CPFD simulation on entrained-flow gasifier

Yongshi LIANG; Xianglong ZHAO; Qiang QIN; Cliff Y GUO; Yi CHENG

doi:10.11949/0438-1157.20190376

您当前的位置：

首页 >

文章列表页 >

CPFD simulation on entrained-flow gasifier

更新时间：2026-03-25

- CPFD simulation on entrained-flow gasifier
- CIESC Journal Vol. 70, Issue 9, Pages: 3291-3299(2019)
- 作者机构：
  
  1. 北京低碳清洁能源研究院,北京,102211
  2. 清华大学化学工程系,北京,100084
- 作者简介：
- 基金信息：
- DOI：10.11949/0438-1157.20190376
  CLC： TQ54
- Online First：05 September 2019，
  
  Published：05 September 2019
- 稿件说明：
移动端阅览
Yongshi LIANG, Xianglong ZHAO, Qiang QIN, et al. CPFD simulation on entrained-flow gasifier[J]. CIESC Journal, 2019, 70(9): 3291-3299.
DOI：

Yongshi LIANG, Xianglong ZHAO, Qiang QIN, et al. CPFD simulation on entrained-flow gasifier[J]. CIESC Journal, 2019, 70(9): 3291-3299. DOI： 10.11949/0438-1157.20190376.

摘要

利用CPFD(computational particle fluid dynamics)模拟方法对三维、全尺寸的气流床气化炉进行了模拟计算，建立起了适用于CPFD模拟方法的气化模拟模型。模拟结果与实验数据相一致，说明模型基本准确且CPFD模拟方法适用于气流床气化过程的模拟。借由CPFD模拟方法给出了颗粒相在气化炉中的具体反应历程及颗粒停留时间的概率分布；结果表明，在单喷嘴顶喷的气化炉中，同时存在颗粒相的轴向流动短路及返混，短路主要发生在炉中心区域；颗粒在炉中心区域反应剧烈而边壁区域反应则很缓慢，而且从气化炉流出的第一股短路颗粒主要由充分反应了的粉煤颗粒构成。

Abstract

For the first time

the three-dimensional

full-size entrained flow gasifier was simulated by CPFD（computational particle fluid dynamics） simulation method

and a gasification simulation model suitable for CPFD simulation was established. This validated the model and CPFD simulation used in entrained-flow gasification. The detailed reaction process and the probability distribution of particle residence time were obtained through CPFD simulation. The results show that both particle short-circuit and re-circulation exist in the gasifier using single burner at top. The short-circuit flow is mainly located at the central region of the gasifier. In addition

the particle reaction rate is very fast in the central region but relatively slow near the wall region. Besides

the first amount of particles flowing out of the gasifier mainly consists of the fully-reacted particles.

关键词

Keywords

references

Views

562

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

CPFD simulation of a 10 MWth chemical looping combustion reactor

Methods of adaptive prediction and abnormal states traceability for sulphur content in flue gas desulfurization process

Zn-doped PdO/ZrO2 with rich oxygen vacancies for the synthesis of diphenyl carbonate from CO2 and phenol

Thermo-gas-elastic coupling performance analysis of high-speed and high-temperature foil face seals

Mechanism and regulation of supercooling behavior in imidazolium-based ionic liquids

Related Author

TONG Yongqi

CHENG Jie

LIN Hai

CHEN Xi

ZHAO Haibo

Related Institution

State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology

Zhanjiang Customs Technology Center

⁰