yang L W , Yao G C , Wang D S . Carbon fiber copper plating and its effect on the interface of copper matrix composites [J]. Journal of Chemical Industry and Engineering (China) , 2005 , 56 ( 7 ): 1343 - 1348 .

Nanni F , Travaglia P , Valentini M . Effect of carbon nanofibres dispersion on the microwave absorbing properties of CNF/epoxy composites [J]. Composites Science and Technology , 2009 , 69 ( 3 ): 485 - 490 .

杨亚政 , 杨嘉陵 , 方岱宁 . 高超声速飞行器热防护材料与结构的研究进展 [J]. 应用数学和力学 , 2008 , 29 ( 1 ): 47 - 56 .

Yang Y Z , Yang J L , Fang D N . Research progress on thermal protection materials and structures of hypersonic aircraft [J]. Applied Mathematics and Mechanics , 2008 , 29 ( 1 ): 47 - 56 .

Li T Q , Xu Z H , Hu Z J , et al . Application of a high thermal conductivity C/C composite in a heat-redistribution thermal protection system [J]. Carbon , 2010 , 48 ( 3 ): 924 - 925 .

黎炎图 , 王超英 , 杜作娟 , 等 . 短切碳纤维电磁散射特性仿真研究 [J]. 计算机仿真 , 2011 , 28 ( 5 ): 139 - 143 .

Li Y T , Wang C Y , Du Z J , et al . Simulation study on electromagnetic scattering characteristics of short-cut carbon fiber [J]. Computer Simulation , 2011 , 28 ( 5 ): 139 - 143 .

王芙愿 . C/SiC复合材料热辐射机制与性能研究 [D]. 西安 : 西北工业大学 , 2015 : 1 - 131 .

Wang F Y . Study on thermal radiation mechanism and properties of C/SiC composites [D]. Xi’an : Northwest Polytechnic University , 2015 : 1 - 131 .

朱波 , 曹伟伟 , 吴益民 . 碳素复合材料热辐射性能的研究进展 [J]. 功能材料 , 2011 , 42 : 586 - 590 .

Zhu B , Cao W W , Wu Y M . Research progress on thermal radiation properties of carbon composites [J]. Functional Materials , 2011 , 42 : 586 - 590 .

武文明 , 成来飞 , 王炜 . 3D C/SiC复合材料的热辐射性能 [J]. 复合材料学报 , 2008 , 25 ( 5 ): 79 - 84 .

Wu W M , Cheng L F , Wang W . Thermal radiation properties of 3D C/SiC composites [J]. Journal of Composites , 2008 , 25 ( 5 ): 79 - 84 .

Davide A , Luigi S , Stefania C , et al . Emissivity and catalycity measurements on SiC-coated carbon fibre reinforced silicon carbide composite [J]. Journal of the European Ceramic Society , 2009 , 29 ( 10 ): 2045 - 2051 .

Guo Z S , Zheng X , Yi L . Absorbing properties and structural design of microwave absorbers based on W-type La-doped ferrite and carbon fiber composites [J]. Journal of Magnetism and Magnetic Materials , 2006 , 301 ( 2 ): 325 - 330 .

Li K Z , Wang C , Li H J , et al . Effect of chemical vapor deposition treatment of carbon fibers on the reflectivity of carbon fiber-reinforced cement-based composites [J]. Composites Science and Technology , 2008 , 68 ( 5 ): 1105 - 1114 .

李丁 . 碳纤维热扩散率测量方法与实验研究 [D]. 青岛 : 青岛理工大学 , 2015 : 1 - 54 .

Li D . Measurement method and experimental research on thermal diffusivity of carbon fiber [D]. Qingdao : Qingdao University of Technology , 2015 : 1 - 54 .

胡玉东 , 刘锦辉 , 王海东 . 拉曼方法同时测量单根碳纤维热物性和对流传热系数 [J]. 化工学报 , 2014 , 65 ( S1 ): 251 - 257 .

Hu Y D , Liu J H , Wang H D . Measurement of thermophysical properties and convective heat transfer coefficient of single carbon fiber by Raman method [J]. CIESC Journal , 2014 , 65 ( S1 ): 251 - 257 .

曹伟伟 , 朱波 , 王成国 . 排布特征对碳素纤维红外发射率性能的影响 [J]. 功能材料 , 2010 , 41 ( 3 ): 379 - 381 .

Cao W W , Zhu B , Wang C G . Effect of arrangement characteristics on infrared emission energy of carbon fiber [J]. Functional Materials , 2010 , 41 ( 3 ): 379 - 381 .

Balat-Pichelin M , Robert J F , Sans J L . Emissivity measurements on carbon–carbon composites at high temperature under high vacuum [J]. Applied Surface Science , 2006 , 253 ( 2 ): 778 - 783 .

Lee S C . Near field scattering by closely spaced infinite cylinders in an absorbing medium [J]. Journal of Quantitative Spectroscopy and Radiative Transfer , 2012 , 113 ( 18 ): 2379 - 2384 .

Lee S C . Near field scattering by multiple infinite cylinders in an absorbing medium at oblique incidence [J]. Journal of Quantitative Spectroscopy and Radiative Transfer , 2013 , 114 : 65 - 72 .

杨柳 , 谢鸣 , 艾青 . 碳纤维结构对其辐射光谱性质的影响研究 [J]. 工程热物理学报 , 2015 , 36 ( 12 ): 2721 - 2725 .

Yang L , Xie M , Ai Q . Study on the influence of carbon fiber structure on its radiation spectral properties [J]. Journal of Engineering Thermophysics , 2015 , 36 ( 12 ): 2721 - 2725 .

李悦 . 基于蒙特卡洛法分析纤维编织结构对辐射特性的影响 [D]. 哈尔滨 : 哈尔滨工业大学 , 2016 : 8 - 49 .

Li Y . Monte Carlo method based analysis of the influence of fiber braided structure on radiation characteristics [D]. Harbin : Harbin Institute of Technology , 2016 : 8 - 49 .

张萍 , 张永忠 , 尹法章 , 等 . 碳纤维增强镁基复合材料的制备及微观结构分析 [J]. 有色金属 , 2011 , 63 ( 1 ): 19 - 22 .

Zhang P , Zhang Y Z , Yin F Z , et al . Preparation and microstructure analysis of carbon fiber reinforced magnesium matrix composites [J]. Nonferrous Metals , 2011 , 63 ( 1 ): 19 - 22 .

葛德彪 , 闫玉波 . 电磁波时域有限差分方法 [M]. 2 版 . 西安 : 西安电子科技大学出版社 , 2005 : 20 - 23 .

Ge D B , Yan Y B . Finite Difference Time Domain Method for Electromagnetic Waves [M]. 2nd ed . Xi’an : Xidian University Press , 2005 : 20 - 23 .

朱正吼 . 碳纤维复合材料电磁特性研究 [J]. 机械工程材料 , 2001 , 25 ( 11 ): 14 - 16 .

Zhu Z H . Electromagnetic characteristics of carbon fiber composites [J]. Mechanical Engineering Materials , 2001 , 25 ( 11 ): 14 - 16 .

Jiang Y N , Ge D B , Ding S J . Analysis of TF-SF boundary for 2D-FDTD with plane p -wave propagation in layered dispersive and lossy media [J]. Progress in Electromagnetics Research , 2008 , 83 : 157 - 172 .

豆正伟 , 李晓霞 , 赵纪金 . 光谱法研究膨胀石墨红外波段复折射率 [J]. 兵工学报 , 2011 , 32 ( 4 ): 498 - 502 .

Dou Z W , Li X X , Zhao J J . Complex refractive index of infrared band of expanded graphite by spectrometric method [J]. Chinese Journal of Military Engineering , 2011 , 32 ( 4 ): 498 - 502 .

Sadao A . The Handbook on Optical Constants of Semiconductors [M]. Singapore City : World Scientific , 2012 : 78 - 79 .

贺福 . 碳纤维及其应用技术 [M]. 北京 : 化学工业出版社 , 2004 : 343 - 346 .

He F . Carbon Fiber and Its Application Technology [M]. Beijing : Chemical Industry Press , 2004 : 343 - 346 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Effect of gas field pressure on the microstructure and mechanical properties of graphite fibers prepared by laser irradiation

Research progress in the application of lignin-based carbon fiber composite materials in energy storage components

Combining paraffin@silica nanocapsules with carbon fiber to develop a phase change thermal interface material for efficient heat dissipation

Simultaneous measurement of thermal properties and convective heat transfer coefficient of individual carbon fiber using Raman spectroscopy

Viscosity behavior of solution copolymerization of acrylonitrile and itaconic acid:on-line determination and theoretical analysis

Related Author

ZHANG Zhenghe

CHENG Lisheng

TAN Jing

DING Qisheng

SONG Lijian

YANG Weimin

LI Jing

TONG Xin

Related Institution

Institute of Mechanical and Electrical Engineering, Beijing University of Chemical Technology

State Key Laboratory of Organic-Inorganic Composites, Beijing University of Chemical Technology

Department of Mechanical Engineering, Tsinghua University

School of Environmental and Natural Resources, Zhejiang University of Science & Technology

Key Laboratory of Enhanced Heat Transfer and Energy Conservation, Ministry of Education, South China University of Technology

⁰