Emergency treatment of crude oil contaminated soil and resource recovery using microemulsion

WANG Long; LIU Hui e; LIU Yutong; YU Yunfei; CHEN Shuang; YU Wenhe; ZHANG Xiuxia

doi:10.11949/0438-1157.20190274

您当前的位置：

首页 >

文章列表页 >

Emergency treatment of crude oil contaminated soil and resource recovery using microemulsion

Energy and environmental engineering | 更新时间：2026-07-24

- Emergency treatment of crude oil contaminated soil and resource recovery using microemulsion
- CIESC Journal Vol. 70, Issue 7, Pages: 2699-2707(2019)
- 作者机构：
  
  1.中国石油大学重质油国家重点实验室，山东青岛 266580
  2.石油石化污染物控制与处理国家重点实验室，北京 102206
  3.中国石油安全环保技术研究院，北京 102206
- 作者简介：
- 基金信息：
- DOI：10.11949/0438-1157.20190274
  CLC： TE 99
- Received：22 March 2019，
  
  Revised：2019-04-12，
  
  Online First：24 July 2026，
  
  Published：05 July 2019
- 稿件说明：
移动端阅览
王龙, 刘会娥, 刘宇童, 于云飞, 陈爽, 于文赫, 张秀霞. 微乳液法用于落地原油应急处理及资源回收的研究[J]. 化工学报, 2019, 70(7): 2699-2707

WANG Long, LIU Hui’e, LIU Yutong, YU Yunfei, CHEN Shuang, YU Wenhe, ZHANG Xiuxia. Emergency treatment of crude oil contaminated soil and resource recovery using microemulsion[J]. CIESC Journal, 2019, 70(7): 2699-2707
王龙, 刘会娥, 刘宇童, 于云飞, 陈爽, 于文赫, 张秀霞. 微乳液法用于落地原油应急处理及资源回收的研究[J]. 化工学报, 2019, 70(7): 2699-2707 DOI： 10.11949/0438-1157.20190274.

WANG Long, LIU Hui’e, LIU Yutong, YU Yunfei, CHEN Shuang, YU Wenhe, ZHANG Xiuxia. Emergency treatment of crude oil contaminated soil and resource recovery using microemulsion[J]. CIESC Journal, 2019, 70(7): 2699-2707 DOI： 10.11949/0438-1157.20190274.

摘要

以十二烷基苯磺酸钠（SDBS）为表面活性剂配制微乳液对落地原油污染土壤进行应急处理及回收原油模拟实验。将原始与回收的原油、土壤进行对比发现：回收土壤的pH略高且大致呈中性，Zeta电位更小，黏粒体积分数减小，微乳液处理对土壤的理化性质影响较小；回收原油中饱和分含量升高，芳香分、胶质和沥青质含量降低，密度与黏度都降低，表明回收所得的是轻质原油。分析了SDBS、正丁醇、NaCl添加量及油水比对原油脱除率的影响，并对筛选出的3种配方微乳液进行温度、循环利用和放大实验检验原油脱除效果的稳定性，最终确定

(SDBS)=10%、

(

-butanol)=4.8%、

(NaCl)=0.8%

、w

(diesel)=12.8%的微乳液为处理落地原油的最优配方。

Abstract

Sodium dodecyl benzene sulfonate (SDBS) was used as a surfactant to prepare microemulsion for emergency treatment of crude oil contaminated soil and recovery of crude oil. Comparison between the original and the recovered crude oil and soil samples was done. It is found that the pH of the recovered soil is slightly higher

the Zeta potential is smaller

the volume fraction of clay reduced

indicating that the microemulsion treatment has little influence on the physical and chemical properties of the soil. The recovered crude oil has higher saturation fraction

lower aromatic

resin and asphaltene content

lower density and viscosity

and belongs to light crude oil. The effects of SDBS

-butanol and NaCl contents on de-oiling effect were investigated. Experiments on effects of oil/water ratio

temperature

recycling and scaling-up were carried out by using the selected three types of microemulsions formula. The optimal microemulsion formula for the de-oiling of crude oil contaminated soil is

(SDBS)=10%

(

-butanol)=4.8%

(NaCl)=0.8%

(diesel)=12.8% .

关键词

Keywords

references

Yang P , Zhou P , Li Y , et al . Recent development in pyrolytic catalysts of oil sludge [J ] . Petroleum Science and Technology , 2018 , 36 ( 2 ): 1 - 5 .

赵红艳 , 韩毅 , 吕娟 , 等 . 三种洗涤剂淋洗落地原油污染土壤的试验研究 [J ] . 东北师大学报(自然科学版) , 2009 , 41 ( 1 ): 123 - 126 .

Zhao H Y , Han Y , Lyu J , et al . Test on three kinds of detergent washing the soils contaminated by crude oil [J ] . Journal of Northeast Normal University (Natural Science Edition) , 2009 , 41 ( 1 ): 123 - 126 .

廉景燕 , 哈莹 , 黄磊 , 等 . 石油污染土壤物化修复前后生物毒性效应 [J ] . 环境科学 , 2011 , 32 ( 3 ): 870 - 874 .

Lian J Y , Ha Y , Huang L , et al . Biological toxicity effect of petroleum contaminated soil before and after physicochemical remediation [J ] . Environmental Science , 2011 , 32 ( 3 ): 870 - 874 .

吴蔓莉 , 张晨 , 祁燕云 , 等 . 生物修复对黄土壤中石油烃的去除作用及影响因素 [J ] . 农业环境科学学报 , 2018 , 37 ( 6 ): 1159 - 1165 .

Wu M L , Zhang C , Qi Y Y , et al . Degradation of petroleum hydrocarbons during the bioremediation of cultivated loessial soil [J ] . Journal of Agro Environment Science , 2018 , 37 ( 6 ): 1159 - 1165 .

Salager J L , Forgiarini A M , Bullón J . How to attain ultralow interfacial tension and three-phase behavior with surfactant formulation for enhanced oil recovery: a review (1): Optimum formulation for simple surfactant-oil-water ternary systems [J ] . Journal of Surfactants and Detergents , 2013 , 16 ( 4 ): 449 - 472 .

李佳 , 曹兴涛 , 隋红 , 等 . 石油污染土壤修复技术研究现状与展望 [J ] . 石油学报(石油加工) , 2017 , 33 ( 5 ): 811 - 833 .

Li J , Cao X T , Sui H , et al . Overview of remediation technologies for petroleum-contaminated soils [J ] . Acta Petrolei Sinica (Petroleum Processing Section) , 2017 , 33 ( 5 ): 811 - 833 .

Kellay H , Binks B P , Hendrikx Y , et al . Properties of surfactant monolayers in relation to microemulsion phase behaviour [J ] . Advances in Colloid & Interface Science , 2017 , 49 : 85 - 112 .

Salager J L , Antón R E , Sabatini D A , et al . Enhancing solubilization in microemulsions state of the art and current trends [J ] . Journal of Surfactants and Detergents , 2005 , 8 ( 1 ): 3 - 21 .

Koneva A S , Safonova E A , Kondrakhina P S , et al . Effect of water content on structural and phase behavior of water-in-oil ( n -decane) microemulsion system stabilized by mixed nonionic surfactants Span 80/Tween 80 [J ] . Colloids and Surfaces A: Physicochemical and Engineering Aspects , 2017 , 518 : 273 - 282 .

Salager J L , Forgiarini A M , Márquez L , et al . How to attain an ultralow interfacial tension and three-phase behavior with surfactant formulation for enhanced oil recovery: a review (2): Performance improvement trends from Winsor s premise to currently proposed inter- and intra-molecular mixtures [J ] . Journal of Surfactants and Detergents , 2013 , 16 ( 5 ): 631 - 663 .

Santanna V C , Curbelo F D S , Castro Dantas T N , et al . Microemulsion flooding for enhanced oil recovery [J ] . Journal of Petroleum Science and Engineering , 2009 , 66 ( 3 / 4 ): 117 - 120 .

Ogino K , Abe M . Microemulsion formation with some typical surfactants [J ] . Surface and Colloid Science , 1993 , 15 : 85 - 123 .

Bera A , Mandal A . Microemulsions: a novel approach to enhanced oil recovery: a review [J ] . Journal of Petroleum Exploration and Production Technology , 2015 , 5 ( 3 ): 255 - 268 .

夏雪 , 刘会娥 , 丁传芹 , 等 . 酸碱性对十二烷基硫酸钠-正丁醇-煤油-水微乳液体系的影响 [J ] . 石油化工 , 2011 , 40 ( 10 ): 1110 - 1114 .

Xia X , Liu H E , Ding C Q , et al . Influence of acidity and alkalinity on sodium dodecyl sulfate- n -butanol-kerosene-water microemulsion system [J ] . Petrochemical Technology , 2011 , 40 ( 10 ): 1110 - 1114 .

夏雪 , 刘会娥 , 夏晔 , 等 . SDS/正丁醇/煤油/水微乳液体系的相转变研究 [J ] . 高校化学工程学报 , 2011 , 25 ( 6 ): 911 - 915 .

Xia X , Liu H E , Xia Y , et al . Phase inversion of sodium dodecyl sulfate (SDS)/ n -butanol/kerosene/water microemulsion system [J ] . J. Chem . Eng. Chinese Univ ., 2011 , 25 ( 6 ): 911 - 915 .

张孝坤 , 刘会娥 , 丁传芹 , 等 . 不同电解质对SDS/正丁醇/煤油/水微乳液体系的影响 [J ] . 高校化学工程学报 , 2013 , 27 ( 6 ): 1089 - 1093 .

Zhang X K , Liu H E , Ding C Q , et al . Influence of different types of electrolyte on sodium dodecyl sulfate/butanol/kerosene/water microemulsion system [J ] . J. Chem . Eng. Chinese Univ ., 2013 , 27 ( 6 ): 1089 - 1093 .

张强 , 汪晓东 , 金日光 . 油酸／氨水-醇-汽油-水微乳体系拟三元相图的分析 [J ] . 北京化工大学学报(自然科学版) , 2001 , 28 ( 2 ): 37 - 39 .

Zhang Q , Wang X D , Jin R G . Analysis on the phase diagrams of pseudo-tricomponent of oleic acid/ammonia-gasoline-alcohol-water microemulsion system [J ] . Journal of Beijing University of Chemical Technology (Natural Science Edition) , 2001 , 28 ( 2 ): 37 - 39 .

周雅文 , 张高勇 , 王红霞 . 汽油微乳化技术研究 [J ] . 日用化学工业 , 2002 , , 32 ( 2 ): 1 - 4 .

Zhou Y W , Zhang G Y , Wang H X . Study on the technology of water-in-gasoline microemulsion [J ] . China Surfactant Detergent & Cosmetics , 2002 , 32 ( 2 ): 1 - 4 .

董松祥 . 微乳化清洁柴油的配制及其性能研究 [D ] . 青岛 : 中国石油大学 , 2010 .

Dong S X . Study on the preparation and performance of energy-saving and clean micro-emulsified diesel oil [D ] . Qingdao : China University of Petroleum , 2010 .

曹建喜 , 罗立文 , 董松祥 , 等 . 微乳柴油的研制及性能 [J ] . 中国石油大学学报（自然科学版） , 2010 , 34 ( 4 ): 152 - 156 .

Cao J X , Luo L W , Dong S X , et al . Preparation and properties of micro-emulsified diesel [J ] . Journal of China University of Petroleum (Edition of Natural Science) , 2010 , 34 ( 4 ): 152 - 156 .

Mcclements D J . Nanoemulsions versus microemulsions: terminology, differences, and similarities [J ] . Soft Matter , 2012 , 8 ( 6 ): 1719 - 1729 .

Jeirani Z , Jan B M , Ali B S , et al . Formulation, optimization and application of triglyceride microemulsion in enhanced oil recovery [J ] . Industrial Crops and Products , 2013 , 43 ( 1 ): 6 - 14 .

Bellocq A M . Effects of alcohol chain length and salt on phase behavior and critical phenomena in SDS microemulsions [M ] // Kumar P, Mittal K L. Handbook of Microemulsion Science and Technology. New York : Marcel Dekker, Inc ., 1999 : 139 - 184 .

Pei G , Zhu Y , Cai X , et al . Surfactant flushing remediation of o -dichlorobenzene and p -dichlorobenzene contaminated soil [J ] . Chemosphere , 2017 , 185 : 1112 - 1121 .

Qiao B W , Ye S , Wu J , et al . Surfactant‐enhanced electroosmotic flushing in a trichlorobenzene contaminated clayey soil [J ] . Ground Water , 2018 , 56 ( 4 ): 673 - 679 .

Guan Z , Tang X Y , Nishimura T , et al . Surfactant-enhanced flushing enhances colloid transport and alters macroporosity in diesel-contaminated soil [J ] . Journal of Environmental Sciences , 2018 , 64 ( 2 ): 197 - 206 .

Hernandez H W , Ehlert W , Trabelsi S . Removal of crude oil residue from solid surfaces using microemulsions [J ] . Fuel , 2019 , 237 : 398 - 404 .

Lowry E , Sedghi M , Goual L . Molecular simulations of NAPL removal from mineral surfaces using microemulsions and surfactants [J ] . Colloids and Surfaces A: Physicochemical and Engineering Aspects , 2016 , 506 : 485 - 494 .

Daoshan L I , Demin W , Wanli K . Interfacial viscoelasticity of water/decan containing resins and asphatenes [J ] . Journal of Chemical Industry & Engineering , 2003 , 54 ( 8 ): 1164 - 1168 .

Liu H E , Zhou P P , Wu Z H , et al . Solubilization behavior of organic mixtures in optimum Winsor type Ⅲ microemulsion systems of sodium dodecyl sulfate [J ] . Journal of Surfactants and Detergents , 2018 , 2 ( 14 ): 497 - 507 .

Liu H E , Wu Z H , Jing J G , et al , Partition of n-butanol among phases and solubilization ability of Winsor type Ⅲ microemulsions [J ] . Journal of Surfactants and Detergents , 2016 , 19 : 713 - 724 .

靖建歌 , 刘会娥 , 丁传芹 , 等 . 内标法研究Winsor Ⅲ型微乳液的醇分布及其增溶参数 [J ] . 化学工程 , 2015 , 43 ( 1 ): 32 - 36 .

Jing J G , Liu H E , Ding C Q , et al . Alcohol distribution and solubilization parameters of Winsor Ⅲ microemulsion using internal standard method [J ] . Chemical Engineering (China) , 2015 , 43 ( 1 ): 32 - 36 .

Javanbakht G , Goual L . Mobilization and micellar solubilization of NAPL contaminants in aquifer rocks [J ] . Journal of Contaminant Hydrology , 2016 , 185 / 186 : 61 - 73 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Preparation of oil-in-water nanoemulsions used for protection ofshale gas reservoirs

Research progress on high-performance α-olefin-based surfactants

Prediction model for COD in petrochemical wastewater influent based on temporal-spatial dual-stream convolutional neural network

Mechanism study on temperature and salt resistance of novel viscoelastic particle-based oil displacement agents

Economic study on the in-situ CO2 enrichment process in FCC regenerators coupled with green electrolysis

Related Author

QIU Zhengsong

DONG Bingqiang

ZHONG Hanyi

WANG Weiji

ZHAO Xin

SONG Dingding

LUO Yang

LIU Tianzi

Related Institution

College of Petroleum Engineering, China University of Petroleum

No.2.Oil Production Plant of Daqing Oilfield

National Key Laboratory of High-Performance Organic Optical Polymers and Advanced Manufacturing Technology, College of Chemical Engineering, Qingdao University of Science and Technology

State Key Laboratory of Heavy Oil Processing, College of Chemical Engineering and Environment, China University of Petroleum

Exploration and Development Research Institute of Shengli Oilfield, SINOPEC

⁰