Study on condensation characteristics of vapor with non-condensable gas in corrugated tubes

Wenhua JIA; Maocheng TIAN; Guanmin ZHANG; Min WEI

doi:10.11949/0438-1157.20190492

您当前的位置：

首页 >

文章列表页 >

Study on condensation characteristics of vapor with non-condensable gas in corrugated tubes

Fluid dynamics and transport phenomena | 更新时间：2020-06-24

- Study on condensation characteristics of vapor with non-condensable gas in corrugated tubes
- CIESC Journal Vol. 70, Issue S2, Pages: 201-207(2019)
- 作者机构：
  
  山东大学能源与动力工程学院，山东济南 250061
- 作者简介：
- 基金信息：
- DOI：10.11949/0438-1157.20190492
  CLC： TK 124
- Received：09 May 2019，
  
  Revised：2019-05-15，
  
  Published：05 September 2019
- 稿件说明：
移动端阅览
贾文华, 田茂诚, 张冠敏, 魏民. 含不凝气体蒸汽波节管内凝结特性研究[J]. 化工学报, 2019, 70(S2): 201-207

JIA Wenhua, TIAN Maocheng, ZHANG Guanmin, WEI Min. Study on condensation characteristics of vapor with non-condensable gas in corrugated tubes[J]. CIESC Journal, 2019, 70(S2): 201-207
贾文华, 田茂诚, 张冠敏, 魏民. 含不凝气体蒸汽波节管内凝结特性研究[J]. 化工学报, 2019, 70(S2): 201-207 DOI： 10.11949/0438-1157.20190492.

JIA Wenhua, TIAN Maocheng, ZHANG Guanmin, WEI Min. Study on condensation characteristics of vapor with non-condensable gas in corrugated tubes[J]. CIESC Journal, 2019, 70(S2): 201-207 DOI： 10.11949/0438-1157.20190492.

摘要

通过数值模拟，研究了波节结构、空气含量及Reynolds数

对含空气的水蒸气波节管内凝结特性的影响，并与圆形换热管内的情况进行了对比。模拟结果表明：空气含量增加，波节管壁面平均传热系数减小；波节管内流体流动和换热过程均呈现振荡波动；波节高度增加，壁面平均传热系数先增加后降低，在波节高度0.032 m达到峰值，而摩擦系数一直增加；波节间距减小，波节宽度增加，壁面平均传热系数及摩擦系数均增大；波节高度对波节管内流动和换热影响均大于波节宽度和波节间距。

Abstract

This paper presents a numerical investigation on the condensation characteristics of vapor with non-condensable gas in corrugated tubes. Several 2D examples with different corrugated structures

air contents and Reynolds numbers are studied and compared. Results show that along with the increase of air content

the wall average heat transfer coefficient decreases in the corrugated tube. The oscillation of fluid flow and heat transfer is generated due to the corrugated structure. With the increasing of wave height

the skin friction coefficient increased

and the wall average heat transfer coefficient first increased

and then decreased

the maximum of wall average heat transfer coefficient in this paper is in 0.032 m. The influence of wave height on the flow and heat transfer characteristics is more obvious than the width of the wave node and the space between two waves. The effect of inlet fluid flow-rate on the skin friction coefficient is also evaluated and discussed to provide some guidelines for future engineering applications.

关键词

Keywords

references

Othmer D F . The condensation of steam [J]. Industrial and Engineering Chemistry , 1929 , 21 ( 6 ): 576 - 583 .

王补宣 , 杜小泽 . 细竖管内流动凝结液膜的稳定性分析 [J]. 化工学报 , 2000 , 51 ( 1 ): 7 - 11 .

Wang B X , Du X Z . Stability analysis of condensation liquid film in fine vertical tube [J]. Journal of Chemical Industry and Engineering (China) , 2000 , 51 ( 1 ): 7 - 11 .

Song W M , Meng J A , Li Z X . Optimization of flue gas convective heat transfer with condensation in a rectangular channel [J]. Chinese Science Bulletin , 2011 , 56 ( 3 ): 263 - 268 .

Huang J , Zhang J , Wang L . Review of vapor condensation heat and mass transfer in the presence of non-condensable gas [J]. Applied Thermal Engineering , 2015 , 89 : 469 - 484 .

王四芳 , 兰忠 , 王爱丽 , 等 . 超疏水表面蒸汽及含不凝气蒸汽滴状冷凝传热实验分析 [J]. 化工学报 , 2010 , 61 ( 3 ): 607 - 611 .

Wang S F , Lan Z , Wang A L , et al . Dropwise condensation of steam and steam-air mixture on super-hydrophobic surfaces [J]. CIESC Journal , 2010 , 61 ( 3 ): 607 - 611 .

周兴东 , 马学虎 , 兰忠 , 等 . 滴状冷凝强化含不凝气的蒸气冷凝传热机制 [J]. 化工学报 , 2007 , 58 ( 7 ): 1619 - 1625 .

Zhou X D , Ma X H , Lan Z , et al . Mechanism of dropwise condensation heat transfer enhancement in presence of noncondensable gas [J]. Journal of Chemical Industry and Engineering (China) , 2007 , 58 ( 7 ): 1619 - 1625 .

Chantana C , Kumar S . Experimental and theoretical investigation of air-steam condensation in a vertical tube at low inlet steam fractions [J]. Applied Thermal Engineering , 2013 , 54 ( 2 ): 399 - 412 .

Li J D . CFD simulation of water vapour condensation in the presence of non-condensable gas in vertical cylindrical condensers [J]. International Journal of Heat and Mass Transfer , 2013 , 57 ( 2 ): 708 - 721 .

Yin Z , Wen J , Wu Y , et al . Effect of non-condensable gas on laminar film condensation of steam in horizontal minichannels with different cross-sectional shapes [J]. International Communications in Heat and Mass Transfer , 2016 , 70 : 127 - 131 .

Kekaula K , Chen Y , Ma T , et al . Numerical investigation of condensation in inclined tube air-cooled condensers [J]. Applied Thermal Engineering , 2017 , 118(Complete): 418 - 429 .

吴峰 . 波纹管内流动与传热三维数值模拟 [J]. 石油化工设备 , 2009 , 38 ( 1 ): 22 - 26 .

Wu F . Three-dimensional numerical simulation of flow and heat transfer in corrugated tubes [J]. Petrochemical Equipment , 2009 , 38 ( 1 ): 22 - 26 .

吴峰 . 空气外掠波纹管束强化传热规律数值计算 [J]. 热能动力工程 , 2009 , 24 ( 4 ): 452 - 456 .

Wu F . Numerical calculation of enhanced heat transfer law of air external swept corrugated bundles [J]. Thermal Energy and Power Engineering , 2009 , 24 ( 4 ): 452 - 456 .

俞接成 , 杜晓萌 . 波纹管层流传热与流动的三维数值模拟 [J]. 北京石油化工学院学报 , 2011 , 19 ( 4 ): 11 - 16 .

Yu J C , Du X M . Three-dimensional numerical simulation of laminar heat transfer and flow in corrugated tubes [J]. Journal of Beijing Institute of Petrochemical Technology , 2011 , 19 ( 4 ): 11 - 16 .

王大成 , 王二利 , 罗小平 . 波纹管结构参数对传热性能影响 [J]. 石油化工设备 , 2014 , 43 ( 1 ): 14 - 17 .

Wang D C , Wang E L , Luo X P . Influence of structural parameters of corrugated tubes on heat transfer performance [J]. Petrochemical Equipment , 2014 , 43 ( 1 ): 14 - 17 .

Wang W , Zhang Y , Li B , et al . Numerical investigation of tube-side fully developed turbulent flow and heat transfer in outward corrugated tubes [J]. International Journal of Heat and Mass Transfer , 2018 , 116 : 115 - 126 .

肖金花 , 钱才富 , 黄志新 . 波纹管传热强化效果与机理研究 [J]. 化学工程 , 2007 , ( 1 ): 12 - 15 .

Xiao J H , Qian C F , Huang Z X . Study on heat transfer enhancement effect and mechanism of corrugated tubes [J]. Chemical Engineering （China） , 2007 , ( 1 ): 12 - 15 .

王补宣 , 杜小泽 . 细圆管内流动凝结换热的实验研究 [J]. 工程热物理学报 , 2000 , 21 ( 3 ): 324 - 328 .

Wang B X , Du X Z . Experimental study on flow condensation heat transfer in thin circular tubes [J]. Journal of Engineering Thermophysics , 2000 , 21 ( 3 ): 324 - 328 .

Cheng F , Yin Z , Dai R , et al . Condensation heat transfer characteristic of high-speed steam/nitrogen mixture in horizontal rectangular channel [J]. Experimental Thermal and Fluid Science , 2016 , 78 ( S0 ): 292 - 300 .

Yi Q J , Tian M C , Yan W J , et al . Visualization study of the influence of non-condensable gas on steam condensation heat transfer [J]. Applied Thermal Engineering , 2016 , 106 : 13 - 21 .

Gu H F , Chen Q , Wang H J , et al . Condensation of a hydrocarbon in the presence of a non-condensable gas: heat and mass transfer [J]. Applied Thermal Engineering , 2015 , 91 : 938 - 945 .

Aroonrat K , Wongwises S . Experimental study on two-phase condensation heat transfer and pressure drop of R-134a flowing in a dimpled tube [J]. International Journal of Heat and Mass Transfer , 2016 , 106 ( S0 ): 437 - 448 .

曾敏 , 王秋旺 , 屈治国 , 等 . 波纹管内强制对流换热与阻力特性的实验研究 [J]. 西安交通大学学报 , 2002 , ( 3 ): 237 - 240 .

Zeng M , Wang Q W , Qu Z G , et al . Experimental study on the pressure drop and heat transfer characteristics in corrugated tubes [J]. Journal of Xi’an Jiaotong University , 2002 , ( 3 ): 237 - 240 .

仝潘 , 范广铭 , 孙中宁 , 等 . 竖直波节管外含空气蒸汽冷凝传热特性研究 [C]//中国核学会核能动力分会反应堆热工流体专业委员会. 第十四届全国反应堆热工流体学术会议暨中核核反应堆热工水力技术重点实验室2015年度学术年会论文集 . 北京 : 中国核学会核能动力分会反应堆热工流体专业委员会 , 2015 .

Tong P , Fan G M , Sun Z N , et al . Study on the condensation and heat transfer characteristics of vapor-air outside the vertical corrugated tubes [C]//Steam Condensation Heat Transfer Characteristics Research of Nuclear Power Branch of China Nuclear Society Reactor Thermal Fluid Professional Committee. The 14th National Conference on Reactor Thermal Fluid and Key Laboratory of Nuclear Reactor Thermal Hydraulic Technology in 2015 Academic Conference . Beijing : Proceedings of China Nuclear Society Nuclear Power Reactor Thermal Fluid Professional Committee of Chapter , 2015 .

Yang D , Sun B , Li H , et al . Experimental study on the heat transfer and flow characteristics of nanorefrigerants inside a corrugated tube [J]. International Journal of Refrigeration , 2015 , 56 : 213 - 223 .

Li X W , Meng J A , Guo Z Y . Turbulent flow and heat transfer in discrete double incline ribs tube [J]. Int . J . Heat Mass Transfer , 2009 , 52 ( 3/4 ): 962 - 970 .

Song W M , Meng J A , Li Z X . Optimization of flue gas convective heat transfer with condensation in a rectangular channel [J]. Chinese Science Bulletin , 2011 , 56 ( 3 ): 263 - 268 .

鹿磊 . 一种高精度简单的湿空气物性经验公式 [J]. 中国科技信息 , 2011 , ( 12 ): 38 - 40 .

Lu L . A high precision empirical formula for simple moist air properties [J]. Technology Information of China , 2011 , ( 12 ): 38 - 40 .

Kuhn S Z , Schrock V E , Peterson P F . An investigation of condensation from steam–gas mixtures flowing downward inside a vertical tube [J]. Nuclear Engineering and Design , 1997 , ( 177 ): 53 - 69 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Characteristics research of the charge-hold-vent method for cryogenic propellant tank chilldown in microgravity

Numerical study on flow boiling heat transfer in asymmetric serrated microchannel structures

Numerical simulation study on the leakage diffusion characteristics and safety monitoring of liquid hydrogen in hydrogen refueling stations

Research on two-phase flow and heat transfer characteristics in precooling process of low-temperature pipelines based on one-dimensional drift-flux model

Numerical study on influence of perforated plate on retention performance of liquid oxygen tank under negative gravity

Related Author

ZHANG Rongda

MA Yuan

WANG Yunlong

WANG Kang

LI Yanzhong

XU Langtao

CUI Shuo

TANG Dawei

Related Institution

Department of Refrigeration and Cryogenic Engineering, Xi’an Jiaotong University

School of Energy and Power Engineering, Dalian University of Technology

School of Safety Science and Engineering, Changzhou University

China Academy of Launch Vehicle Technology Research and Development Center

Institute of Refrigeration and Cryogenics, Shanghai Jiao Tong University

⁰